Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | ||||||||||||||||
| 10V017000 | TOYOTA MOTOR NORTH AMERICA, INC. | from 01/04/2007 to 01/21/2010 | V (Vehicle) | 2230661 | 03/16/2010 | MFR | TOYOTA MOTOR CORPORATION | 01/21/2010 | 01/21/2010 | |||||||
| Defect Summary | Toyota is recalling certain model year 2005-2010 avalon, model year 2007-2010 camry, model year 2009-2010 corolla, corolla matrix, rav4, model year 2010 highlander, model year 2008-2010 sequoia, and model year 2007-2010 tundra vehicles. due to the manner in which the friction lever interacts with the sliding surface of the accelerator pedal inside the pedal sensor assembly, the sliding surface of the lever may become smooth during vehicle operation. in this condition, if condensation occurs on the surface, as may occur from heater operation (without a/c) when the pedal assembly is cold, the friction when the accelerator pedal is operated may increase, which may result in the accelerator pedal becoming harder to depress, slower to return, or, in the worst case, mechanically stuck in a partially depressed position. | |||||||||||||||
| Consequence Summary | The accelerator pedal may become hard to depress, slow to return to idle, or, in the worst case, mechanically stuck in a partially depressed position, increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Dealers will install a reinforcement bar in the accelerator pedal which will allow the pedal to operate smoothly. gm will notify owners for the pontiac vibe please see 10v-018. this service will be performed free of charge. the safety recall is expected to begin early february and will be completed in late april 2010. owners may contact toyota at 1-800-331-4331. | |||||||||||||||
| Notes | Toyota safety recall no. aoa. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 09V388000 | TOYOTA MOTOR NORTH AMERICA, INC. | V (Vehicle) | 4260319 | 10/08/2009 | MFR | TOYOTA MOTOR CORPORATION | 10/05/2009 | 10/06/2009 | ||||||||
| Defect Summary | Toyota is recalling certain model year 2004-2010 passenger vehicles. the accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat. | |||||||||||||||
| Consequence Summary | A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death. | |||||||||||||||
| Corrective Summary | Toyota filed an amended defect report on november 25, 2009, stating that dealers will modify the accelerator pedal and, on certain vehicles, alter the shape of the floor surface under the pedal. these changes address the risk of pedal entrapment due to interference with the floor mat. redesigned accelerator pedals will become available beginning in april 2010 and dealers will replace any modified pedal with the new pedal if desired. also, dealers will replace any genuine toyota or lexus all-weather floor mats with redesigned all-weather mats, or repurchase the previous mats from owners who do not want the new ones. additionally, software modifications will be installed on camry, avalon and lexus es 350, is 350 and is 250 models that will ensure that the brake overrides the accelerator in the event both brake and accelerator pedals are applied. toyota will begin mailing letters to owners in december 2009. owners may contact toyota at 1-800-331-4331, lexus at 1-800-255-3987. | |||||||||||||||
| Notes | Toyota recall no. 90l/90lg.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | |||||
| TSB-0087-12 | 06/13/2012 | 10045140 | Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe | 08/21/2012 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| VEHICLE SPEED CONTROL | ||||||
| RQ10003 | TOYOTA MOTOR CORPORATION | 02/16/2010 | UNINTENDED ACCELERATION | |||
| On september 26, 2007, toyota filed a defect information report and notified nhtsa that some of its model year (my) 2007 and 2008 lexus e350 and toyota camry vehicles could experience unintended and uncontrolled acceleration due to interference between the optional all weather floor mat offered on those vehicles and the vehicles' accelerator pedal.this decision was influenced by an office of defects investigation (odi) engineering analysis.this recall was designated 07e082.two years later, on october 5, 2009, toyota filed a defect information report and notified nhtsa that a number of its my 2004-2009 lexus and toyota vehicles may also experience unintended and uncontrolled acceleration due to interference between the accelerator pedal and the driver's floor mat.this recall was designated 09v388.several months later, on january 27, 2010, toyota filed an amended, or supplemental, defect information report and expanded the population of vehicles to include additional my 2008-2010 toyota and lexus vehicles.since this expansiontook place in a different calendar year, this recall was designated 10v023.separately on january 21, 2010, toyota filed a defect information report and notified nhtsa that certain toyota vehicles and certain pontiac vibe vehicles contained a safety defect in the accelerator pedal assembly that may cause the accelerator pedal to become harder to depress, slower to return, or in the worse case, mechanically stuck in a partially depressed position.nhtsa designated this recall 10v017.in total, the four recalls cover over 7.6 million toyota and lexus vehicles as well as the pontiac vibe product made by new united motor manufacturing, inc., a venture of toyota and general motors corporation.nhtsa requires additional information from toyota to more fully understand and evaluate, among other things, whether the scope of the recalls identified above (makes, models and model years) is sufficiently broad.the agency is seeking to determine whether toyota viewed the underlying defects too narrowly as interference between the accelerator pedal and the driver | ||||||
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | ||||||
| RQ10003 | TOYOTA MOTOR CORPORATION | 02/16/2010 | UNINTENDED ACCELERATION | |||
| On september 26, 2007, toyota filed a defect information report and notified nhtsa that some of its model year (my) 2007 and 2008 lexus e350 and toyota camry vehicles could experience unintended and uncontrolled acceleration due to interference between the optional all weather floor mat offered on those vehicles and the vehicles' accelerator pedal.this decision was influenced by an office of defects investigation (odi) engineering analysis.this recall was designated 07e082.two years later, on october 5, 2009, toyota filed a defect information report and notified nhtsa that a number of its my 2004-2009 lexus and toyota vehicles may also experience unintended and uncontrolled acceleration due to interference between the accelerator pedal and the driver's floor mat.this recall was designated 09v388.several months later, on january 27, 2010, toyota filed an amended, or supplemental, defect information report and expanded the population of vehicles to include additional my 2008-2010 toyota and lexus vehicles.since this expansiontook place in a different calendar year, this recall was designated 10v023.separately on january 21, 2010, toyota filed a defect information report and notified nhtsa that certain toyota vehicles and certain pontiac vibe vehicles contained a safety defect in the accelerator pedal assembly that may cause the accelerator pedal to become harder to depress, slower to return, or in the worse case, mechanically stuck in a partially depressed position.nhtsa designated this recall 10v017.in total, the four recalls cover over 7.6 million toyota and lexus vehicles as well as the pontiac vibe product made by new united motor manufacturing, inc., a venture of toyota and general motors corporation.nhtsa requires additional information from toyota to more fully understand and evaluate, among other things, whether the scope of the recalls identified above (makes, models and model years) is sufficiently broad.the agency is seeking to determine whether toyota viewed the underlying defects too narrowly as interference between the accelerator pedal and the driver | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| VEHICLE SPEED CONTROL | |||
| 10/12/2009 | 9500 | ||
| Toyota tundra 2009: toyota requiring customer to pay for repair of defective floor mat that slides forward and jams accelerator pedal. accelerating to speed on on-ramp. removed foot from pedal after merging onto interestate, but vehicle continued to accelerate. had to pry back accelerator pedal with foot and then noticed that mat had jammed accelerator pedal. all-weather floor-mat purchased as part of vehicle. this could have caused serious injury. removed floor mat as indicated by initial recall. contacted toyota dealership as part of pedal/floor mat recall. told that i would have to purchase separate retainer to secure floor-mat. does not make sense to have a recall and then insist that customers pay for their failures and defects. the safety retainer should have came with the vehicle. it does in other vehicles. | |||
| 10/01/2009 | 0 | ||
| Tl*the contact owns 2009 toyota tundra. since the vehicle was purchased it began accelerating without warning whenever he made a left or right turn and while driving 60 mph. the contact had to shift into neutral gear and apply the brake pedal in order to stop the vehicle each time the failure occurred. the dealer made some repairs; however, the contact doesn't know what components were repaired or replaced. the failure has recurred since the vehicle was repaired and the transmission has recently began making a noise and the vehicle lunged forward. the dealer advised the contact that they were unable to trade the vehicle for a new one. the failure mileage was 0 and the current mileage 20,000. the manufacturer was notified; however, they did not file a report on the failure. | |||
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | |||
| 03/05/2010 | 17000 | ||
| Tl*the contact owns a 2009 toyota tundra. while traveling between 35-40 mph the accelerator suddenly became stuck in place causing the vehicle to continue moving through an intersection. the contact applied the brakes and shifted the vehicle into the neutral gear in order to bring the vehicle to a stop. the failure occurred after the vehicle was repaired in accordance with nhtsa recall campaign 09v388000, vehicle speed control, accelerator pedal. the vehicle was taken to the dealer who stated after two days that the failure could not be reproduced. the manufacturer was not contacted. the failure mileage was 17,000. | |||
| 02/01/2010 | 3 | 05/16/2009 | |
| Ltr fwd (tx) re 2009 toyota tundra, considers vehicle a lemon after experiencing several defects especially w/electrical & fuel system, filed complaints w/nhtsa odi system in 2009, reply to houston, tx ofc. *tgw the consumer stated the vehicle has acceleration, transmission and electrical problems. the odometer, drive shaft and muffler failed. the consumer stated the vehicle speed went from 65 mph to 105 mph. the odometer was not correct, there were vibration and ticking noises coming from the engine.*jb | |||