Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 0052 | 01/01/2004 | 10006514 | Installing the seal plug in the cylinder block. *mr | 05/05/2004 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 46-13 | 04/18/2008 | 10024466 | 5 cylinder angle gear leakage and resealing. on all wheel drive models. *nj updated 6/5/08. *nj | 04/16/2008 | |
| 123A | 11/01/2003 | 10005321 | Faulty calibration data in the engine control module (ecm) may under some conditions cause the evaporative emission (evap) diagnostic software to operate incompletely. service campaign 123a. *tt | 02/20/2004 | |
| 2322 | 10/15/2002 | 10000301 | Crank no start, no fuel pressure. *tt | 02/21/2003 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 0051 | 02/01/2004 | 10006259 | Vvt solenoid, cleaning. *mr | 04/27/2004 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| 0013 | 11/01/2003 | 10005276 | Evaporative emission (evap) system software. service campaign no. 123a. *tt | 02/18/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 11/14/2009 | 105000 | ||
| Tl*the contact owns a 2002 volvo s80 t6. while driving various lower speeds to include approximately 10 mph, there was hesitation and the vehicle surged forward. the dealer stated that there were no recalls or warranties. the computer diagnosis did not list any failure codes. the vehicle was not repaired. the failure mileage was 105000 and the current mileage was 106000. | |||
| 01/18/2008 | 47600 | 2 | 01/01/2006 |
| Tl*the contact owns a 2002 volvo s80. while driving 65 mph, the throttle control and pcv components failed and would not perform correctly. the contact took his vehicle to the dealer and they stated that the throttle control and pcv may have been clogged. the failure could result in serious injury or death. the dealer did not state which one was the cause of the failure. the manufacturer has not been notified. the failure and current mileages were 47,600. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 07/19/2008 | 63000 | ||
| 2002 volvo s80 transmission failed at 63,000 miles, replaced with new volvo transmission, lasted 2 years 1 month, volvo states 2 years is the warrenty, so far we have 8900.00 in repairs to this car in the last 3 years,this car is a real lemon | |||