Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| TB-35-11-01 | 06/06/2011 | 10041250 | Ready | 09/21/2011 | |
| TB-35-11-01 | 06/06/2011 | 10041250 | Volkswagen: the gear box has a momentarily delay while accelerating. *rm | 09/21/2011 | |
| 2014708 | 05/03/2007 | 10021961 | Transmission, indicator illuminated in instrument cluster. *kb | 06/27/2007 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
| 0413 | 06/21/2004 | 10008078 | Update programming (flashing) transmission control module (tcm) for harsh shifting. *mj | 07/21/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
| VQ | 09/01/2004 | 10009746 | A rubber part can rub against the power steering and/or transmission fluid lines located behind the radiator grille. this rubbing can lead to corrosion of the lines and possibly even a fluid leak. *tt | 10/19/2004 | |
| POWER TRAIN - DRIVELINE | |||||
| TB-01-11-29 | 12/21/2011 | 10043280 | Volkswagen: certain model year vehicles experience tire rubbing or binding of drivetrain at low speed and the instrument cluster light would be on or flashing. *pe | 03/09/2012 | |
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||||
| 0501 | 04/27/2005 | 10015085 | Required rear final drive differential gear oil change. *tt | 05/19/2005 | |
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
| 0402 | 06/21/2004 | 10008088 | Transfer case, checking/replacement. *mj | 07/21/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 09/25/2009 | 80000 | 1 | |
| Rear center drive shaft from gearbox to differential, middle bearing fails. volkswagen only supplies new shafts for $1,400 no bearings or exchange. this happens to a lot of touaregs according the clubtouareg forum. this is a premature design failure of this car. *tr | |||
| 09/25/2009 | 80000 | ||
| Rear center drive shaft from gearbox to differential, middle bearing fails. volkswagen only supplies new shafts for $1,400 no bearings or exchange. this happens to a lot of touaregs according the clubtouareg forum. this is a premature design failure of this car. | |||
| 03/30/2012 | 90000 | 1 | |
| While accelerating onto the highway, a loud, repetitious bang/clunk from the middle underside of the vehicle started, sounding similar to a blown tire. no abnormal operations noted prior to this. limped the car back to the shop at 15 mph and found the center driveshaft carrier bearing failed. the service tech acted as if this was common and was not surprised. i have a 1981 mercury with over 305000 miles and never lost a bearing in my driveshaft. mechanical parts fail. the worst part of this event is voa's reaction that somehow they are not responsible for a poor/weak design. list of other major component failures with no recall that are common to all touaregs of this generation according to the company's own service tech's: center differential lock motor fail rear diff. lock motor fail cooling fans do not shut off, drain battery thermostat housing leak radio failure. *tr | |||
| 03/30/2012 | 90000 | ||
| While accelerating onto the highway, a loud, repetitious bang/clunk from the middle underside of the vehicle started, sounding similar to a blown tire. no abnormal operations noted prior to this. limped the car back to the shop at 15 mph and found the center driveshaft carrier bearing failed. the service tech acted as if this was common and was not surprised. i have a 1981 mercury with over 305000 miles and never lost a bearing in my driveshaft. mechanical parts fail. the worst part of this event is voa's reaction that somehow they are not responsible for a poor/weak design. list of other major component failures with no recall that are common to all touaregs of this generation according to the company's own service techs: center differential lock motor fail rear diff. lock motor fail cooling fans do not shut off, drain battery thermostat housing leak radio failure | |||
| 04/01/2010 | 92000 | ||
| At 94,000 miles transmission problems, told transmission non-servicable vw does not recommend any transmission fluid replacement. could be gear box cost $2400 or entire transmission cost $7,000. vwa will pay $1,000 to our choice of gear box or transmission replacement but if we choose wrong repair will not pay for anything further! vwa obviously is aware of problem and designed the transmission in such a way that it can't be serviced. we have had prior engine coil recall replaced, updated computer software and replaced drive-train at cost of $1900 at 74,000 miles. | |||
| 12/02/2009 | 80000 | 1 | |
| In december 2009 my 2004 vw touareg was in park with the engine idling while my son, who was driving the car, got out of the car to speak to a parking lot attendant. his wife was in the passenger seat and their two children were in car seats in the rear seat. about 2 minutes later, while my son was still out of the car, the car began to roll backwards into a busy street in nyc. he ran after the car while his wife frantically tried to get out of her seat belt to move into the driver's seat. he caught up with the car and jumped in and hit the brake to stop the car. he looked over at the gear shift thinking that it had been moved inadvertently but the car was still in park. he then turned off the ignition. the car was idling in park on a relatively flat surface - there are no real hills in nyc. he took his life in his hands to avoid a disaster whereby the car would have certainly been hit broadside in the busy adjoining street with his family in the vehicle. we took the car into a vw dealer repair shop near my home in maryland the next week and they checked the car out thoroughly, but could not find anything wrong, nor could they duplicate the experience. this was a frightening and dangerous experience and i am afraid that it could happen again. *tr | |||
| 09/16/2009 | 104000 | 1 | |
| I have a 2004 vw touareg v8, i have a airbag light that come on (airbag fault), now the tran light is coming on when i start the suv. *tr | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 04/01/2010 | 92000 | ||
| At 94,000 miles transmission problems, told transmission non-servicable vw does not recommend any transmission fluid replacement. could be gear box cost $2400 or entire transmission cost $7,000. vwa will pay $1,000 to our choice of gear box or transmission replacement but if we choose wrong repair will not pay for anything further! vwa obviously is aware of problem and designed the transmission in such a way that it can't be serviced. we have had prior engine coil recall replaced, updated computer software and replaced drive-train at cost of $1900 at 74,000 miles. | |||
| 05/08/2010 | 95000 | ||
| 2004 vw touareg v-8 many problems but 3 worth reporting: for no apparent reason passenger door could not be opened or unlatched by using any known means including the inside door handle or outside door handle, electric lock actuator clicks as if the door is unlocked but the door can not be opened or unlatched. vehicle had to be brought to vw dealership and worked on by destroying the door handle to open the door and perhaps cutting a whole in the body pannel at the cost of 2 hours of diagnostics, 8 hours of labor to open door and probably 2 or 3 additional hours of replacing door handle if body of door is not bent, plus parts vehicle has many electrical glitches including but not limited to intermittent malfunction of air bag igniters....once again having the potential to cause serious harm occupants given the right circumstances this is a potential dangerous situation and has made me lose all faih in this manufacturer. vehicle lunges forward when stopped at trafic lights and beginning to procceed on a green | |||
| 05/28/2010 | 45000 | ||
| I have a 2004 touareg and have been having tranmission issues hard shifts, bucking and hard downshifts. i have taken this to the vw dealer and they say there is nothing wrong with the transmission. it is very very dangerious when access the highway and in several cases it shifts so hard that it knocks it's self out and you have to pull off the highway until resets to 4th gear from 6th. i now have to shift manually. i have this issue daily and i know this is a wide spread issue. | |||
| 04/15/2010 | 38800 | ||
| Car: 2004 volkswagen touareg v6 suv 38,900miles problem: car frequently jerks while slowing down (at speeds between 20-40mph). was told drive shaft was damaged and needed to be replaced at a cost of $1,150 parts plus labor of approx. $1,000 which included computer diagnostic. upon pick up from mechanic problem still persisted so i took the car back to mechanic. i was told that damaged drive shaft damaged 2 valves in the transmission which now also need replacing at a cost of $1600. i was also told by the mechanic that they had received a 'bulletin on the car regarding similar complaints about this problem from several owners. this car only has 39.000 miles and is driven with care. it seems extremely premature to have anything of this nature happen especially at a cost of almost $4000 out of pocket to me and other owners. i ask that you please look into volkswagen's responsibility in correction/reimbursement (possible recall) of this situation. | |||
| 03/10/2007 | 87850 | ||
| Tl*the contact owns a 2004 volkswagen toureg suv. the contact stated that immediately after the vehicle was started, it would either shudder or stall. also, when traveling at speeds of 1 mph and higher, the vehicle would shake in between shifting gears. the dealer performed a diagnostic test on the vehicle but could not duplicate the failure. the failure continued to occur. to date, no repairs were made to correct the failure nor were there any recalls pertaining to the failure. the failure mileage was 40,000 and the current mileage was 87,850. | |||
| 02/11/2010 | 72000 | 1 | |
| 2004 vw touareg miles 72,000 brought into dealership, because of transmission was acting up. told i need new transmission, not under warranty how can the car need new transmission at 72,000 miles other people have had troubles with this suv vw should replace this, tons of stuff has gone wrong with suv. *tr | |||
| 10/15/2009 | 81000 | 1 | |
| I was parking the vehicle in a tight parking lot and maneuvering around a tree in order to pull further up into the space. as i gently pushed down on the accelerator to inch into the spot, the car lurched forward at a very high rate of speed crashing into a wooden garbage box. i jammed on the brakes before going through the fence. i was incredibly lucky that i was no longer aiming at the tree. it was as though the car suddenly wanted to peal out in a manner that was totally out of sync with the amount of pressure on the gas pedal. it just started speeding toward the fence/box. looking back on it, i believe that this happened a couple of days before as i started to accelerate after stopping at a stop sign. though the reaction of the car was similar, it was not nearly so pronounced. it felt as though the car was tripping over itself. i had the insurance tow the car to the mechanic but so far he has not been able to replicate the problem. i spoke with both the local vw serviceman and vw north america but they denied ever hearing about such a problem. i have had this car for over 6 years and have never had this happen before the other day. *tr | |||
| 05/01/2008 | 40000 | 2 | |
| Tl*the contact owns a 2004 volkswagen touareg. when the contact accelerated more than 45 mph, the vehicle began vibrating, shaking and was stuck in neutral. eventually, the vehicle began accelerating at the desired speed. occasionally, when the failure occurred the contact had to shut the engine off; however, it would operate normally after a few minutes. the dealer was unable to diagnose the failure; however, the failure recurred 4 months later and the dealer stated that the transmission needed to be replaced. the contact is aware of the safety risk involved. the dealer and the manufacturer stated that they would not be responsible for the repair cost. the failure mileage was 40,000 and the current mileage was 69,000. updated 10/06/09. *lj the consumer was informed the transmission fluid was burnt. updated 10/06/09 | |||
| 07/28/2008 | 44000 | 1 | |
| Multiple engine light failures for over 4 years. engine light came on and engine shut down immediately while wife was on the freeway. very dangerous...essentially no warning. have replaced wiring harness in the vehicle and have had it in the shop for electrical issues many times. unsafe handling and acceleration...car jumps forward at stops while it is downshifting. think the transmission, tires and brakes should be tested. think you will find they are defective. engine blew up at 44,000 miles. very dangerous car..and you will find other touaregs with similar issues. should be recalled. *tr | |||
| 11/01/2006 | 15000 | 4 | 01/03/2005 |
| Tl*- the contact stated that since she purchased the vehicle acceleration has been sluggish. the dealer stated that it was the nature of the beast, and there was nothing that they could do about it. the engine was not powerful enough to sustain the weight of the vehicle. the contact often took the vehicle for repairs. neither road nor weather conditions have been factors in the failure.*ak when accelerating from a dead stop, acceleration is slow but steady, when accelerating while moving between 40 mph acceleration is non-existent for approximately 3 seconds and then takes off fast. updated 03/30/07. *jb | |||
| 08/09/2006 | 34000 | 7 | 05/24/2004 |
| Dt*: the contact stated a week after having the transmission replaced by the service dealer, the vehicle was driven 60 mph on the highway, and the engine warning message read turn the motor off immediately, as the electrical system failed and stalled the engine. the contact was able to steer and coast to a stop on the break down lane. the vehicle restarted and stalled 7 times before making one mile to the contact's driveway. the service dealer provided a number to a towing service. the service dealer diagnosed the problem as an alternator and electrical failure, due to leakage from the engine when the engine was removed to replace the transmission. no evidence was found in the garage or driveway, before or after the problem or while parked in the driveway while waiting for the tow to the service dealer. the manufacturer was notified. updated 10/25/2006 - *nm | |||
| 07/01/2005 | 15000 | 365 | 05/01/2005 |
| Dt*: the contact stated that there automatic transmission was not operating properly. while traveling at highway speeds, the vehicle would not downshift smoothly. as an alternative pressure was applied to the brakes which in the event of an emergency braking situation the vehicle felt as if it would not stop in time this was caused by the pressure to the transmission. this problem occurs on a daily basis. the vehicle was at a dealership for 3 and a half weeks and the dealer determined the vehicle was operating under normal operating standards. the contact expressed that this is a serious safety concern.*ak | |||
| 04/20/2006 | 29500 | 1 | 03/01/2004 |
| Dt*: the contact stated the transmission disengaged while driving 65 mph. the vehicle acted as if it was in neutral, regardless of the position of the shifter. the transmission would not engage in any position including park. the engine continued to run, but there was no power to the wheels. after several attempts to restart, the transmission re-engaged. the vehicle has been to the dealership five times for inspection and repairs. they have replaced the battery, alternator, flashed the transmission control module, engine control module, and differential control module however the problem still exists. the vehicle is currently at the dealership awaiting further inspection. the manufacturer was alerted. updated 07/25/06. *jb | |||
| 01/28/2006 | 1 | ||
| Alignment: since its purchase the car was not properly aligned. i took it to the dealer several times, at the 5,000 miles, 10,000 miles, and 20,000 miles services. it was not fixed at all. the repair sheet stated that car was fixed to the manufacturer's standards. at the 20,000 miles service i requested the car to repaired before i take it back. the dealer told me that due to the uneven tires there was no way for them to repair the alignment, and that the only way to fix it properly was to replace the tires first. i replaced the tires and brought the car back. the dealer had the car in the shop for three days the first time. when i tested the car after the first time it was not fixed. i took it back and had a dispute with the technician. when other technicians tested the car the dealer decided to keep for repair. the car was at the shop for two days. when it was finally done, the car had the same problem. computer system: lights and signals periodically stop working. gas sensor periodically stops working for days. cd player. periodically skips and does not work. transmission: periodic jerking when shifting to lower speeds. screeching sound comes from the front right side after 20 -30 minutes of driving. tires were worn out after 10,000 miles.*ak | |||
| 12/01/2005 | 4000 | 2 | 10/20/2003 |
| Several transmission failures where the engine would lose power and wouldn't shift. *jb | |||
| 10/22/2005 | 100 | 09/30/2004 | |
| Our 2004 vw touareg v-8 has the following problems despite five trips to the dealer: i) hesitation during acceleration; ii) pulls hard to the right; and iii) shifts roughly at low speeds. past problems include: iv) the latch on the rear door broke, such that it came crashing down on my wife's head; v) the rear seat belt latch wouldn't work; vi) the car shuddered badly when you tried to make a turn at low speeds (e.g., while parking) and vii) the flat tire indicator went on even though the tire was neither flat nor low. we have an arbitration scheduled for 11/9/05 under california's lemon law. *nm | |||
| 09/18/2005 | 1900 | 1 | 07/15/2005 |
| My 2004 vw touareg has had an ongoing safety issue since purchase in july of 2004 with regards to the transmission. when accelerating from a stop or low speed the vehicle will often hesitate while running the engine rpms up to 3000-4000 then drop into gear and lurch forward. the transmission also erratically shifts from first to second gear and often hesitates for more than a few seconds before engaging this causes a danger when merging with traffic or crossing intersections. i have contacted the dealer and volkswagen of north america with no resolution. *nm | |||
| 01/01/1901 | 16000 | 3 | |
| Consumers vehicle is experiencing erratic shifting. when accelerating from a stop car will hesitate and jerk. *ts this problem seems to only occure whil the transmission is in lower gears. the vehicle has been taken to the deler at least three times but they have not been able to locate or fix the problem. the consuemr has also contacted tehe manufcature but they provided no assistance. the tire have excessive wear at only 16000 miles. *nm | |||
| 10/05/2005 | 5000 | 1 | |
| My 2004 v6 volkswagen touareg frequently stalls after the engine is cranked. this has been a problem since we purchased the vehicle in oct 2004. after cranking you can press all the way down on the gas pedal but the car will not move at all. after a few seconds, it will sputter a little then move then sputter again then it will drive normally. there is no way to tell when this will happen and i am concerned that it will cause an accident if i start the vehicle then pull out into oncoming traffic. *jb | |||
| 08/01/2004 | 200 | 6 | 07/15/2004 |
| Dt: the consumer states his 2004 volkswagen touareg was having a throttle delay problem. this is especially bad when pulling out from an intersection. this lasted for about 2-4 seconds and it is intermittent. after the vehicle has a delay the rpms go up t 3,000 to 4,000. this has been happening for about a year. the vehicle has been at the dealership for this problem 4 times. a regional technical representative came and examined the vehicle. he tried to flash the vehicle and upgraded the computer system. this still has not worked. the vehicle has consistently became worse. the owner has an appointment with volkswagen next week to assess the problem again. also, the dealer has been contacted by the manufacturer, who wanted more diagnostic work done. speed was not a factor. it is coming from a stop to pulling out that the throttle is having the delay. the consumer is providing all the information that he has available at this time. *ak the driver window was inoperative and the heater blower fan was noisy. *sc *jb | |||
| 10/07/2004 | 3 | ||
| While driving vehicle hesitated. consumer pressed down on the accelerator pedal and vehicle moved intermittently on its own. srs light appeared on the dashboard and remained on. consumer drove vehicle to the dealer for inspection, and mechanic placed the vehicle on a diagnostic machine. the mechanic determined that the sensor shaft for transmission and engine needed to be replaced. this problem was a design flaw defect. consumer informed the mechanic this problem was not acceptable and had not been resolved. *ak | |||
| 01/06/2004 | 2500 | 6 | 12/12/2003 |
| I have experienced the following issue approximately 5 or 6 times, in a 4 to 5 month period. i have contacted my local vw dealership & their national headquarters. i have not had any resolution or any status updates. what is the problem with the vehicle? will the problem be corrected soon? do i need to get trade or sell my vehicle? (1) usually when slowing down, in the 40-50 mph range, while turning in a curve (2) my 04 touareg feels (shudders) as if it has slipped a gear. there is no indication or warning when it will occur. the first 2 times it happened, i almost lost control of the vehicle (3) i have contacted my local vw dealership, service manager, and the vw us headquarters. they tell me that i am not the only one experiencing these problems, that they are trying to determine the cause and solution. thank you, *ak | |||
| 08/10/2003 | 1 | 07/26/2003 | |
| When accelerating from a very slow speed or a rolling stop, the car hesitates or stalls before accelerating, then lurches forward. this problem occurs randomly, but consistently. when driving up a hill to a stop, the vehicle regularly jumps forward at the last downshift in the stopping process. this is dangerous and threatens my safety, those around me in traffic, my passengers, and other potential drivers of my vehicle. i've been told by volkswagen of america & my dealer that this is the way this suv is designed to perform. the fact that the hesitations/stalls occur at random only furthers my point that this is clearly a defect and not just the way this model drives and you just have to get used to it as i was told by the service manager at martens vw.*ak | |||
| 03/01/2004 | 75 | 1 | 02/29/2004 |
| Same as others on site have noted: the 2003 touareg v8 hesitates upon acceleration, resulting in a surge forward when the engine finally catches. i find this very dangerous. we took it to the dealership; they couldn't replicate the action (unfortunately didn't have time to drive with them to demonstrate -- but will this week). i would also like to ask the nhtsa to help touareg owners by forcing vw to acknowledge this issue and find a resolution before an injury occurs. *jb | |||
| 08/01/2003 | 1 | 07/09/2003 | |
| Automatic transmission shifts erratically from first to second gear. car often hesitates when accelerating from a near stop. causes a danger when merging or crossing intersections.*ak | |||
| 09/18/2003 | 1 | 08/18/2003 | |
| My 2004 vw touareg has a serious safety issue with its transmission. when accelerating from a stop or low speed the truck hesitates and then lurches forward. i have contacted vw and the dealership with no resolution. i have talked with other touareg owners and they have the same complaint, so it appears to be affecting more than a single vehicle. i would ask the nhtsa to help touareg owners by forcing vw to acknowledge this issue and find a resolution before there is a fatality due to this safety issue.*ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||
| 03/23/2006 | 300 | 5 | 02/12/2004 |
| I brought a volkswagen touareg. this vehicle has a lot problems with the brake and engine. so i filed a lemon request. last month, vw asked me to drop this vehicle to vw dealer to investigate the brake problem. on march 23, the vw expert test drove my touareg and had an accident because the brakes failed. there is a police report. *nm the rear wiper made a clicking noise. updated 05/04/06. *jb the check engine light illuminated. the dealer replaced the engine control module. the transmission control module was updated. updated 06/01/06. *jb | |||
| 11/16/2004 | 1000 | 2 | 09/25/2004 |
| We have a volkswagon toureg v6 automatic and standard transmission. we brought the car in for ovelrall service and to inspect transmission for possible faulty gear box. dealership replaced transfer case as well as inspected case steeper motor. car was kept for three days for repairs and then anotger three days to get the part and replace. perfomance of the cars automtic shifting capabilites has been poor. notice that car has problems shift from 1st , 2nd to 3rd. high revs the engine. also notice at higher speeds the car sometime cause the car to lurch into lower gear we have also experienced car stalling on steep hills when in gear . *ak | |||
| 11/08/2004 | 2 | ||
| While driving transmission shifted from fifth gear to first gear. consumer pulled over, and turned the vehicle off. then, vehicle was reprogrammed, and consumer was able to drive it to the dealer for inspection. at first the mechanic could not duplicate the problem. but the mechanic informed the driver that the control module needed to be replaced. *ak | |||
| 10/06/2004 | 13 | 100 | 03/10/2004 |
| Transmission has terrible shift characteristics. unless the vehicle is completely stopped, the transmission won't downshift to 1st or when it does it launches you into the car in front. the vehicle seems to stumble bad from a stop if it hasn't downshifted into low gear. i think the computer needs to be reprogrammed for a smoother start!*ak | |||
| POWER TRAIN - DRIVELINE | |||
| 05/28/2010 | 76950 | ||
| Heard a knocking sound from below on my 2004 volkswagen touareg. looked under my car, the middle under carriage was gone. there was a knocking and thumping noise in the vehicle. thought it was just the undercarriage, but when the part came in and installed it, the knocking was still there. drove it last night because i need my car; i heard my car have rattling noises underneath. sounds like there's loss parts under the car. i never took my car off road, the roads on oahu are terrible, but never had this ever done on my older cars. i was researching online and saw that a lot of other touareg owners have/had the same problem. i'm not going to pay for a default part, especially when the drive shaft and its bearings are the main parts of the car powertrain. i haven't done anything wrong with this vehicle and feel that volkswagen will need to pay for this fix. | |||
| 07/15/2006 | 1 | ||
| I have had my 2004 vw touareg since june 2006 and have had problem after problem with the vehicle. the catalytic converter went out within 6 weeks of buying the car, the drive shaft had to be replaced, the air conditioning compressor had to be replaced, the brakes have had to be replaced and i am getting another check brake pads error again, the tire monitoring system continually tells me i have a flat, the radio amplifier was making a loud cracking so the dealership replaced a fuse and blew the 2 back speakers (which they would not fix, hewlett vw in georgetown, texas), the auto differential is going out. there seems to be no end in sight for repairs. *tr | |||
| 10/14/2008 | 62000 | 1 | |
| Drive shaft support bearing failure @ 62,000 miles. manufacturer vw does not sell individual broke part but sells assembly which cost $1,100 plus tax. this is common and should be a factory recall. *tr | |||
| 12/15/2007 | 66000 | 2 | 09/17/2006 |
| Drive train failed within warranty period. also, the module failed within six months of the drive train being replaced. the abs module however; failed 3 months after warranty expired. as a result i skidded unpredictably on ice and came within inches of causing a serious accident. $1500 was quoted to me to replace the module. *tr | |||
| POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
| 01/28/2005 | 1 | 09/07/2004 | |
| 2004 vw touareg with tire failure and key programming. consumer states he had to replace the tires due to a puncture in one of the sidewall tires. the second key received needed to be programmed and dealer charged him for programming. *kb the consumer stated he gets low gas mileage. when the vehicle was returned to the consumer, the tire monitoring system would come on and go off repeatedly. the drive shaft was replaced due to a vibration when making turns. the front brakes needed to be replaced.*jb | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 05/27/2004 | 1000 | 50 | 05/25/2004 |
| Transmisson fails to engage when starting from a slow roll or stop. dealer has been unable to reproduce intermittent problem. after many trips to dealer nothing has been done or been replaced.i was told that the car was operating to manufactures specs and there was nothing wrong with the car. | |||
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
| 10/14/2007 | 34000 | 2 | 10/05/2004 |
| The esp light came on steady and the lights around the differential switch came on flashing. then the vehicle lost electrical power and would not start. i had it towed into the dealer and the service people indicated there were numerous recalls on this vehicle that caused this problem. i was never notified of these recalls. *tr | |||
| 06/01/2004 | 48041 | 3 | |
| Vehicle would jump forward when making turns, making it difficult to control vehicle. owner took vehicle to dealer for repair of the transfer case 3 times. the accelerator pedal would get stuck, which was not enabling the vehicle to accelerate and to change gears. also, windshield wipers would work intermittently, causing visibility problems on the road during inclement weather. in addition, the battery would drain and cause the vehicle not to turn on. manufacturer was contacted by owner numerous times.*ak | |||
| 12/28/2004 | 2 | 10/31/2004 | |
| On two occasions my 2004 volkswagen touareg v-8 experienced complete electrical system failures. the vehicle would not start on these two occasions. there was no electrical power as if the battery were completely depleted. i did not cause any electrical/battery drain, i.e. leaving on lights or leaving any electrical equipment on. local vw dealership service conducted an analysis and found several faults stored. but the service adviser said none of the stored faults indicated what caused the complete electrical failure. first incident was april, 2004 and most recent dec. 28, 2004. i also experienced numerous other electrical and/or computer malfunctions. these malfunctions were related to: all-wheel drive system, drive line system, stability control system, anti-lock brakes, steering input, door locks, interior lighting features, tire pressure monitoring, and keyless remote. all-wheel drive system, drive line system, anti-lock brakes, and steering input malfunctions occurred four total times. dealer/service could not duplicate the problem and no repairs were made. the door locks and interior lighting problems were constant but dealer/service could not the problem. the tire pressure monitoring was repaired and has been problem free since march 2004. the keyless remote door lock/unlock was repaired and works better but has not been problem free. *nm | |||