Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
SMB 28 200 | 08/01/2008 | 10026148 | Volvo: pzev (s40/v50) vehicles have extended warranty coverage for the engine manage ment software (ems) on some model year 2003-2008 models. pzev csc letter was received. *pe | 10/02/2008 | |
SMB-28-200 | 08/27/2008 | 10026145 | Volvo: extended warranty coverage for the engine management software (ems) on some model year 2003-2008 models. p-54 csc letter was received. *pe | 10/02/2008 | |
SMB 28-200 | 08/27/2008 | 10026146 | Volvo: extend warranty coverage for the engine management software (ems) on some model year 2003-2008 models. p-55 csc letter was received. *pe | 10/02/2008 | |
19273 | 06/23/2008 | 10025687 | Clunking during shifting and vibration through floor. s40 and v50 customers may complain of a clunking noise during shifting or when applying and releasing the accelerator pedal. especially noticeable on cars with manual transmissions. * | 08/29/2008 | |
3658 | 05/01/2007 | 10022341 | Immobilizer warning lamp lit or flashing, immo-dtc 321. *kb | 08/02/2007 | |
2872 | 05/07/2007 | 10022340 | Dtc ecm - 130a mass air flow sensor, faulty signal, dtc ecm - 250a long term fuel trim, lower limit, in limited adaptation areas. *kb | 08/02/2007 | |
21021 | 05/09/2005 | 21021 | 10016649 | Engne may have rough idle, dtc ecm misfire codes, rough running or lack of power. *sc | 09/26/2005 |
2121 | 05/12/2005 | 2121 | 10016499 | Engine may have a rough idle, dtc ecm misfire codes, rough running or lack of power. *sc | 09/14/2005 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
2523 | 02/22/2006 | 10019393 | Installation and removal of crankcase breather check valve. *tt | 03/14/2006 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
02/22/2012 | 81356 | ||
First occurence about 87000 miles was traveling on freeway when car stalled. started it back up and check engine light came on. took vehicle to dealer and they installed new spark plug and wires. stalled again at about 89000 miles and was told to bring back when check engine light came back on. check engine light came on again and took vehicle in on saturday but store was remodeling and couldn't get me in. took car in for 90000 mile service and check engine light was on. was told that spark plugs were installed. i informed them i had spark plugs and wires installed the last service and that this stalling of my vehicle is dangerous. was told that after the spark plugs were installed it cleared the check engine light and that i would have to bring the car in agin when the check engine light was on. dearlership has been of no help with this issue. looked online for people with similar problems and it points to recall #08v033000. | |||
02/26/2011 | 130000 | ||
Tl- the contact owns a 2004 volvo s40. the contact turned the vehicle on and the engine revved up to 4000 rpm | |||
12/01/2008 | 36000 | ||
Tl* the contact owns a 2004 volvo s40. the contact stated the brake warning light would illuminate while driving at any speed, causing the vehicle to shut down. the vehicle was taken to the dealer three times for the failure and the dealer reprogrammed the computer software each time. on a separate occasion, the failure recurred and the vehicle was towed to the dealer. the dealer advised the computer module would need to be replaced. the manufacturer advised an inspector would assess the failure further. the contact was awaiting results. the failure mileage was 36,000 and the current mileage was 40,000. | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
12/12/2009 | 48000 | ||
Tl* the contact owns a 2004 volvo s40. while driving 50 mph the check engine light illuminated on the instrument control panel, and then the vehicle stalled. after a period of waiting she was able to restart the vehicle. the volvo manufacturer was notified, but no assistance was provided. the failure mileage was 48,000. | |||
08/19/2005 | 4 | 10/31/2003 | |
The engine dies intermittently once every six months. this normally happens when making a right turn or slowing down. all of the warning lights in the dashboard light up. the gear must be put back in park, must turn off the ignition and then re-start again. the first time it happened, i thought it might have been a fluke, the second time i took it in they changed a valve in the engine, the third time they kept the car for 2 weeks and they changed the air compressor and positive/negative battery cables (they had a volvo of north america technician come down). the last time it happened was friday, august 19, 2005. i've called the dealership and they don't seem to want to take my call. | |||
09/18/2004 | 3 | 08/30/2004 | |
Multiple failures. air bag system, problem starting and noise in steering. *bf the vehicle also had an air condition problem. the air bag light illuminated on 3 occasions. the consumer stated the passenger seat was equipped with a device that weighed passengers to determine if the air bag should be activated. *jb |