Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 37-35 | 02/06/2008 | 10020121 | Cem harness terminal corrosion due to water entrance in plenum. *tt updated 4/7/08. *nj | 07/24/2006 | |
| 3204 | 12/14/2005 | 10018776 | Cem diagnostic trouble code dd21 due to faulty lin-network, alternator not charging. *tt | 01/13/2006 | |
| ELECTRICAL SYSTEM - SOFTWARE | |||||
| TJ-14902 | 11/19/2010 | 10037485 | Ready | 05/24/2011 | |
| TJ-14902 | 11/19/2010 | 10037485 | Volvo: software being downloaded is interrupted and the cem fails. there is a cem recovery method. *rm | 05/24/2011 | |
| RTJ-20756 | 10/30/2009 | 10032914 | Volvo: differential electronic module (dem), software. this technical journal applies to all awd model vehicles, starting from 2003. *pe | 06/11/2010 | |
| RTJ-20756 | 06/11/2012 | TJ-20756-2 | 10032914 | Volvo: differential electronic module (dem), software. this technical journal applies to all awd model vehicles, starting from 2003. *pe updated on 4/10/2012. *kb updated 6/13/12. *pe | 06/11/2010 |
| RTJ-16629 | 05/15/2009 | 10030359 | Volvo: leakage detection diagnostics improvements to remedy dtc's. all models from model years 2003-2008. diagnostic monitor for the evaporative emission system small leak, has used a software function that calculates leakage based on a pr | 09/24/2009 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 07/22/2011 | 105000 | ||
| Vehicle has stalled without any warning several times while traveling at highway speeds (60 mph). first incident occurred during the summer of 2011 at 105,000 miles. a second, similar incident occurred in the fall of 2011 at 108,000 miles. auto scandia in herndon, va, replaced mass air flow meter in an attempt to address the problem. the vehicle performed well for several months without incident. unfortunately it stalled again in march 2012. this was also without any warning while traveling at highway speeds (60 mph). the unusual highway breakdown was very dangerous. | |||
| 12/17/2009 | 67728 | 1 | |
| Headlight wiring and connector burned causing light to go out. the dealer replaced the wiring and connector according to a tsb issued by volvo. dealer stated that they had repaired several volvos with this problem. although the dealer said this was a safety issue and volvo issued a tsb and provided a repair kit for repairs volvo does not consider this a safety issue. thankfully, only one light burned out at the time otherwise i would have crashed at 70 mph. dealer said both headlight wiring cables and connectors were burnt and they replaced both. i reported this safety issue to tennessee and kentucky consumer protection division. this one light went out on several occasions before i took the car to the dealer and discovered the safety problem. repairs made at my cost. *tr | |||
| 11/11/2009 | 66000 | 1 | |
| I have a 2005 volvo s60r which has a vehicle immobilizer in which if it there is not a 2 way communication between the car and the key, it prevents the car from starting. nice feature, but i called 3 dealerships when i got this warning and there is no workaround. so if i have an emergency, of if i am in a bad part of town, i cannot use my car... this is a major safety flaw... *tr | |||
| 07/14/2007 | 12000 | ||
| Tl*the contact owns a 2005 volvo s60. while attempting to make a right turn at 25 mph, the vehicle would sporadically stall without warning. the vehicle was able to restart immediately. the dealer could not duplicate the failure. two weeks later, while driving approximately 65 mph, the vehicle completely lost power. the failure prevented the contact from safely maneuvering to the side of the road and she could not activate the hazard warning lights. the following day, she took her vehicle back to the dealer and was informed that her vin was not included in nhtsa campaign id number 06v441000 (vehicle speed control). the vehicle has not been repaired. the failure and current mileages were 12,000. | |||
| ELECTRICAL SYSTEM - WIRING | |||
| 06/10/2005 | 37 | 2 | 06/09/2005 |
| Picked up my brand new 2005 (4 miles on odometer) volvo s60 on june 9 at dealer. while driving to work the next am, and with 37 miles on the odometer, i approached an intersection. i braked normally and came to a stop. without warning, the engine raced and the car drove into the intersection. my foot was still on the brake. i narrowly missed an on coming vehicle. i regained control and got the vehicle off the road. the car seemed to operate normally and i tried several stops and starts without problem. i continued towards work and about 5 miles later the same thing happened at another intersection. without warning the engine raced (tach shot up) and the car took off on its own. i contacted volvo and had the car towed away. volvo later told me the main engine computer registered a fault code caused by a loose wire. i asked for details and the fault code number but volvo did not respond. the dealer claimed they fixed the problem. i request your help to resolve this dangerous situation. this car may be defective or there may be a systemic design or manufacture defect that endagers volvo drivers. i am reminded of the audi 5000 problem. my problem sounds the same. | |||