Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| AIR BAGS | |||||
| RTJ-19139 | 10/17/2008 | 10027424 | Volvo vehicles: pad lamp, logic changed with srs sw upgrade. the pad (passenger airbag disabled) lamp illuminates when the front passenger seat is unoccupied. earlier vehicles within same range, receive a total can or srs reload or upgr | 01/14/2009 | |
| 88-48 | 05/21/2008 | 10025021 | Pad passenger airbag disabled light logic changed with srs sofware upgrade. *pe | 07/01/2008 | |
| AIR BAGS - FRONTAL | |||||
| RTJ-19139 | 10/17/2008 | 10027424 | Volvo vehicles: pad lamp, logic changed with srs sw upgrade. the pad (passenger airbag disabled) lamp illuminates when the front passenger seat is unoccupied. earlier vehicles within same range, receive a total can or srs reload or upgr | 01/14/2009 | |
| AIR BAGS - FRONTAL - SENSOR/CONTROL MODULE | |||||
| RTJ-19139 | 10/17/2008 | 10027424 | Volvo vehicles: pad lamp, logic changed with srs sw upgrade. the pad (passenger airbag disabled) lamp illuminates when the front passenger seat is unoccupied. earlier vehicles within same range, receive a total can or srs reload or upgr | 01/14/2009 | |
| 8842 | 04/03/2007 | 10022376 | Occupant weight sensor (ows) spare part for dtc srs-0015. *kb | 08/09/2007 | |
| 8845 | 02/08/2007 | 10021204 | Passenger airbag off indication with belted adult passenger. *kb | 03/22/2007 | |
| AIR BAGS - SIDE/WINDOW | |||||
| 8833 | 07/29/2003 | 10003400 | Moisture in b-pillar side impact sensor. *tt | 10/17/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| AIR BAGS | |||
| 10/19/2012 | 95000 | ||
| Tl-the contact owns a 2004 volvo s40. the contact stated that the air bag warning light illuminated without warning. the dealer was contacted and advised him that the occupant weight sensor may have failed and needed to be replaced. the vehicle was not repaired. the manufacturer was contacted and they offered him a 10 percent coupon. the failure mileage was approximately 95,000. the current mileage was approximately 110,000. kmj | |||
| 10/19/2012 | 95000 | ||
| Tl-the contact owns a 2004 volvo s40. the contact stated that the air bag warning light illuminated without any warning. the dealer was contacted and they advised him that the occupant weight sensor may have failed and needed to be replaced. the vehicle was not repaired. the manufacturer was contacted and they offered him a 10% off coupon. the failure mileage was approximately 95,000. the current mileage was approximately 110,000. tb | |||
| 01/14/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. the contact stated that the driver side air bags were previously replaced under warranty due to the warning light illuminating continuously. the vehicle was taken to the dealer for routine maintenance but the dealer informed him that the air bags needed to be replaced. the contact attempted to contact the manufacturer to no avail. the vehicle was not repaired. the vin was unavailable. the failure mileage was 89,000. kmj | |||
| 03/09/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. while the contact started the ignition, the air bag warning indicator began to illuminate continuously until the engine was turned off. the vehicle was taken to an authorized dealer, where the front driver's side air bag was replaced. one year later, after the repair was performed the failure recurred. the air bag was replaced for a second time. the manufacturer was notified of the failure. the approximate failure mileage was 89,000. sm. | |||
| 01/14/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. the contact stated that the driver side air bags were previously replaced under warranty due to the warning light illuminating continuously. the vehicle was taken to the dealer for routine maintenance but the dealer informed him that the air bags needed to be replaced. the contact attempted to contact the manufacturer to no avail. the vehicle was not repaired. the vin was unavailable. the failure mileage was 89,000. kmj | |||
| 03/09/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. while the contact started the ignition, the air bag warning indicator began to illuminate continuously until the engine was turned off. the vehicle was taken to an authorized dealer, where the front driver's side air bag was replaced. one year later, after the repair was performed the failure recurred. the air bag was replaced for a second time. the manufacturer was notified of the failure. the approximate failure mileage was 89,000. sm. | |||
| 01/14/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. the contact stated the air bags on the driver side was replaced previously under warranty due to the warning light illuminates continuously. the vehicle was taken to the dealer for a routine maintenance on the engine light but the dealer informed him that the air bags needed to be replaced due to the re-occurrence of the warning light. the repairs would be $750 and it would be at the expense of the contact. the contact informed them it was replaced previously under warranty and they cannot afford to replace it again. the contact stated they tried to contact the manufacturer but had no response. the vin was unknown. the failure mileage was 89,000. mw | |||
| 03/09/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. while the contact started the ignition, the air bag warning indicator began to illuminate continuously until the engine was turned off. the vehicle was taken to an authorized dealer, where the front driver's side air bag was replaced. one year later, after the repair was performed the failure recurred. the air bag was replaced for a second time. the manufacturer was notified of the failure. the approximate failure mileage was 89,000. sm. | |||
| 03/09/2011 | 89000 | ||
| Tl-the contact owns a 2004 volvo s40. while the contact started the ignition, the air bag warning indicator began to illuminate continuously until the engine was turned. the vehicle was taken to an authorized dealer where the front driver's side air bag was replaced. one year later, after the repair was performed the failure recurred. the air bag was replaced for a second.the manufacturer was notified of the problem. the approximate failure mileage was 89,000. js | |||
| 10/04/2008 | 1 | ||
| On october 4th i was involved in a car accident in which a driver hit my car on the driver's side pushing my car down a pth in the woods in fairfax, va. my airbags did not deploy although the sensors were activated according to the collision center. *tr | |||
| 09/18/2004 | 3 | 08/30/2004 | |
| Multiple failures. air bag system, problem starting and noise in steering. *bf the vehicle also had an air condition problem. the air bag light illuminated on 3 occasions. the consumer stated the passenger seat was equipped with a device that weighed passengers to determine if the air bag should be activated. *jb | |||
| AIR BAGS - FRONTAL | |||
| 02/06/2009 | 80000 | 1 | |
| The event leading up to the failure is simply a defective part after some usage due to a poor welding job at manufacture. volvo has only recalled one vehicle to my knowledge but they needed to recall all vehicles during that year. the failure is the car has a hard time stopping when the brakes are applied the care continues to move and rough engine idle. the parts that were replaced were the vacuum pump and valve at brake booster, hoses, lines and fittings. repair cost $840. the air bag light has continued to come on/off since the purchase of the car. it is defective. the drivers side sips bag needs replacing total cost $801. *tr | |||
| 03/12/2009 | 40000 | ||
| Tl*the contact owns a 2004 volvo s40. while driving less than 50 mph, the contact crashed into the rear of the preceding vehicle. the passenger side air bag deployed, but the driver's side air bag did not. a police report was filed. the driver was transported to the hospital and released with no major injuries. the manufacturer stated that they performed a complete safety inspection on the vehicle prior to selling it to her, and the diagnostic did not indicate any failure with the air bag. the failure and current mileages were less than 40,000. | |||
| 07/19/2005 | 19215 | 2 | |
| During a frontal drivers side crash the drivers side airbag did not deploy causing injury to the driver. however the passenger side airbag did deploy, but no passengers were present at the time of the accident. the impact of the crash was mostly drivers side. i also believe the braking system failed since my car failed to slow like a car should during braking. | |||
| AIR BAGS - FRONTAL - SENSOR/CONTROL MODULE | |||
| 08/10/2006 | 10000 | 30 | 06/09/2004 |
| The vehicle has the following intermittent electrical problems. dashboard, radio, climate controls turn-off by themselves. wipers activate by themselves. srs warnings are displayed. fuel door button does not activate. ignition will not active so car will not start. *jb | |||
| 03/15/2005 | 7 | ||
| Consumer complained about electrical problems. the windshield wipers suddenly cut on and off at times; the power windows and doors did not work, and gas gauge always showed that vehicle had no fuel. also, airbag light came on. finally, the trunk did not open. *ak | |||