Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | ||||||||||||||||
07E023000 | CARDONE INDUSTRIES, INC. | E (Equipment) | 13128 | 04/02/2007 | MFR | VOLVO CARS OF N.A. LLC. | 03/29/2007 | 03/29/2007 | ||||||||
Defect Summary | Certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid. | |||||||||||||||
Consequence Summary | Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780. | |||||||||||||||
Notes | This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||||
0007 | 11/01/2003 | 10005319 | Brake vibrations, analysis and corrective action. *tt | 02/20/2004 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - VACUUM | |||||
5202 | 01/30/2001 | 620147 | This bulletin states that certain models now have different brake pedal feel due to the brake booster characteristics. with newer cars, the brake booster is more sensitive to changes in the vacuum from the engine, which may result in slig | 07/19/2001 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES | |||
06/01/2012 | 128000 | 1 | |
When i apply pressure to the brake pedal i get an error message sometimes, not always, that says check brake lights. when the message is up, the left and right brakes in the back of the vehicle do not illuminate, but the middle one in the back of my rear window still does. when the message goes away, all lights illuminate. *tr | |||
06/01/2012 | 128000 | ||
When i apply pressure to the brake pedal i get an error message sometimes, not always, that says check brake lights. when the message is up, the left and right brakes in the back of the vehicle do not illuminate, but the middle one in the back of my rear window still does. when the message goes away, all lights illuminate. | |||
SERVICE BRAKES, AIR | |||
10/23/2010 | 166800 | ||
Lower brake lights fail while upper rear windshield light continues to work. had this work done once in 2005 to correct the wiring situation and now it is having to be done again. i feel this is completely dangerous for both brake lights to fail at the same time. reading online forums has led me to believe this is a widespread issue with the 2001 volvo s60 | |||
SERVICE BRAKES, HYDRAULIC | |||
10/28/2009 | 99000 | 1 | |
Driving 2001 volvo s60 2.4t at 30 mph, stepped brakes and they locked up (car has abs) causing complete loss of control. went into spin and crashed over curb, breaking both passenger side rims and gauging rear tire. had to be towed; one week later, car still in shop. mechanic can find no reason for this...no fault codes on computer, fluids, wires, etc all fine. *tr | |||
09/05/2006 | 142000 | 1 | 09/01/2001 |
Dt*: the contact stated the vehicle accelerated on its own after reaching 30 mph and caused an accident. the contact tried braking, but the brakes failed, due to the throttle issue. the vehicle was not taken to a service dealer to address the issue. a police report was taken. | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
04/25/2005 | 52000 | 50 | 01/22/2001 |
Dt: consumer stated 2001 volvo s 60 was having a problem with the unit that regulated the air flow into the brakes and engine. the car was making a hissing sound, like air being let into the cabin. this was happening a lot, especially in the heat. the brakes had to be depressed to get the car to stop. consumer had the car fixed last week at the dealership; the mechanic informed consumer that the air pump to the brakes had to be replaced. this vehicle was not stalling,or losing power, nor were there near misses. consume r was just responding to this because of what she saw on the news. the warranty expired. repairs were done at consumer's expense. *ak |