Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - BATTERY | |||||
| TB-27-09-01 | 03/06/2009 | 10030116 | Volkswagen: the positive battery cable on passat vehicles with v6 engine may corrode and in individual cases break. as a result, the power supply may be disrupted and e.g. the vehicle cannot be started. *pe | 08/04/2009 | |
| ELECTRICAL SYSTEM - BATTERY - CABLES | |||||
| SA-97R7 | 04/01/2010 | 10034370 | Volkswagen: inspect, and if necessary, replace positive battery cable. vehicles affected by this action may have a positive battery cable that may corrode and, in rare cases, break. if this happens, the power supply may be disrupted and | 11/08/2010 | |
| SB-97P4-Y5 | 03/01/2009 | 10030449 | Volkswagen: this is to inform you of the release of a new required vehicle update. check and, if necessary, replace positive battery cable. models passat, passat wagon, passat cc. *pe | 10/06/2009 | |
| TB-27-09-01 | 03/06/2009 | 10030116 | Volkswagen: the positive battery cable on passat vehicles with v6 engine may corrode and in individual cases break. as a result, the power supply may be disrupted and e.g. the vehicle cannot be started. *pe | 08/04/2009 | |
| TB-27+09-01 | 03/06/2009 | 10029033 | Volkswagen: the positive battery cable on vehicles may corrode and in individual cases break. as a result, the power supply may be disrupted and e.g. the vehicle cannot be started. *pe | 06/12/2009 | |
| ELECTRICAL SYSTEM - IGNITION | |||||
| SAC-28F3/P1-REV | 08/01/2010 | 10036496 | Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. models passat and wagon; golf; gti; jetta a | 03/23/2011 | |
| TSB-28-10-02 | 05/10/2010 | 10034745 | Volkswagen: mil on or flashing, misfire dtcs p0300-0312 stored in ecm. the misfire condition may be caused by a malfunctioning ignition coil. vehicles are out of production. *pe | 01/10/2011 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| SA-97U3 | 01/01/2011 | 10038595 | Ready | 06/22/2011 | |
| SA-97U3 | 01/01/2011 | 10038595 | Volkswagen service campaign: see document search button for owner letter. resistance in the air bag system can cause the air bag light to turn on even though there is no problem. *rm | 06/22/2011 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| EA11002 | VOLKSWAGEN OF AMERICA, INC | 01/26/2011 | 02/17/2012 | Engine Compartment Fire | ||
| In july 2010, the agency opened pe10-027 to investigate allegations of coil on plug (cop) ignition coil fires in my2002-2003 vw passat vehicles.the investigation was upgraded in january 2011 to include all my2001-2007 4-cylinder vw passat, gasoline, turbo-charged vehicles.based on the analysis of vw's response, and including odi's consumer complaints, odi has since identified 135 unique engine fire reports attributable to the cop coils.after further review of the details as contained in each report, odi determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.these cop coil fires were characterized as initiated from within the cop coil circuit located at the top of the engine block and below the plastic engine cover.the fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in odi | ||||||
| EA11002 | VOLKSWAGEN OF AMERICA, INC | 01/26/2011 | Engine Compartment Fire | |||
| Odi has received 14 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 21 complaints of ignition coil failure that did not result in a fire.reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.the vehicles were repaired by replacing the faulty ignition coil(s). some of the complaints indicated that the ignition coils were replaced more than once.the scope of pe10-027 focused on model years (my) 2002-2003 passat vehicles and volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles.however, based on consumer complaints, odi also requested and received data from volkswagen regarding my2006-2007 passat vehicles.the failure report for this engineering analysis contains data for my 2002-2003 and my 2006-2007 vehicles.odi needs to further investigate this issue.to facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an engineering analysis.odi is expanding the scope to include my 2001-2007 passat vehicles. | ||||||