Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 2867 | 03/10/2006 | 10019640 | Dtc 275c engine coolant temperature sensor (ect) signal too high. *tt | 04/12/2006 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 28-200 | 09/26/2008 | 10026143 | Volvo: extend warranty coverage for the engine management software (ems) on some model year 2003-2008 models. p45 csc letter was received. *pe ref: 10026144 (p-46), 10026145 (p-54), 10026146 (p-55), 10026147 (p-76). updated 6 | 10/02/2008 | |
| 46-13 | 04/18/2008 | 10024466 | 5 cylinder angle gear leakage and resealing. on all wheel drive models. *nj updated 6/5/08. *nj | 04/16/2008 | |
| 46-11 | 05/15/2008 | 46-11 | 10022698 | Dem dtcs (differential electronic module diagnostic trouble codes). *nj updated 4/7/08. *nj updated 7/14/08 *pe | 09/21/2007 |
| 2866 | 07/07/2006 | 2866 | 10019641 | Ecm dtc 434c fuel tank system, leakage. minor leak. *tt | 04/12/2006 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 10/25/2011 | 72702 | ||
| The electronic throttle module had to be replaced in my 2006 volvo s60. the car only has 72,702 miles! this is after having paid several hundred dollars to have the etm cleaned several months ago. the cost to replace the etm was over $800. as i search the internet, these cars seem to have problems with this particular part. it's ridiculous to think that i'm going to have to keep paying for this part, especially when the car is only 5 years old and has far less than 100,000 miles!!! i demand a recall and warranty replacement! the service manager at my local volvo dealership tells me these units need to be cleaned or serviced about every 30k miles. i have a copy of my receipt from this weeks service. this part should be covered under a warranty by the manufacturer! believe me, i'm active on the web and i'm going to tell everyone i know to stay away from volvos. | |||
| 08/01/2009 | 15000 | ||
| Tl* the contact owns a 2006 volvo s60. the contact stated that intermittently when attempting to start the vehicle it failed to start. the vehicle was taken to the dealer and the technician could not duplicate the failure or provide a remedy. the failure mileage was 15,000 and the current mileage was 47,000. | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| 04/03/2006 | 17000 | 3 | 09/05/2005 |
| Dt*: the contact stated while making a left u-turn at low speeds there was a knocking sound heard coming from the passenger side front near the tire. the dealer inspected and determined the link arm was broke in half and needed to be replaced. also, the coolant light illuminated and the sunroof would not open. the dealer determined there was a crack in the radiator and the sunroof module was inoperable, and both were replaced. | |||