Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
AIR BAGS | |||||
TSB-0122-11 | 09/06/2011 | 10042555 | Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe | 12/16/2011 | |
TSB-0162-10 | 06/23/2010 | 10034130 | Toyota: supplemental restraint systems. some model vehicles may exhibit an srs lamp on condtion with diagnostic trouble code (dtc) b0111 and/or b0116. an updated repair procedure is available to address this condition. *pe | 10/18/2010 | |
T-SB-0252-08 | 08/14/2008 | 10026564 | Toyota: for vehicles that exhibit diagnostic trouble code (dtc) b0111 and/or b0116, a new service part has been made available for 05-08 model year sienna vehicles. *pe | 11/08/2008 | |
AIR BAGS - FRONTAL - SENSOR/CONTROL MODULE | |||||
EL001-08 | 03/18/2008 | 10024292 | Repair manual supplement: srs light [on] - dtc b0111/b0116 - open side squib circuit. *nj updated 5/1/08. *nj | 04/02/2008 | |
AIR BAGS - SIDE/WINDOW | |||||
TSB-0069-12 | 05/01/2012 | 10044579 | Toyota: updated information provided regarding the repairing procedures available for floor wire harness and replace/repair side airbag squib circuit, depending on production date. *pe | 07/17/2012 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
AIR BAGS | |||
08/09/2012 | 116000 | 1 | |
The airbag light came on in the dashboard; took the van to local dealer they diagnosed code p0116 2 part repair replacement of lf side air bag assembly and wiring harness replacement which cost over $1100; *tr | |||
08/09/2012 | 116000 | ||
The airbag light came on in the dashboard; took the van to local dealer they diagnosed code p0116 2 part repair replacement of lf side air bag assembly and wiring harness replacement which cost over $1100; | |||
10/26/2012 | 39569 | 1 | |
Air bag light is flashing. *tr | |||
10/26/2012 | 39569 | ||
Air bag light is flashing. | |||
08/03/2011 | 1 | ||
Had 2007 sienna serviced for blinking air bag light at toyota dealership. service dept. stated that the sensor needed to be cleaned; charge was roughly $100 as the vehicle was over the 60,000/5 yr warranty. on 05/29/2012 car was serviced again for blinking air bag light; however, service dept. stated that the light was not blinking at the time the car was serviced, so the problem could not be assessed. the air bag light came on again for the third time and we were informed that the wire on the passenger side needed to be replaced at a cost of $1,100. funny how the light keeps coming on, but the problem could never be assessed, and now it costs $1,100 to fix. needless to say, we are not having it fixed and we pray for no accidents--pretty scary. we have had nothing but problems with this vehicle and we will never purchase another toyota. *tr | |||
08/03/2011 | |||
Had 2007 sienna serviced for blinking air bag light at toyota dealership. service dept. stated that the sensor needed to be cleaned; charge was roughly $100 as the vehicle was over the 60,000/5 yr warranty. on 05/29/2012 car was serviced again for blinking air bag light; however, service dept. stated that the light was not blinking at the time the car was serviced, so the problem could not be assessed. the air bag light came on again for the third time and we were informed that the wire on the passenger side needed to be replaced at a cost of $1,100. funny how the light keeps coming on, but the problem could never be assessed, and now it costs $1,100 to fix. needless to say, we are not having it fixed and we pray for no accidents--pretty scary. we have had nothing but problems with this vehicle and we will never purchase another toyota. | |||
02/10/2012 | 49550 | ||
Flashing airbag light in 2007 sienna with ~49k miles. dealer suggested replace floor wire and air bag assembly - $3500 total. not under warranty; error code b0116. many similar complaints found on the internet for 06/07 siennas. cannot believe that toyota does not stand behind its airbags more than the basic warranty when safelty equipment failed less than 50k miles. the repair cost is too high which is a result of bad design. safety equipment failure should be responsible by manufacture, especially the milage is less than 50k. have owned numerous vehicles with no airbag problems ever. | |||
02/20/2012 | 90000 | ||
Flashing airbag light in 2007 sienna with ~90k miles. dealer states front passenger airbag sensor failure - $700 to replace. not under warranty; error code b0111. many similar complaints found on the internet for 06/07 siennas. opted not to replace sensor due to concerns about it failing again. cannot believe that toyota does not stand behind its airbags more than the basic warranty. have owned numerous vehicles (94 acura for 7 yrs; 96 mazda for 7 yrs; 01 bmw for 8 yrs; 03 acura for 9 yrs) with no airbag problems ever. no one in my or my wife's family has ever had an airbag problem similar to this. | |||
12/03/2011 | 90000 | ||
Tl* the contact owns a 2007 toyota sienna. the contact stated that the air bag light remained illuminated. the vehicle was taken to the dealer where the dealer performed a diagnostic and located the failure at the passenger air bag sensor. the passenger air bag sensor disabled the air bag system. the manufacturer was made aware of the failure but the vehicle was not repaired. the failure and the current mileage was 90,000. | |||
12/03/2011 | 90000 | ||
Tl-the contact owns a 2007 toyota sienna. the contact stated that the air bag light remained illuminated. the vehicle was taken to the dealer where the dealer performed a diagnostic and located the failure at the passenger air bag sensor. the passenger air bag sensor disabled the air bag system. the manufacturer was made aware of the failure but the vehicle was not repaired. the failure and the current mileage was 90,000. kmj | |||
12/03/2011 | 90000 | ||
Tl-the contact owns a 2007 toyota sienna. the contact stated the air bag light remained illuminated. the vehicle was taken to the dealer. the dealer performed a diagnostic which located the failure at the passenger air bag sensor. the passenger air bag sensor disable the air bag system. the manufacturer was made aware of the failure. the vehicle was not repaired. the failure and the current mileage was 90,000. li | |||
06/08/2011 | 69000 | ||
I have a 2007 toyota sienna van. the srs light intermittently comes on. i took it in for general maintainance as well as to check the air bags. i got an error code of bo111 and was told it would be several hundred to fix. i chose not to have it fixed at this time as it was the passenger side. now the light has gone off. im not sure if in fact it is an airbag problem or electrical. i was also in an accident in 2009 which i could not even open my door and the vehicle was not driveable and the airbags did not deploy. toyota is looking into this. hopefully, it will be covered because i do believe this is a manufacturers issue. | |||
02/11/2011 | 67000 | ||
Srs warning light continued flashing after start up. dealer confirmed error code b0111. passengers air bag and harness needs replaced. these items are covered with updated parts in a toyota tsb 0162-10, dated 02/27/2008, covering sienna model years 2004 through 2008. over one hundred similar occurrences are found on various safety related and owner based internet sites. this is an obvious oem defect of a critical vehicle system that toyota has been aware of for some time now. | |||
08/28/2010 | 65000 | ||
My name is brandon and i have a 2007 toyota sienna with an airbag light that intermitantly comes on and off. as a mechanic, i researched my airbag light diagnostic trouble code b0111 open in side squib rh circuit and there is a tsb on repairing the airbag light. it says to replace the airbag assembly in the passenger front seat. as mechanic, i know that when the airbag light is on, the airbags will not deploy in an emergency situation. therefore, i dont see why a saftey issue such as this is not a recall. so instead of a recall, i must now spend $900 on just the airbag, nevermind the cost to install it? i do not believe that i should be responsible for such a costly repair due to the fact that this is a safety issue that i could not have prevented. the tsb number is t-sb-0252-08 from my repair program, mitchell on demand and it says toyota's reference number is el001-08 | |||
AIR BAGS - SIDE/WINDOW | |||
01/01/1901 | 1 | ||
2007 toyota van. consumer states she was hit on the driver's side by another vehicle and the airbags did not deploy *tgw the consumer stated she hit her head on the window. *jb |