Tiffin Allegro Bus 2002
Model Allegro Bus made in 2002 by Tiffin got 3 consumer complains there are 2 recalls as well as 5 service bulletins. Consumer complaints with reference, among others things, to fuel system, diesel, fuel system, other and tires. Technical service bulletines regarding equipment, equipment adaptive. There was one recall concerning equipment .
Model 2002
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 09V443000 | TIFFIN MOTORHOMES, INC. | V (Vehicle) | 528 | 12/07/2009 | MFR | TIFFIN MOTORHOMES, INC. | 11/17/2009 | 11/17/2009 | ||||||||
| Defect Summary | Tiffin is recalling certain recreational vehicle equipped with norcold model 1200lr and 1200lrim refrigerators, manufactured from december 1, 2001, with serial numbers between 1273701 and 1536607, non-consecutively. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. if a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. at such high temperatures, the cooling unit could rupture. | |||||||||||||||
| Consequence Summary | If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. | |||||||||||||||
| Corrective Summary | Tiffin is working with norcold and tiffin will notify owners and the vehicle's refrigerator will be repaired free of charge by norcold. please see norcold's defect report 09e-027. owners may contact norcold's recall center at 1-800-767-9101. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 07V517000 | TIFFIN MOTORHOMES, INC. | V (Vehicle) | 11438 | 04/06/2007 | ODI | TIFFIN MOTORHOMES, INC. | 11/05/2007 | 11/06/2007 | ||||||||
| Defect Summary | On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, these refrigerators may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
| Consequence Summary | Release of coolant under certain conditions could ignite and result in a fire. | |||||||||||||||
| Corrective Summary | Tiffin motorhomes will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or tiffin at 1-256-356-8661. | |||||||||||||||
| Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| EQUIPMENT | |||||
| SB-21 | 03/18/2008 | 10026734 | Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe | 12/09/2008 | |
| EQUIPMENT ADAPTIVE | |||||
| SB-21 | 03/18/2008 | 10026734 | Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe | 12/09/2008 | |
| EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
| SB-21 | 03/18/2008 | 10026734 | Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe | 12/09/2008 | |
| EQUIPMENT - RECREATIONAL VEHICLE | |||||
| SB-21 | 03/18/2008 | 10026734 | Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe | 12/09/2008 | |
| EQUIPMENT - RECREATIONAL VEHICLE - LPG WATER HEATER | |||||
| SB-20 | 03/29/2008 | 10026736 | Tiffin motorhomes: there is a potential problem with the water heater by pass in your unit. there is a possibility it was incorrectly plumbed. csc letter was received. *pe | 12/10/2008 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, DIESEL | |||
| 01/16/2008 | 48000 | 1 | 05/10/2007 |
| Cummins lsc serial#46171810, diesel fuel lift pump 2002 alegro bus rv weather cold. fuel lift pump lost gasket between mounting bracket and pump, causing fuel to drain onto starter and then ground. have seen problem many times in past as i'm a diesel mechanic. most always in cold weather. same problem each time,loss of gasket, pump still functioning. fuel leak onto starter is enough to cause fear of starter igniting fuel. fire danger is in my opinion very high! my rv was parked in drive with no apparent leak. key must be in on position to raise landing gear,motor not running. the 5-10 minutes i took to raise the landing gear, motor was not started, left a puddle on my driveway of about an 18-24 circle. i do not know the quantity of diesel fuel that was in this circle, but i do know if it had caught fire my rv would have been a total loss before help could arrive. again, i've been a mechanic for many years and have seen this failure numerous times. the replacement pump is supplied with the mounting bracket installed. new pump must not be removed from bracket as the gasket will not set in twice. i purchased the first one i replaced twice. paid for it twice as well. cummins does not give any instructions with the new pump, nor will they take one back that has been separated from it's base. cummins is very aware of this problem, as they have service bulletins out for it. the web also comes up with results from a school bus site discussing a recall. this recall lists rvs in it as well. recall#05e-007 i don't expect an answer to this complaint, but would like some sort of acknowledgement it was recieved. i will be going to bat with cummins in amarillo texas on monday morning the 21st of january 2008. i'm expecting a heated discussion, as i know first hand the cost and difficultly of this repair. one more time i'll make this repair in the cold and where the truck stopped. les drummond *tr | |||
| FUEL SYSTEM, OTHER - DELIVERY - FUEL PUMP | |||
| 01/16/2008 | 48000 | 1 | 05/10/2007 |
| Cummins lsc serial#46171810, diesel fuel lift pump 2002 alegro bus rv weather cold. fuel lift pump lost gasket between mounting bracket and pump, causing fuel to drain onto starter and then ground. have seen problem many times in past as i'm a diesel mechanic. most always in cold weather. same problem each time,loss of gasket, pump still functioning. fuel leak onto starter is enough to cause fear of starter igniting fuel. fire danger is in my opinion very high! my rv was parked in drive with no apparent leak. key must be in on position to raise landing gear,motor not running. the 5-10 minutes i took to raise the landing gear, motor was not started, left a puddle on my driveway of about an 18-24 circle. i do not know the quantity of diesel fuel that was in this circle, but i do know if it had caught fire my rv would have been a total loss before help could arrive. again, i've been a mechanic for many years and have seen this failure numerous times. the replacement pump is supplied with the mounting bracket installed. new pump must not be removed from bracket as the gasket will not set in twice. i purchased the first one i replaced twice. paid for it twice as well. cummins does not give any instructions with the new pump, nor will they take one back that has been separated from it's base. cummins is very aware of this problem, as they have service bulletins out for it. the web also comes up with results from a school bus site discussing a recall. this recall lists rvs in it as well. recall#05e-007 i don't expect an answer to this complaint, but would like some sort of acknowledgement it was recieved. i will be going to bat with cummins in amarillo texas on monday morning the 21st of january 2008. i'm expecting a heated discussion, as i know first hand the cost and difficultly of this repair. one more time i'll make this repair in the cold and where the truck stopped. les drummond *tr | |||
| TIRES | |||
| 06/04/2008 | 1 | ||
| On may 19, 2008 we purchased 4 new tires from ganin tire in middletown, ny for our motorhome. on may 30 we drove to massachusetts. while the vehicle was parked, my husband noticed cracks in one of the tires. upon checking with our tire information brochure that came with the vehicle, my husband discovered that the tires may, in fact, be 10 years old, although we purchased them 2 weeks ago and the invoice also noted that they were new. while we were in massachusetts. my husband called michelin and they also confirmed that the dot numbers indicated that the tires were built in 1998. as we were driving to get back home to go back to the originating dealer for the tires, the back right tire blew out the inner sidewall. we got off the road and called for roadside assistance. we had to purchase another tire which was installed at the side of the road and then we drove to the nearest michelin dealer. we were told that all tires we dry-rotten, the belt in the tire that failed was rusted and the dealer in massachusetts indicated that all tires were used as the tread depth indicated that the tires were worn way beyond 300 miles (approx 11/32 tread-depth and michelin indicated that new tread depth is 16.4/32). we replaced all tires and we kept all tires that were taken off. we are also contacting michelin management. please note that this was not a failure of a michelin tire, but a failure of the dealer by selling old, used tires as new. *tr | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| NY | MIDDLETOWN | 10940 | GANIN TIRE | 845-342-3941 |