Tiffin Allegro 2003

Model Allegro made in 2003 by Tiffin got 10 consumer complains there are 6 recalls as well as 6 service bulletins. Consumer complaints with reference, among others things, to electrical system, engine and engine cooling and fuel system, gasoline. Technical service bulletines regarding equipment, equipment adaptive. There were some recalls concerningelectrical system, equipment and service brakes, hydraulic.

Model 2003

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ELECTRICAL SYSTEM
06V142000TIFFIN MOTORHOMES, INC. V (Vehicle)1594ODITIFFIN MOTORHOMES, INC.04/28/200604/28/2006571101 & 105
Defect SummaryCertain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard no. 101, controls and displays, and no. 105, hydraulic and electric brake systems. if the brake fail input falls below a voltage of 1.5v, the brake failure lamp and alarm will be activated. also activation of the abs telltale when the abs is not properly functioning does not always occur.
Consequence SummaryAt night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.
Corrective SummaryTiffin is working with workhorse to contact the owners and remedy this campaign . workhorse will reprogram the instrument panel cluster free of charge. owners may contact workhorse at 1-877-246-7731 or tiffin at 1-256-356-0205.
NotesCustomers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
EQUIPMENT - RECREATIONAL VEHICLE
11V082000TIFFIN MOTORHOMES, INC. V (Vehicle)10683MFRTIFFIN MOTORHOMES, INC.02/08/201102/09/2011
Defect SummaryTiffin motorhomes is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Consequence SummaryThe sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Corrective SummaryTiffin motorhomes is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the safety recall is expected to begin during february 2011. owners may contact norcold at 1-800-767-9101.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
09V443000TIFFIN MOTORHOMES, INC. V (Vehicle)52812/07/2009MFRTIFFIN MOTORHOMES, INC.11/17/200911/17/2009
Defect SummaryTiffin is recalling certain recreational vehicle equipped with norcold model 1200lr and 1200lrim refrigerators, manufactured from december 1, 2001, with serial numbers between 1273701 and 1536607, non-consecutively. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. if a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. at such high temperatures, the cooling unit could rupture.
Consequence SummaryIf a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.
Corrective SummaryTiffin is working with norcold and tiffin will notify owners and the vehicle's refrigerator will be repaired free of charge by norcold. please see norcold's defect report 09e-027. owners may contact norcold's recall center at 1-800-767-9101.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
07V517000TIFFIN MOTORHOMES, INC. V (Vehicle)1143804/06/2007ODITIFFIN MOTORHOMES, INC.11/05/200711/06/2007
Defect SummaryOn certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, these refrigerators may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence SummaryRelease of coolant under certain conditions could ignite and result in a fire.
Corrective SummaryTiffin motorhomes will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or tiffin at 1-256-356-8661.
NotesCustomers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
SERVICE BRAKES, HYDRAULIC
09V110000NAVISTAR, INC V (Vehicle)4887609/16/2010ODITIFFIN MOTORHOMES, INC.04/03/200904/03/2009
Defect SummaryNavistar is recalling certain model year my 2001-2008 workhorse w20, w21 and w22 chassis and certain model year 2009 through 2011 monaco rv admiral, arista, monarch, and riptide recreational vehicles equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. when combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. this can result in abnormal heat generation at the wheel end causing brake drag. the driver would normally have warning of the brake drag if undetected by the driver.
Consequence SummaryThe temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Corrective SummaryWorkhorse dealers will replace all four bosch brake caliper assemblies free of charge. the safety recall began on september 16, 2010. owners may contact workhorse at 1-877-246-7731.
NotesWorkhorse recall no. 50901-c and 51101-c.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING
03V149000TIFFIN MOTOR HOMESfrom 08/01/1999 to 06/30/2003V (Vehicle)117406/02/2003MFRTIFFIN MOTORHOMES, INC.04/14/200305/12/2003571105 S5.3
Defect SummaryCertain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems. the brake system warning indicator may not function as required by standard.
Consequence SummaryIn some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.
Corrective SummaryDealers will repair the brake warning lamp circuit. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact tiffin at 1-256-356-8661.
NotesCustomers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
EQUIPMENT
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT ADAPTIVE
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT - ELECTRICAL - NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
SB-2306/06/200810026732Tiffin motorhomes: a wire is not hooked up and needs to be. the navigational system will work until its program for a destination and get the path to the destination. csc letter was received. *pe12/09/2008
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT - RECREATIONAL VEHICLE
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT - RECREATIONAL VEHICLE - LPG WATER HEATER
SB-2003/29/200810026736Tiffin motorhomes: there is a potential problem with the water heater by pass in your unit. there is a possibility it was incorrectly plumbed. csc letter was received. *pe12/10/2008

Consumer Complaints


Fail datemilesoccurencesPurchase date
ELECTRICAL SYSTEM - WIRING
08/09/2002
 Heater grid is part of engine cooling system. this system didn't turn off and wire was burning. dealership is aware of problem.*ak
ENGINE AND ENGINE COOLING - COOLING SYSTEM
08/09/2002
 Heater grid is part of engine cooling system. this system didn't turn off and wire was burning. dealership is aware of problem.*ak
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE
05/27/20035601402/06/2003
 Motorhome lost power on 4 different occasions and suffered a severe jolt while travelling 60 - 65 mph on 3 diffrerent occasions.*ak
 Intermittent stalling. *ak
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
10/25/200521207103/25/2003
 Dt*: the contact stated while driving 15mph the vehicle stalled twice. both times the vehicle was towed to the dealer where the fuel pump was replaced.
SERVICE BRAKES, HYDRAULIC
10/17/20089221
 In 2008 full loss of brake functioning in our 2003 allegro motorhome with a workhorse chassis going up hill. we had motorhome towed to service center. workhorse refused to take responsibility claiming it was my husband who held the brakes on to long. he is a professional cement truck driver and this is not the case. the brake pads show no wear they were just burned when the brake system failed. we paid to have all brake systems replaced, but now are afraid to drive the coach because after receiving the recall notice it may happen again and we are in fear of our families safety. we continue to make payments on a motorhome we are unable to use due to safety issues workhorse is unable to repair.
04/10/2006100002
 Tl*the contact owns a 2003 tiffin allegro recreational vehicle. while driving less than 60 mph, the brakes failed. the contact depressed the brake pedal and it extended to the floor. he was able to maneuver the vehicle off the road and continued to pump the brakes. the brakes finally became operable after several attempts. he later received a recall notice stating that there was a recall on his unit. the remedy offered a new design on the braking unit; however, the parts would not be immediately available. the failure and current mileages were less than 10,000. updated 06/23/09. *lj the consumer stated the brakes on the rv have failed twice. updated 06/23/09.*jb
05/21/2009245001
 Brake lockup after hard stop being required. brakes worked correctly and smoothly for over 100 miles, but i had a situation where had i tried and finish my left turn (two lane highway) i would have been hit in the side by a semi-truck that decided to pass. i had the left turn signal on and was driving slow in order to make my turn when i saw the semi, at which time i pulled over to the right and hit my brakes. i then drove approx. 2-3 miles to my destination and that is when the brakes heated up, as you could smell them. *tr
05/03/20061800103/03/2006
 Tl*the contact owns a 2003 tiffin allegro rv. while driving approximately 40 mph on normal road conditions, the vehicle failed to slow down when the brake pedal was depressed. suddenly, after pumping the brakes several times, the vehicle came to a complete stop. the abs warning indicator illuminated on the instrument panel and remained lit until the engine was turned off. the vehicle was taken to an authorized dealer for inspection and they stated that there was brake failure. the technician replaced the brake system; however, the failure recurred. the vin was excluded from nhtsa campaign id number 03v149000 (service brakes, hydraulic;switches:brake warning), although the failures were identical. the vehicle has not been repaired. the failure mileage was 1,800 and current mileage was 9,600.updated 01/09/09. *lj updated 01/12/09. *jb
SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING
04/10/2006100002
 Tl*the contact owns a 2003 tiffin allegro recreational vehicle. while driving less than 60 mph, the brakes failed. the contact depressed the brake pedal and it extended to the floor. he was able to maneuver the vehicle off the road and continued to pump the brakes. the brakes finally became operable after several attempts. he later received a recall notice stating that there was a recall on his unit. the remedy offered a new design on the braking unit; however, the parts would not be immediately available. the failure and current mileages were less than 10,000. updated 06/23/09. *lj the consumer stated the brakes on the rv have failed twice. updated 06/23/09.*jb

Car dealers selling


StateCityZipNamePhone
ILSHOREWOODRICKS RV
TXALVARADO76009MOTORHOME SPECIALIST INC