Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||||
| 010702 | 01/11/2007 | 10021315 | Dtc's p1297 (17705) or p1557 (17965) stored in dtc memory. this may be caused by intake hoses leaking (during boost conditions) due to incorrect torque on clamps or improper placement, worn or torn intake hoses. *kb | 04/03/2007 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| TB-01-12-04 | 02/10/2012 | 10043602 | Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance. *pe | 04/13/2012 | |
| SAC-28F3/P1-REV | 08/01/2010 | 10036496 | Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. models passat and wagon; golf; gti; jetta a | 03/23/2011 | |
| 0501 | 09/09/2005 | 10016900 | Mil is on and or catalytic converter is rattling. *sc | 10/14/2005 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| 2015831 | 08/28/2008 | 10026848 | Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe | 12/29/2008 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| SAC-28F3/P1-REV | 08/01/2010 | 10036496 | Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. models passat and wagon; golf; gti; jetta a | 03/23/2011 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 03/28/2003 | 34064 | 11 | 07/09/2001 |
| Since car was bought in 2001 mil light has been coming on in raining conditions. vw said it was the catalytic converter and replaced in at no charge in march of 2003. since replacement light still comes on, and is now permanently on. when car is wet you can see sparks coming from the ignition coil. there are noticeable cracks in the coil housing. *******epa reference information(ihttp://www.epa.gov/otaq/cert/recall/420b04018.pdf) *******epa states the following: cylinder ignition coil failure. causing the engine to misfire and illuminate the malfunction indicator lamp (mil). two separate failure modes may exist within the defective ignition coils tested, (1)coil housing damage caused during the assembly process at the applicable vw or audi factory, (2)coil design shortcomings by the supplier. *****************note: the 2002 golf gti vr6 (engine class 2vwxv02.8224) and the 2001 euro van vr6 (engine class 1vwxv02.8225)use the same ignition coils as my car, the 2001 golf gti vr6 (engine class 1vwxv02.8224). please help to include my call the 2001 golf gti (vr6). my car is now and has been going through all kinds of electrical issues, excess fuel consumption, emissions faults, loss of power engine power while driving, excess oil comsumption etc. *nm | |||
| 06/23/2005 | 0 | 05/29/2001 | |
| I have a 2001 vw golf gti. it is leaking oil from the engine's block head gasket. being that it is under a 100k miles warranty i took it in to the vw dealer to have it fixed. i was alarmed that the dealer told me that the leak was a small and normal leakage, just sipping. the person at the counter told me i had nothing to worry because i was under warranty and would get a new engine if anything happened to the one i have now. can you please have vw explained to me how is that an engine block that leaks oil is normal. in the end, i left b/c they would not service the car sinse it was sipping oil, thus acceptable according to the dealer. | |||
| 04/04/2003 | 39000 | 4 | 03/14/2001 |
| My blinkers stopped working in august 2002. dealer repaired under warranty. january 2003 check engine light came on. car off warranty; turbo cut off valve replaced and coolant temp sensor. check engine light came on a couple weeks later. took gti to dealer again. dealer replaced the fuel pump relay. now, 3 days later the check engine light came on again. *nlm | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 04/06/2008 | 82000 | 1 | |
| 2001 vw gti bought used. at 79,000 miles had 80k service done at dealership which included checking timing belt. at 82,000 timing belt broke causing extensive damage to engine. needed to replace engine cost me $5300 in which vw would not pay for as warranty only covers original owner. vw claims belt is supposed to last 105,000 miles. after researching on internet, numerous claims for all 1.8t engines regarding the timing belt going well before 105,000. *tr | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 12/04/2002 | 2 | 06/01/2001 | |
| The coil packs on the engine have failed on me twice. was going 65 down a major highway when my engine power was reduced to less then half and becoming real rough and real jerky. vw needs to realize that this is also a safety issue as well. imagine accidentally pulling out in front of oncoming traffic and having more than one coil pack fail and not being able to get out of the way. i would hate to see that happen to even one family. dt | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 11/02/2001 | 1 | 05/01/2001 | |
| My intake manifold change over valve are rattling. although i have a 10 yr drive train warranty vw told me that the manifold is covered in the warranty but the inside components are not. even worse the vw mechanic said that this is common with the vr6 engines. this should not be allowed to happen. *nm | |||