Volkswagen Jetta 1992
Model Jetta made in 1992 by Volkswagen got 33 consumer complains there are 3 recalls as well as 3 service bulletins. Consumer complaints with reference, among others things, to electrical system, engine and engine cooling and fuel system, gasoline. Technical service bulletines regarding engine and engine cooling, seats and structure. There were some recalls concerningexterior lighting, fuel system, gasoline and service brakes, hydraulic. The car has 3 modeles with engines 1.6l, 1.8l and 2.0l.
Model 1992
| Engine [L] | Cylinders | Transmission | Drive | Estimate MPG (city/highway/combined) | Unadjusted MPG (city/highway/combined) | Fuel | Fuel cost | Class | Release date |
|---|---|---|---|---|---|---|---|---|---|
| ( 1.6L) | 4 | Manual, 5 gears | FWD | 37/40/38 | 41/51/45 | D | $ 473 | 4 | 910821 |
| ( 1.8L) | 4 | Automatic, 3 gears | FWD | 23/28/25 | 26/36/30 | Regular | $ 720 | 4 | 910821 |
| ( 1.8L) | 4 | Manual, 5 gears | FWD | 25/32/28 | 27/41/32 | Regular | $ 643 | 4 | 910821 |
| ( 2.0L) | 4 | Manual, 5 gears | FWD | 21/28/24 | 23/36/28 | Regular | $ 751 | 4 | 910821 |
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EXTERIOR LIGHTING | ||||||||||||||||
| 09E012000 | SABERSPORT | E (Equipment) | 16270 | 05/11/2009 | OVSC | VOLKSWAGEN OF AMERICA, INC | 04/07/2009 | 04/07/2009 | 571 | 108 | ||||||
| Defect Summary | Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. these lamps do not contain the required amber side reflectors. | |||||||||||||||
| Consequence Summary | Decreased lighting visibility may result in a vehicle crash. | |||||||||||||||
| Corrective Summary | Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589. | |||||||||||||||
| Notes | This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
| 92V058000 | VOLKSWAGEN OF AMERICA,INC | from 07/01/1985 to 06/01/1992 | V (Vehicle) | 358000 | 05/22/1992 | MFR | VOLKSWAGEN OF AMERICA, INC | 04/14/1992 | 04/24/1992 | |||||||
| Defect Summary | The fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak. | |||||||||||||||
| Consequence Summary | Fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition. | |||||||||||||||
| Corrective Summary | Replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp. | |||||||||||||||
| Notes | System: fuel lines.vehicle description:passenger cars. | |||||||||||||||
| SERVICE BRAKES, HYDRAULIC | ||||||||||||||||
| 06E018000 | FOREIGN PARTS DISTRIBUTORS, INC. | E (Equipment) | 266 | 03/30/2006 | OVSC | VOLKSWAGEN OF AMERICA, INC | 03/01/2006 | 03/01/2006 | 571 | 106 | ||||||
| Defect Summary | Certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, brake hoses. | |||||||||||||||
| Consequence Summary | Brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash. | |||||||||||||||
| Corrective Summary | Foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11. | |||||||||||||||
| Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| 2015831 | 08/28/2008 | 10026848 | Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe | 12/29/2008 | |
| SEATS | |||||
| 0101 | 06/12/2001 | 621613 | Subject regarding latch system lower anchors and tethers for children, installing / retrofitting. *tt | 09/27/2001 | |
| STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||||
| 2015831 | 08/28/2008 | 10026848 | Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe | 12/29/2008 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM - IGNITION | |||
| 10/30/1992 | 5 | 10/01/1992 | |
| This vehicle from new ( within 5 days of deliverly) has stalled out while driving. the warranty provided for replacemant parts but no mechanic could ever find the root of the cause. while driving the tachometer will bounce back and forth with the engine surging and attepmting to die out. and it will die out . no certian speed or circumstance will contribute to this. vw just replaces parts without ever identifying what the actual cause is. the throttle position swith has been replaced 5 times at a cost of 300.00 each. this maskes the problem but due to its interminate nature no one can put it on a scope and say this it it. it becomes a safty problem while driving and the car suddenly jerks and quits while driving on the freeway or in stop and go traffic. all conectors are gold plated as the factory recall was issued, fuses have been replaced. we are looking for an answer as this has become dangerous to drive. someone should be able to provide an answer to this problem. please contact me with any information. . *ak | |||
| 12/29/1994 | 9 | ||
| Intermittent stalling. *skd | |||
| ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||
| 08/26/1994 | |||
| Ongoing/intermittent problem with starter overheating, and causing engine to shut off. consumer learned of a service bulletin conerning same problem. but dealer/manufacturer were not conerned. can nhtsa provide additional information or help in this matter. *ak | |||
| 08/11/1995 | 1 | ||
| Starter replaced three times due to intermittent stalling/ vehicle not starting. *skd | |||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
| 09/11/1998 | 08/13/1994 | ||
| Driver was on the highway when the vehicle suddenly lost power and smoke began coming from under the hood and through the fresh air system. the driver pulled off the road, lifted the hood, and found that the wiring harness (platic covering on wires) was melted and on fire. *ak | |||
| 08/03/1996 | 1 | 12/01/1991 | |
| While drivng down the highway vehicle caught on fire on the right underside of the hood, consumer pulled off highway, in less than (10) minutes vehicle was engulfed in flames. *ak *jb | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 06/02/2003 | 119646 | 1 | 08/26/1999 |
| The vehicle experienced a coolant leak from the heater core. *jb the consumer was driving when a boiling sound was heard coming from the air vent and viewed heavy steam coming from the dash board as well, and when the vents were opened, hot radiator coolant was splashed in the consumers face. *scc *jb | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 12/01/1993 | 4 | ||
| The defective timing belt breaks annually which causes engine problem and the engine to seize while driving, which can cause an accident. been to dlr 4 times. cause unknown. please provide further information. *ak | |||
| 06/28/1996 | 8 | ||
| Engine mounts broke twice. *sd | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 02/04/2001 | 8 | 03/01/1992 | |
| For over a year now, my car will just die while i am driving it. i have been in almost 2 accidents now because of it. it doesn't give any warning that it is going to die. i just notice it when the dumy lights come on or when i loose my steering. it can happen when the car is hot or cold, at any speed. it just doesn't matter. sometimes i can tell, because the rpm will drop to almost 0. but usually nothing happens. i have taken it to the dealer 7 or 8 times over the last year and they have never been able to figure out what the problem is. they have gone as far as saying they cannot duplicate the problem. however, i have several witness's that have been with me in my car that can dispute this. i have had my car die as much as 7x in one day. i have contacted the manufacturer and they basically did nothing about it. they just contacted the dealer and they said they were trying to figure it out and that was the end of it. i called the manufacturer again and asked if they could send an engineer out to look at the car as it didn't seem the technicians at the dealer were able to figure it out and they told me no it is at the sole discretion of the service manager to decide this. so, till now, they have not been able to fix this problem, or even detect where it is coming from and they have no intentions to keep looking. in the meantime, i am driving a death trap. the car is totally unsafe. 3 weeks after i bought this car i started having problems. it is a lemon and the dealer basicaly admitted it, but wants nothing to do with it. in the past 10 years that i have had the car. i have taken it in for service around 45 times. is there anything i can do about this?*ak | |||
| 7 | 04/25/1993 | ||
| Engine hesitated intermittently and finally stalled completely, with not warning. | |||
| 12/16/1994 | 3 | ||
| Intermittent stalling. *aw | |||
| FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
| Vehicle stalls frequently, and dealers have replaced numerous parts, possible faulty airflow sensor. dealers have been unable to correct problem. *ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
| 08/01/1997 | |||
| The defective heater core malfunctioned, causing heavy smoke coming out of the vents, blinding the occupant while driving which almost caused an accident. also there are problems with the fuel lines in relation to the recall. (92v-058.001). *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
| 05/01/1998 | 3 | ||
| Shifting cable continues to either break or come loose from transmission housing. | |||
| SEAT BELTS | |||
| 12/12/1996 | |||
| When vehicle was involved in a rear end crash, the seat belt on the driver's side did not restrain the driver, causing injuries to the driver's neck/shoulder and back. please provide any further information. *ak *yc | |||
| SEAT BELTS - FRONT - RETRACTOR | |||
| During rear impact 20-25mph, shoulder harness driver/pass. side failed to retract, allowing occupants to impact with interior. *ak | |||
| SERVICE BRAKES, AIR | |||
| 06/12/2004 | 4 | ||
| While applying the accelerator pedal it failed to accelerate. after applying the accelerator pedal numerous times vehicle suddenly accelerated uncontrollably. consumer applied the brake pedal, but it failed. this caused the vehicle to collide into a guard rail. vehicle was towed to a garage for inspection. driver sustained minor injuries. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 08/15/1995 | |||
| When applying the brakes, the brakes will make a loud noise. tt | |||
| SUSPENSION - REAR | |||
| 2 | |||
| Rear axle is misaligned, causing excessive tire wear. | |||
| 04/03/1993 | |||
| Rear end misaligned, causing excessive tire wear. | |||
| VEHICLE SPEED CONTROL | |||
| 01/10/1998 | 1 | 01/01/1992 | |
| Throttle cable wrapped around gas pedal causing gas pedal to stick. | |||
| 09/01/1993 | 1 | ||
| Cruise control stuck, causing surge in acceleration. *dh | |||
| 03/05/1996 | 5 | ||
| Cruise control actives when accelerator pedal is depressed. *sd | |||
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | |||
| 06/12/2004 | 4 | ||
| While applying the accelerator pedal it failed to accelerate. after applying the accelerator pedal numerous times vehicle suddenly accelerated uncontrollably. consumer applied the brake pedal, but it failed. this caused the vehicle to collide into a guard rail. vehicle was towed to a garage for inspection. driver sustained minor injuries. *ak | |||
| 07/02/2004 | 1 | 08/29/1999 | |
| 2025 hrs: traffic was gentle, with trailers on the right and smaller cars and trucks passing on the left that day. i was traveling to crown point from lafayette using highway 65 north (60-65 mph -with the flow of traffic), when 3/4 miles away from reneselaer the accelerator cable froze still halfway. it would not release to the full position, nor will it depress past halfway. at that moment, the engine revved and started speeding up. i watched with panic as my jetta's speedometer read 67, 70, 72 and 75 progressively. to slow the car down, i stepped on the breaks gradually; which helped a little, but not by much. i had just passed the 1/4 mile to reneselear exit number 215, which merges with highway 114. seeing the exit ahead (and still stepping on the brakes to slow me down), i turned into the exit and halfway through the exit, i turned the engine off and rolled to a stop at the stop sign on top of the hill exit. before i stopped completely, i began to smell my brake pads smelting. and when i did roll to stop, there was smoke rising from the front wells. i got out and popped the hood to inspect further and to check my tires. as i bent down to check the wheels, i noticed my rotors were both red hot. checking the left wheel, after inspecting the right, revealed a small lip of flame right next to the brake rotor. i then grabbed a full bottle of windshield wiper fluid and emptied it on both rotors. the thought of losing my beloved car to a fire and a hugh explosion -my gas tank was completely full at the moment- was morbidly petrifying. the fire was quickly extinguished after i poured it on the flames. to my west, about ~ 1000 meters, was a shell gas station with kelly's tires right before it, where i asked for help. a kind technician -from kelly's tires- informed me, after inspecting my car, that i would need a new accelerator cable before any work is done. i would need to special order the part and then bring it to them on or after tuesday (7-6-2004. *ak | |||
| 01/10/1998 | 1 | 01/01/1992 | |
| The trhottle cable tangled causing the accelerator pedal to stick to floor. | |||
| VEHICLE SPEED CONTROL - CRUISE CONTROL | |||
| 05/01/1996 | 1 | ||
| Idle speed surges/sticks. *dh | |||
| VEHICLE SPEED CONTROL - LINKAGES | |||
| 09/09/1999 | 0 | 11/19/1991 | |
| When started vehicle heard a noise, smelled smoke, and vehicle lurged forward. vehicle finally stopped when rear end collided with the front of a pickup truck parked in the lane. driver suffered injuries, and vehicle sustained damage. accident was caused by accelerator cable snapping in half. applied brakes, but failed to stop vehicle prior to collision. *ak | |||
| VISIBILITY - DEFROSTER/DEFOGGER SYSTEM - WINDSHIELD - HEATER CORE | |||
| 11/04/2000 | |||
| Heater coil bursted and cooliant came inside of vehicle through dashboard. dealership wasn't aware of problem, but said that she will call them today.*ak | |||
| 08/01/1997 | |||
| The defective heater core malfunctioned, causing heavy smoke coming out of the vents, blinding the occupant while driving which almost caused an accident. also there are problems with the fuel lines in relation to the recall. (92v-058.001). *ak | |||
| VISIBILITY - GLASS, SIDE/REAR | |||
| 01/10/1997 | |||
| Vehicle was in idle position left to warm up, water/ heater/ defroster, was turned on, after driving the vehicle 15 minutes, rear windows exploded. *ak | |||