Tiffin Zephyr 2002

Model Zephyr made in 2002 by Tiffin got 1 consumer complain there are 3 recalls as well as 8 service bulletins. Consumer complaints with reference to structure. . Technical service bulletines regarding equipment, equipment adaptive and unknown or other. There was one recall concerning equipment .

Model 2002

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
EQUIPMENT - RECREATIONAL VEHICLE
11V082000TIFFIN MOTORHOMES, INC. V (Vehicle)10683MFRTIFFIN MOTORHOMES, INC.02/08/201102/09/2011
Defect SummaryTiffin motorhomes is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Consequence SummaryThe sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Corrective SummaryTiffin motorhomes is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the safety recall is expected to begin during february 2011. owners may contact norcold at 1-800-767-9101.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
09V443000TIFFIN MOTORHOMES, INC. V (Vehicle)52812/07/2009MFRTIFFIN MOTORHOMES, INC.11/17/200911/17/2009
Defect SummaryTiffin is recalling certain recreational vehicle equipped with norcold model 1200lr and 1200lrim refrigerators, manufactured from december 1, 2001, with serial numbers between 1273701 and 1536607, non-consecutively. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. if a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. at such high temperatures, the cooling unit could rupture.
Consequence SummaryIf a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.
Corrective SummaryTiffin is working with norcold and tiffin will notify owners and the vehicle's refrigerator will be repaired free of charge by norcold. please see norcold's defect report 09e-027. owners may contact norcold's recall center at 1-800-767-9101.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
07V517000TIFFIN MOTORHOMES, INC. V (Vehicle)1143804/06/2007ODITIFFIN MOTORHOMES, INC.11/05/200711/06/2007
Defect SummaryOn certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, these refrigerators may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence SummaryRelease of coolant under certain conditions could ignite and result in a fire.
Corrective SummaryTiffin motorhomes will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or tiffin at 1-256-356-8661.
NotesCustomers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
EQUIPMENT
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT ADAPTIVE
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT - ELECTRICAL - NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
SB-2306/06/200810026732Tiffin motorhomes: a wire is not hooked up and needs to be. the navigational system will work until its program for a destination and get the path to the destination. csc letter was received. *pe12/09/2008
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
SB-1902/06/200810026731Tiffin motorhomes: there should be more support on the zephyr bedslide to keep undue stress from cracking the wall. *pe12/09/2008
EQUIPMENT - RECREATIONAL VEHICLE
SB-2103/18/200810026734Tiffin motorhomes: switch box grounding lug. the tap screw is not tight enough. this could cause problems at the load center causing a loss of ground. csc letter was received. *pe12/09/2008
EQUIPMENT - RECREATIONAL VEHICLE - LPG WATER HEATER
SB-2003/29/200810026736Tiffin motorhomes: there is a potential problem with the water heater by pass in your unit. there is a possibility it was incorrectly plumbed. csc letter was received. *pe12/10/2008
UNKNOWN OR OTHER
SB-1902/06/200810026731Tiffin motorhomes: there should be more support on the zephyr bedslide to keep undue stress from cracking the wall. *pe12/09/2008

Consumer Complaints


Fail datemilesoccurencesPurchase date
STRUCTURE
12/01/2004606/01/2002
 The coach's storage door leaked which caused the wiring, fuses and 2000 amp inverter to get wet. this resulted in shorts and electrical failures. *nm the electrical failure included the windshield wipers, turn signal, dash gauges, headlight and taillights (2002 tiffin zephyr). *nm

Car dealers selling


StateCityZipNamePhone
ALRED BAYTIFFIN SERVICE DEPARTMENT256-356-8661