Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
3658 | 05/01/2007 | 10022341 | Immobilizer warning lamp lit or flashing, immo-dtc 321. *kb | 08/02/2007 | |
226 | 07/15/2004 | 10008742 | Adapter cable. service campaign 130b. *mj | 08/19/2004 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
2831 | 06/06/2001 | 621872 | Fault tracing diagnostic trouble code 78, crank no start / long cranking time; and / or intermittent dsa light. *tt | 10/03/2001 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
250036 | 01/01/2004 | 10005197 | Long crank on start could be caused by exhaust gasses remaining in the intake manifold from the previous engine shut down. installing a vent valve will allow the intake manifold to purge the gasses into the exhaust system. extra control va | 02/12/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
250026 | 05/01/2001 | 621854 | Customer may comment about noise from the exhaust system. this bulletin involves replacing missing retaining nuts for the exhaust manifold. *tt | 10/03/2001 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
04/09/2006 | 56000 | 04/28/2001 | |
2005 (sep/nov/dec): engine check light on 3 times. dealer repaired all 3 times and following months, which is 2006, having sudden shifting/accelarating at low speed. dealer fixed 2 times and 1 time couldnot find the issue. aug. 18, 2007: continued having same problems plus car was jerking on fwy speed. two days later, i couldn't start the car. dealer replace neg. battery cable and #4 ignition coil. aug.21, 2007: called to inform volvo north america and they suggested that i should talk to dealer service manager. aug. 27, 2007: the car is having same issue: sudden shifting @ low speed & jerking on fwy speed. this is very dangerous to drive and i don't know when the car is going to stall middle of fwy. i told the dealer that the car symptons are very much like etm problem (recall) on other models. aug. 29,2007: dealer replaced another #3 ignition coil and spark plug. i don't know how many times i will have to go back to the dealer for repeat repair. the dealer didn't bother to check etm unit. so far, i am lucky that i haven't gotten accident. (same dealer service my car since 2001) | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
12/03/2001 | 25000 | 100 | |
Tl*the contact owns a 2001 volvo v40. the current mileage was 105000. the check engine warning indicator light turns on. the vehicle has been taken to both volvo repair shops and local mechanics numerous times for this failure. they are able to turn the light off; however, it usually comes back on within three weeks. the dealer is unable to diagnose the failure. the failure mileage was 25,000. the engine size is unknown. the vin was provided but appears to be invalid. | |||
06/27/2005 | 41901 | 2 | 05/21/2002 |
Over the weekend my check engine came on in my v40 wagon. when idle it acted as if it was going to stall. a few times it did, when idle at a stop. it did restart most of the time right away, but a few times it took a couple of tries and waiting. i made an appointment to bring it in for service on 6/28. on 6/27 i was taking my 7 month old baby to day care when it stalled in the middle of driving. luckily there was no one behind me and i was able to pull to the side of the road. the car went completely dead while driving approximately 45 mph. i had a bit of trouble restarting it - but it eventually restarted. i was very nervous the rest of the way to the day care, but i made it without it stalling. i was able to leave the day care and decided to get to work and have it towed to the dealership. it stalled again. after many tries and 30 minutes later it started and i made it to work. i had it towed to volvo. they found a power supply interruption code -ecm30 and replaced the mass airflow sensor. picked up the car later that day and on my way home from work the check engine came on again. as i pulled into my driveway it started stalling again. took it back to volvo on 6/28. they worked on it for 5 hours while i waited. they replaced the front oxygen sensor, still had problems, replaced the rear oxygen sensor, the light still came back on. replaced both sensors again and loaded software. that seemed to do the trick. i haven't had that same problem again so far. but i am noticing that my v40 sometimes slows (rpms rev up to around 4,000) when accelerating. this was very dangerous because when i needed to accelerate into traffic, vehicle slowed down. when i read in the paper about other volvo models have similar occurrences, i wanted to make sure someone new of the same type of problem happening in the 2001 v40 wagon. every repair was under warranty and did not cost me anything thank goodness. my warranty is up this week -sure hope this doesn't happen again.*jb |