Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN - AXLE ASSEMBLY | |||||
| DL00203 | 08/06/2003 | 10003561 | Rear axle seal design change. *tt | 10/23/2003 | |
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||||
| 5097B | 06/08/2005 | 10015473 | Differential locking system - suspension and axle. repair manual correction. 00400-rm921-u2. *tt | 07/25/2005 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 12/28/2009 | 42000 | 1 | |
| Gas tank shield severely rusted. under side of gastank is protected by a shield/skid plate. it is rusted so badly that when hit with a hammer the hammer goes right through. presumably this shield is to protect the gas tank from debris and stones especially if the truck is used off road. i discovered this as i was inspecting the underside of the truck before dropping the truck off at the dealer to have the frame replaced. in addition to this, it is apparent that the drive axle and differential housing also have severe rust. if tapped with a hammer the rust comes of in sheets. the parking brakes actuating levers have rusted in place and can no longer be used. there appears to be more to this rust than simple frame rust. the rust is pervasive through out the underside of the truck. *tr | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 10/15/2004 | 76000 | 1 | 08/15/2002 |
| Transmission-power train.while driving in low speed situations the vehicle's transmission shifts from 1st to 2nd.....back and forth from 1st to 2nd and 2nd to 1st. i took the vehicle to the dealer and they advised that they couldn't find anything wrong with it. it has 76k miles on it. i was just wondering if anyone else was having this problem.*akl | |||
| 07/01/2004 | 0 | 1 | 06/01/2004 |
| Power train - just bought my truck about 3 months ago. during the test drive, i was extremely impressed by the ride of my tacoma. a few weeks after i had it, i started to experience the clunking sound coming from underneath. i have to the dealership 3 times now, and everytime i have been told was normal. i was told all automatic transmissions do this. this is the second toyota truck i have owned, and i could tell you this, they don't come up with a resolution, it will be my last. i also drive a celica (great car), but if i lose the truck, then i losing the celica, and will want nothing to do with toyota's again!!! *ak | |||
| 06/03/2004 | 1 | 10/05/2001 | |
| Transmission/driveshaft experiences loud clunk noise when brakes are applied then released. this is a known problem to toyota however they offer no resolution. research has indicated adding leaf springs to stiffen rear suspension resloves this issue toyota will not do this modification. *jb | |||
| 08/05/2003 | 20000 | 04/11/2002 | |
| My 2002 tacoma vibrates at high speeds and when stopping. i've had the brakes fixed 5 times now and it's still not right. my transmission clunks when i stop and start, shutters when coming to a stop, and shifts hard. sometimes the transmission clunks after i've already started moving. the problems started about a year ago. i've recently been to two dealerships before the warranty expired and nothing was done. one toyota technician said it was my brakes, yeah right, the other wouldn't even take it for a test drive. i think the problem is caused by my transmission sliding back and forth, which i don't think it's supposed to do. whenever i stomp on the gas to pass someone it shifts into the wrong gear and the engine red lines. my dash squeaks, so i have to wedge my wallet in between the windshield and dash to stop it. my driver's side door doesn't shut flush with the body. last but not least, i had to replace my oxygen sensor. i would like to sell my truck, but can't with all the problems. this was my first toyota and will probably be my last. | |||
| 12/18/2002 | 5000 | 06/09/2002 | |
| For the last year i have brought truck back to sf toyota dealership for transmission problems , suspension problems rattling dash board, squeaking sounds from seat and front bushings. all these problems still have not been fixed. after 15 visits to dealership, sf toyota left scratches on body and lost mud flap. body now tilted after service. *nlm | |||
| 03/15/2003 | 3000 | 1 | 12/15/2001 |
| Transmission clunks on stops and surges after brake is released from stop. feels like you've been rear ended. dealer said this is normal, they all do it. i contacted toyota hq and they refused to comment on problem. vehicle value is greatly diminished. *jb | |||
| 12/30/2002 | 0 | 0 | 07/01/2002 |
| The automatic transmission shifts too soon, making the engine struggle and vibrate at low rpms. while still under warranty, i took it to the dealership and they said all the new 4 cylinder trucks were like this. at 12000 miles, the valves are tapping at idle, and the hood vibrates. seeing the other complaints on this forum, i now remember how squirly the truck gets after going over bumps. that would explain the bad front shocks. i hope i don't get into a bad accident knowing the air bags are not going to work. | |||
| 12/17/2002 | 5009 | 06/09/2002 | |
| Brought truck to toyota service for 5000 mile service reported auto trans jump in gear shift from 1st to second (mechanic said needed new transmission, after leaving service station noticed truck wasn't driving properly brought truck back mechanic said needs new front shock and rear shock. now it did not need new transmission even though it still jumps from gear to gear. | |||
| 01/01/2002 | |||
| Transmission clunks on stops and surges after brake is released from stop. dealer said this is normal. i contacted toyota hq and they refused to comment on problem. said dealer is the expert. i guess the expertise of the design of the vehicle is left up to the dealers not toyota.*ak | |||
| 12/01/2001 | |||
| After about 1100 miles we started to get a bad shudder when setting of, toyota said this normal, the truck as now started to shudder going from 1st to 2nd, toyota said this is normal, then the engine started to vibrate through the cab at 3000 miles,toyota said this is normal, the transmission then started hard shifting,changing up,the later changing down, now when pulling grades and the transmission goes into 4th gear there is a vibration all through the drive line and cab, when in cruise the transmission hunts up and for no reason, toyota says all this is perfectly normal although 2 toyota techs agreed there is a problem 2 independant garages said there is a problem, every time we take it for repair to the dealership toyota tells us there is nothing wrong even though the dealership as said there is a problem toyota refuses to do anything.*ak | |||
| 11/01/2001 | |||
| Transmission line blew off, causing vehicle to stop accelerating. dealer was notified. mechanic replaced hoses and added a clamp.*ak | |||
| POWER TRAIN - AXLE ASSEMBLY | |||
| 07/01/2011 | 2 | ||
| 2002 toyota tacoma. consumer states in 2010 while backing out of the backyard, the left wheel axle broke *tgw the consumer stated the exact same thing happened on july 1, 2011, only it happened on the opposite side. the consumer stated the tire twisted and the truck skidded into oncoming traffic. *jb | |||
| POWER TRAIN - DRIVELINE | |||
| 05/23/2007 | 61923 | 7 | 02/25/2006 |
| The toyota tacoma had a rear axle wrap up, this was where the two piece driveshaft becomes loose at the spleen and caused a clung or looseness in the drive line, which caused undue stress on the engine and the transmission, which could cause the driveshaft to break at the yoke and fall to ground, causing an accident. this was getting progressively worse on the truck. i have taken the car under warranty to the dealer. they dismissed it as normal. this was not normal. it was a flaw in the springs they used on the truck.*ak | |||
| POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
| 05/23/2007 | 61923 | 7 | 02/25/2006 |
| The toyota tacoma had a rear axle wrap up, this was where the two piece driveshaft becomes loose at the spleen and caused a clung or looseness in the drive line, which caused undue stress on the engine and the transmission, which could cause the driveshaft to break at the yoke and fall to ground, causing an accident. this was getting progressively worse on the truck. i have taken the car under warranty to the dealer. they dismissed it as normal. this was not normal. it was a flaw in the springs they used on the truck.*ak | |||
| 02/25/2005 | 30000 | 5 | 02/10/2005 |
| My toyota tacoma has what toyota refers to as rear axle wrap up, where the two piece drive shaft becomes loose at the spline and causes a clunk or looseness in the driveline which cause undue stress on the engine and the transmission, which could cause the drive shaft to break at the yoke and fall to ground causing accident.*jb | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 03/01/2011 | 145000 | ||
| Rusted out rear differential - 2002 toyota tacoma | |||
| 09/18/2006 | 55000 | 1 | |
| My experience with manual transmission on my current and previous toyota pick-up trucks was not very good. first my previous, earlier model 98 toyota tacoma 2wd manual transmission had failed at about 55,000 miles just prior to the 60,000 mile powertrain warranty limit. the failure happened at the synchronizer from 4th to 5th gear when shifting from neutral according to toyota technician at the time. the safety issue on this is that while driving and one needs to shift to 5th gear from neutral, one may have difficulty shifting and the transmission could have a catastrophic failure and at such freeway speed the vehicle could suddenly stall, stop and may go in a tailspin. previous dealer where i bought the vehicle from repaired the transmission per the warranty. now i have another toyota tacoma pick-up 4x4 having the same problem. i took it to the a toyota dealer previously since it was still under warranty for powertrain and around 55,000 miles but dealer refused to take a look at the problem even after repeated attempts to get the problem corrected. i informed them that i have a similar problem before and they have fixed it. but this time around they refused. i have attempted several times from sep 2006 until jan 2007 and even called toyota usa reps on the issue. i still own the truck and to get around the synchronizer problem, i have to downshift back to 3rd, 4th before i can go back to 5th gear. this can cause a lot of distraction while driving and to con unwitting driver unaware of what to do suddenly shifts to 5th from neutral the manual transmission squeaks/rattles like the sound of gears having problem meshing or breaking - thus in a worst case scenario one may loose driveability and capability to move the vehicle since the drive could get lost and may result in a failure. i kind a give up on it since the dealers and toyota usa before don't want to pay attention to me. i know this current toyota recall may result in them looking into this - safety issue. *tr | |||