Volvo 854 1997
Model 854 made in 1997 by Volvo got 10 consumer complains there are 2 investigations as well as 2 recalls. Consumer complaints with reference, among others things, to electrical system, service brakes, hydraulic and steering. The car had some investigations: electrical system, seats. There were some recalls concerningseats, vehicle speed control.
Model 1997
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| SEATS - FRONT ASSEMBLY - SEAT HEATER/COOLER | ||||||||||||||||
| 02V314000 | VOLVO CARS OF NA, INC. | from 05/01/1996 to 12/31/1996 | V (Vehicle) | 65000 | 02/19/2003 | ODI | VOLVO CARS OF N.A. LLC. | 11/19/2002 | 11/26/2002 | |||||||
| Defect Summary | On some sedans and station wagons equipped with seat heaters, it is possible that excessive compression of the seat cushion could cause damage to the electrical wiring of the seat heater. | |||||||||||||||
| Consequence Summary | If this occurs, the damage could result in a short circuit that could cause a fire. | |||||||||||||||
| Corrective Summary | Dealers will disconnect the existing wires and install a new electronic thermostat and cable harness. owner notification began on february 19, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-458-1552. | |||||||||||||||
| Notes | Volvo cars recall no. 112. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
| VEHICLE SPEED CONTROL | ||||||||||||||||
| 96V199000 | VOLVO CARS OF NA, INC. | from 04/01/1996 to 07/31/1996 | V (Vehicle) | 12530 | 11/08/1996 | MFR | VOLVO CARS OF N.A. LLC. | 10/11/1996 | 10/21/1996 | |||||||
| Defect Summary | The screws which attach the throttle plate to its axle (shaft) can loosen allowing the throttle plate to come in contact with the throttle housing. | |||||||||||||||
| Consequence Summary | This condition could prevent the throttle from returning to idle position increasing the potential for a vehicle accident. | |||||||||||||||
| Corrective Summary | Dealers will replace the throttle housing. | |||||||||||||||
| Notes | Owner notification:owner notification is expected to begin november 8, 1996. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-458-1552.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| EA02019 | VOLVO CARS OF N.A. LLC. | 08/22/2002 | 12/18/2002 | SEAT FIRES | 02V314000 | |
| Volvo is conducting a safety recall based on its analysis of complaints and technical information developed during its investigation.volvo'ssurvey of vehicles routinely brought in for maintenance at east-coast dealerships produced evidence that bare metal wires (that provide support for the seat bottom) can contact the thermostat and electrical wiresin or beneath the seat cushion.this can result in an electrical short.volvo confirmed in testing that if such a condition is present, the short to the wire seat support could cause burning of the seat cushion without activating (opening) the seat heater fuse.volvo will replace the entire thermostat assembly with an electronic timer delay unit. | ||||||
| SEATS - FRONT ASSEMBLY - SEAT HEATER/COOLER | ||||||
| EA02019 | VOLVO CARS OF N.A. LLC. | 08/22/2002 | 12/18/2002 | SEAT FIRES | 02V314000 | |
| Volvo is conducting a safety recall based on its analysis of complaints and technical information developed during its investigation.volvo'ssurvey of vehicles routinely brought in for maintenance at east-coast dealerships produced evidence that bare metal wires (that provide support for the seat bottom) can contact the thermostat and electrical wiresin or beneath the seat cushion.this can result in an electrical short.volvo confirmed in testing that if such a condition is present, the short to the wire seat support could cause burning of the seat cushion without activating (opening) the seat heater fuse.volvo will replace the entire thermostat assembly with an electronic timer delay unit. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 04/01/2003 | 95000 | 12/11/1997 | |
| Tracs and abs warning lights. *nlm | |||
| 10/01/1997 | 8 | 01/07/1997 | |
| The vehicle would not start at 3000 miles after purchase because the battery was dead. the problem continued every 5000 miles until the dealer discovered that the cause was electrical problem. *yh | |||
| ELECTRICAL SYSTEM - BATTERY | |||
| 09/17/1998 | 8 | 01/01/1997 | |
| The battery has recharged/replaced multiple times, due to the the electrical system malfunctioning.*yh | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 04/01/2003 | 95000 | 12/11/1997 | |
| Tracs and abs warning lights. *nlm | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE | |||
| 06/13/2003 | 0 | ||
| Failure of the anti-lock brake system computer. this seems to be a regular occurrence on the volvo 850. i feel this is a major safety related issue, and a recall investigation should be looked into. *nlm | |||
| 02/24/2001 | 33210 | 02/23/2001 | |
| My vehicle is a 1997 volvo 850r, i'm the second owner of the vehicle. the volvo is a soild car but the 850 series have a defect with the abs/tracs module, this sets a code on your obdii and it clears when you restart the car. the issue at hand is that it's a safety issue because the control module sees a fault and deactivates the abs/tracs control module and you no longer have an abs on the vehicle and it's very dangerous if it's raining, snowing or a sudden stop on the freeway. the wheels will lock giving you a greater chance to cause an accident. so far i've been lucky, i spoke to the volvo dealer directly to see if they can change this unit under the volvo vip warranty and i was told that it was not covered and the new unit cost around $600.00 without labor. i feel that volvo should be held responsible in changing this abs/tracs control module, lot's of volvo 850's and s70 owners have changed this part with vehicles in the 40,000 to 60,000 mile range. the cause it's a hair line fracture on the circuit board that sets the fault, too me that sounds like a manufacturers defect and bad qa control. i hope that this complanit will not just get pushed aside and hold volvo liable for this since it's a safety issue. the reason why i bought a volvo is beacuse safety is their #1 product. | |||
| STEERING | |||
| 02/01/1997 | |||
| The belt that drives the power steering and alternator periodically slips when wet. this occurs repeatedly at low speeds when going through even small puddles. a kit was added to repair the problem at about 10k miles. the dealer claims the persistent loss of power with the kit is normal. when this occurs it becomes very difficult to steer the car for a few seconds until the belt stops slipping. it also is unexpected to find the car difficult to steer in the middle of a turn and could cause loss of control. | |||
| UNKNOWN OR OTHER | |||
| 11/03/2010 | 88000 | ||
| Odometer failure at under 90,000 miles. original equipment; not tampered with; vehicle never in an accident. | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| CA | CARLSBAD | CARLSBAD VOLVO |