Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | ||||||||||||||||
98V254000 | VOLVO CARS OF NA, INC. | from 01/01/1997 to 10/31/1998 | V (Vehicle) | 50835 | 11/16/1998 | ODI | VOLVO CARS OF N.A. LLC. | 10/14/1998 | 10/15/1998 | |||||||
Defect Summary | Vehicle description: station wagons equipped with third seats. users of the third seat, when exiting the vehicle, can come in contact with the tailpipe. | |||||||||||||||
Consequence Summary | Contact with the tailpipe can result in personal injury. | |||||||||||||||
Corrective Summary | Dealers will inspect the length of the vehicle's tailpipe and, if necessary, repair the tailpipe. | |||||||||||||||
Notes | Owner notification began november 16, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-458-1552.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
2260002 | 06/01/1999 | 608294 | This service bulletin describes how to install a nipple to the drainage hole in the intercooler. *tt | 11/18/1999 | |
2260002 | 06/01/1999 | 606583 | Information on how to install a nipple in the intercooler. *tt | 08/27/1999 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
4460008 | 03/01/2002 | 635176 | On some vehicles oil weepage can be found at the bevel gear vent. *tt | 10/18/2002 | |
0023 | 07/01/2002 | 0023 | 6089468 | Bulletin describing how to correct condition of oil leakage occurring at one or more of the oil pump retaining screws. *tt this bulletin replaces the previous sb21-0023 dated october 1999. *tt | 02/03/2000 |
2210015 | 06/01/1999 | 608253 | Information on adjusting the mechanical camshaft belt tensioner and camshaft belt. *tt | 11/12/1999 | |
2510 | 06/04/1999 | 607363 | Information regardng pulsed secondary air injection system diagnosis. *tt | 09/21/1999 | |
430004 | 11/01/1998 | 602662 | Information on replacing a new type of oil bevel gear. *yc | 01/06/1999 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
2840 | 12/21/2001 | 629014 | Subject regarding engine management system service manual tp2321201. *tt | 03/26/2002 | |
2109 | 02/01/2000 | 613429 | Some vehicles may exhibit a malfunction indicator lamp on with diagnostic trouble codes indicating misfires and / or a hard engine start condition. *tt | 07/13/2000 | |
210004 | 08/20/1998 | 601714 | A new screw for the engine connecting rod cap has been released. *yc | 08/20/1998 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
2230031 | 12/01/1999 | 610425 | This service bulletin describes replacement of the fuel tank evaporative hoses. *tt | 04/28/2000 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
2250010 | 02/01/2000 | 2250010 | 610588 | Subject regarding new routing of wiring for oxygen sensor. *tt | 05/08/2000 |
2307 | 09/30/1997 | 6089534 | Subject regarding maf sensor dtc 1-2-1 on high and low pressure turbos. *tt | 02/04/2000 | |
2250010 | 06/01/1999 | 2250010 | 606269 | Subject regarding new routing of wiring for oxygen sensors. *tt | 08/13/1999 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
10/30/2005 | 135000 | 1 | 07/31/1997 |
The timing belt holder broke on my 1998 volvo while on driving on us route 40 in chapel hill north carolina. this caused a complete loss of acceleration. fortunately we were in the right lane and were able to pull off the road. *jb | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
07/18/2005 | 77251 | 4 | 03/01/1998 |
Vehicle randomly shuts off while driving. engine shut-down with loss of power steering control. disabled vehicle with groceries and small children inside on a 90+ degree (very hot!!)afternoon in mid-july. $322 for replacement of air flow device (meter or sensor?) to correct problem. approx. $50, loss of perishable food. *jb | |||
02/03/2005 | 101000 | 1 | |
The camshaft belt tensioner broke which caused the belt to come off and the vehicle to lost power while driving 70 mph. the owner has contacted the manufacturer who refused to do anything about this. *jb timing belt tensioner, belt and valves and head gasket needed to be replaced. *tt | |||
06/26/2003 | 1 | ||
While traveling on the highway check engine light will appear on the dashboard. due to the gasoline cap being loose the check engine light will appear on the dashboard. consumer has to go to the dealer to have it turned off.*ak | |||
12/01/1997 | 10 | 11/01/1997 | |
There have been numerous electrical failures with the car on a routine basis. there have also been oil leaks, gasoline leaks, air conditioner failure and seat belt failures. the car has been repaired almost on a monthly basis since the beginning of ownership. this past week, it has been repaired three times for electrical problems related to the seat belts and air bags. the volvo dealerships have made the necessary repairs and warranties have paid most of the costs, the amount of time this car has spent being serviced is totally unacceptable. even the volvo dealer here in florida (plantation volvo) suggested we research the florida lemon law. the law does not apply to us because the car was purchased in massachusetts. we would appreciate any assistance in getting volvo's attention that this particular car has major flaws, especially electrical. | |||
03/08/1999 | 1 | ||
Had driven vehicle .after routine service when engine stopped cold, tried starting, but nothing. smoke started coming from under the hood. then the engine caught on fire. *ak | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
07/03/1999 | 1 | 04/02/1999 | |
Vehicle is experiencing a power loss and has had to be jump started several times in order to get it to start, dealer can not find anything wrong. *slc | |||
A fire started in the engine compartment area without warning right after being serviced by a dealer. prior to this vehicle stalled once. vehicle was totaled. cannot determine what caused the fire. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
09/01/2004 | 1 | ||
The consumer's vehicle was tested and found to have high levels of carbon monoxide. *nm black smoke was belching out of the exhaust pipe. *sc the transmission failed. *jb | |||
12/27/1997 | 9 | 09/27/1997 | |
Consumers vehicle is emmiting a foul exhaust(rotten egg) odor which enters the vehicle when the driver's side window is down 2, the catalytic converter has been clean a replaced but the odor persist. nlm | |||
08/01/1997 | |||
Strong odor (sulphur?) on an intermittent basis. driver and passengers/children have become nauseous and pulled over to exit the vehicle. volvo claims it is a gasoline problem, but all instructions related to the gasoline type have been followed. volvo replaced the catalytic converter but this has not solved the problem. | |||
500 | 09/01/1998 | ||
Daily exhaust odor inside car when driver or passenger window is opened a little. this is a health hazard. it happens when there are no other cars around as well, so i know it is not coming from other cars. this has not happened in any other car we have had. it has not happened when i drive a loaner volvo (when my car is being serviced). dealer has checked this out several times and can't find a problem. this car has been in for service on one thing or another every 3-4 months. should i contact the health department since this could affect our health? we have to keep the air circulation button on inside air or exhaust comes in from other cars. is this car a lemon? do we have any options besides buying a different car? this complaint does not have anything to do with the airbags. i can't figure out how to change that information after i reviewed all of the information. sorry. *ak | |||
The defective exhaust system leaks into the cabin. cause unknown. please provide further information. *ak | |||
07/01/1998 | |||
The catalitic converter smells inside the car while driving. this is a problem that i had with a previous v70. after numerus complaints to volvo they replaced the car with a similar car. now i face this problem again. it is not as bad when i use the highest octane available and add octane boost. i consider these odors dangerous becouse i get headaches and burning eyes while driving. i would appreciate any info you may have about this problem. please follow up on this complaint. thankyou. | |||
07/13/1998 | 1 | 09/01/1997 | |
My 5 year old daughter suffered a second degree burn on her leg by coming into contact with the exhaust pipe tip at the rear bumper of the car by the lift gate. the exhaust on this car is extremely hot, subjectily, it feels much hotter than other vehicles that i own. i understand that there is a pe underway by nhtsa for this problem and just wanted to supply some data. my daughter is fine and has recovered completely and i don't expect to take any action against the manufacturer. they should be aware of this problem by now. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
07/14/2005 | 106063 | 1 | 06/15/2000 |
Stalling and check engine light. stalling at normal operating speed with resulting loss of power, steering and brakes. the mass air sensor and intake hose were replaced. *jb | |||
09/13/2003 | 2 | ||
I own a 1998 volvo v70. with less than 50,000 miles on the odometer, i have had to replace both the air pump and the abs control module. these parts should not have failed on a car that is five years old. since the car is past its warranty period, volvo will not reimburse me for these parts (a total of $1,273). in response to a letter from me, volvo said, in the event that either of these components is recalled, reimbursement could be considered at that time. please add my name to others who undoubtedly have complained about these faulty parts (air pump - pks70ap and abs/trac - 8602266) so that a recall can be issued. i would be glad to submit to nhtsa both letters between volvo and myself.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
08/10/2002 | 1 | 08/01/1998 | |
Child was burned by muffler in rear of vehicle. muffler is right at eye level to child. consumer feels this is very dangerous. *ak the child sustained 2nd degree burns by placing hand on the still hot muffler. a field rep. from volvo will asess the situation. *jg | |||
1 | 03/01/1998 | ||
Tail pipe failed. yh | |||
1 | 01/01/1998 | ||
Tail pipe caused 3rd degree burn, design is too exposed. yh | |||
1 | 10/01/1997 | ||
Child exiting vehicle burned on the tailpipe due to location. | |||
08/09/1998 | 1 | ||
Had parked vehicle & got out w/child. child went behind vehicle & was burned by tail pipe which was still hot. *ak | |||
06/06/1998 | |||
Vehicle was parked after a one hour drive. there is a third seat in the car. child climbed out of back and burned the calf on the tail pipe. the second child was walking around the car, and burned thigh on the tail pipe. dealer cannot duplicate the problem. *ak | |||
05/13/1998 | |||
Consumer's son was exiting from the rear door. when he stepped down his leg was right up against the tail pipe, he suffered 2nd degree burns. consumer was taken to doctor and was prescribed anti-biotics for infection due to burn. incident happened on may 13, which is the first time consumer was taken to the doctor and again on the 15 of may. *ak |