Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | ||||||||||||||||
04V451000 | VOLVO CARS OF N.A. LLC. | from 04/06/1999 to 05/15/2000 | V (Vehicle) | 149799 | 11/29/2004 | MFR | VOLVO CARS OF N.A. LLC. | 09/13/2004 | 09/20/2004 | |||||||
Defect Summary | On certain passenger and sport utility vehicles, under certain operating conditions, some electric cooling fans may overheat potentially causing heat damage and, in rare instances, a fire in the engine compartment. | |||||||||||||||
Consequence Summary | A fire in the engine compartment could occur. | |||||||||||||||
Corrective Summary | Dealers will replace the cooling fan. the recall began on november 29, 2004. customers should contact volvo cars at 1-800-458-1552. | |||||||||||||||
Notes | Volvo recall no. 141.customers can also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
25149B | 02/20/2006 | 25149B | 10019762 | Checking crankcase ventilation system. *ak | 04/26/2006 |
25149C | 02/20/2006 | 25149C | 10019763 | Cleaning the crankcase ventilation. *ak | 04/26/2006 |
ENGINE AND ENGINE COOLING - ENGINE | |||||
2322 | 10/15/2002 | 10000301 | Crank no start, no fuel pressure. *tt | 02/21/2003 | |
0023 | 07/01/2002 | 0023 | 6089468 | Bulletin describing how to correct condition of oil leakage occurring at one or more of the oil pump retaining screws. *tt this bulletin replaces the previous sb21-0023 dated october 1999. *tt | 02/03/2000 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
2220006 | 11/01/2000 | 220006 | 618508 | This service bulletin describes how to replace the piston cooling valve. *tt | 04/14/2001 |
2828 | 11/21/2000 | 615908 | Experience a rough cold start especially at higher altitudes. *tt | 02/02/2001 | |
2310 | 06/23/2000 | 2310 | 615027 | Information on how to run and evaluate an evap quick test on a car with the b5254s engine, which has the denso engine management system. *tt | 12/18/2000 |
2198 | 04/01/2000 | 610590 | Service campaign envolving the engine oil filler grake located in the engine oil filler neck of certain vehicles. *tt | 05/08/2000 | |
2210029 | 03/01/2000 | 610600 | Information on inspecting the oil filler grate located in the engine oil filler neck of certain vehicles. *tt | 05/08/2000 | |
2220006 | 12/01/1999 | 610445 | Information on replacing the piston cooling valve on gasoline engines. *tt | 05/01/2000 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
2250033 | 09/01/2002 | 10000085 | Heated oxygen sensor (ho2s) replacement. *tt | 02/12/2003 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
2829 | 05/24/2001 | 2829 | 621847 | Subject regarding mass air flow sensor replacement. *tt | 10/03/2001 |
120199 | 12/01/1999 | 6089456 | Recall campaign for vehicles with an incorrect emissions diagnostic software package. *tt | 12/01/1999 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
0031 | 11/01/2003 | 10005275 | New bracket in the sub-frame for mounting the catalytic converter. *tt | 02/18/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
149 | 02/20/2006 | 149D | 10018801 | Warranty coverage should a customer epxerience a defect wit the etm system beyond the terms of the normal new car warranty. *tt troubleshooting electronic throttle system (ets). *tt checking crankcase ventilation system. *tt cleani | 01/17/2006 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE | |||
05/22/2012 | 197593 | 1 | |
August 8, 2012 i am sending this complaint concerning the service i received on a recall for a 2000 v-70 volvo, campaign# r115 ( vehicle speed ), nhtsa -campaign# o6v441000, action # eaq-5021. i scheduled an appointment with a volvo dealership. i went to the scheduled appointment and left my vehicle to be serviced. i was called from the dealership and was told my car was ready for me to pick up. after driving my vehicle for about 15 min max. it began unfortunately with the same symptoms i previously was experiencing. i called the service department where i apparently had my car serviced for repair and was told by the manager that i would be responsible for another diagnosis, and that it was probably something else, since the recall service was done i decided to call the: volvocars.us telephone #, @ 1-800-458-1552. i thought for sure, i would receive the support i needed . i did not. i was told once again, i was responsible for the repair. very upset, needless to say, i proceeded once again, and called the manager at the volvo dealership. i expressed once again, my concern with the service performed. in addition to the service, i had some questions concerning the service invoice . they have yet to be answered. i have adolescent children who are passengers in my vehicle everyday, and we would so appreciate!!! our car serviced as it should be, please, this recall reads more than an upgrade. apparently this upgrade was completed, i beg to differ. thank you for your time and consideration in this very concerning matter, as i look forward to hearing from your office. at your most earliest convenience. *tr | |||
05/22/2012 | 197593 | ||
August 8, 2012 i am sending this complaint concerning the service i received on a recall for a 2000 v-70 volvo, campaign# r115 ( vehicle speed ), nhtsa -campaign# o6v441000, action # eaq-5021. i scheduled an appointment with a volvo dealership. i went to the scheduled appointment and left my vehicle to be serviced. i was called from the dealership and was told my car was ready for me to pick up. after driving my vehicle for about 15 min max. it began unfortunately with the same symptoms i previously was experiencing. i called the service department where i apparently had my car serviced for repair and was told by the manager that i would be responsible for another diagnosis, and that it was probably something else, since the recall service was done i decided to call the: volvocars.us telephone #, @ 1-800-458-1552. i thought for sure, i would receive the support i needed . i did not. i was told once again, i was responsible for the repair. very upset, needless to say, i proceeded once again, and called the manager at the volvo dealership. i expressed once again, my concern with the service performed. in addition to the service, i had some questions concerning the service invoice . they have yet to be answered. i have adolescent children who are passengers in my vehicle everyday, and we would so appreciate!!! our car serviced as it should be, please, this recall reads more than an upgrade. apparently this upgrade was completed, i beg to differ. thank you for your time and consideration in this very concerning matter, as i look forward to hearing from your office. at your most earliest convenience. | |||
ENGINE AND ENGINE COOLING | |||
04/11/2011 | 114500 | ||
Lost power in traffic, had to drive 10 mph in limp mode in heavy traffic | |||
08/27/2008 | 110000 | ||
Tl*the contact owns a 2000 volvo v70. the vehicle would shut off while driving at any speed. the dealer replaced some of the components. the contact merged into heavy traffic and the vehicle shut off again. the failure has occurred twice and been repaired twice; however, the contact is concerned that the failure will recur. the failure mileage was 110,000. | |||
10/01/2005 | 50 | 12/28/2001 | |
When i begin to brake and the car slows, it will simply cut off. it is getting progressively worse and cuts off about one-half the time i begin to come to a complete stop. i had this same problem several years ago, and it reached the point where it stalled at as i was driving in a roundabout at approximately 10 mph. i took the car to my mechanic and it was repaired. now, however, the stalling failure is recurring. although the field below requires a specific date, this problem is ongoing. *jb | |||
09/20/2004 | 85000 | 5 | 03/15/2000 |
The electronic throttle control module in my 2000 v70 volvo wagon was defective. the car ran badly, missed and stalled - brakes and transmission shifting was also affected. the situation continued to happen while on an extended trip with no volvo dealers within range. it took several trays for the dealer where i purchased the car to make the necessary repairs at a cost of about $900.00. i feel that the company should reimburse me since i understand that this situation is under investigation. *jb | |||
08/15/2002 | 64000 | ||
I read about your company in this past sunday's philadelphia inquierer. the air conditioning in my volvo no longer works, and i needed to replace the throttle body control. there are technical service bulletins on both of these items. i have not made the air conditioning repair yet because the estimate is $1600. i wrote volvo a letter on 5/15/03 about the air conditioning problem & asked them to call me. they wrote me a letter dated 5/19/03 & essentially denied any responsibility. i replied on 6/5/03 & again asked that they call me, but they did not. i called volvo on 7/8/03 and they said they would not change their position. in looking for the tsbs on my air conditioning problem, i also found one on a throttle control problem that i had previously replaced. there were definitely drivability problems with the throttle body before i had the repair made. the problem was once i started getting up to around 55-60 mph, the driving would hesitate. i originally thought it might be a transmission problem, as the problem drove similar to a transmission "slipping". they replaced the throttle body, not cleaned it like the tsb mentions. my feeling is that if these two items are design flaws, for which the design has since been corrected, then volvo should repair my vehicle regardless of the fact that it was out of warranty. i bought my volvo new on 3/16/2000 and it currently has 88,000 miles. the warranty was for four years/50,000 miles. | |||
06/15/2002 | 1 | ||
While pulling inside of the driveway, vehicle started smoking. vehicle was on fire. dealership was aware of problem.*ak to date, the cause of fire is still undetermined. it appears the coolant over flow bottle exploded and some how set fire to the engine. volvo wants to take no responsibility for the vehicle although it is still under warranty. *jg | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
02/03/2006 | 5 | 05/23/2003 | |
On 2/3/06 our volvo v70 year 2000, 74000m showed an ets light and check engine light. car stalled at upon stopping and also upon stopping at a stop light the vehicle would not accelerate. upon turning the car off and back on i was able to have it accelerate. the car would run ok for about 20 miles then lights came on again. contacted volvo byers in cols oh 614-864-0780 whom informed me that the throttle system is needing replaced. had the vehicle serviced on 2/6/06. byers perform fault tests and noted that there was low voltage and stated cables from battery were needing replaced. i informed them that i was confused with how this could cause the ets light and check engine light to come on and cause my car to stall and at times not accelerate while the car is running. they indicated that prior to fixing the ets they needed to fix this issue. the cost $463.59. they then cleared all fault codes and noted that there was no ets code present. i informed them that this is probably because they did not drive the car enough after it had been turned off as this is what occurred to me the day the ets caused problems. they insisted that it was repaired. however, on february 15, 2006 the ets and check engine light came on again and the car stalled upon stopping and the lights would turn off upon restarting then driving 10 miles turned back on. i called the dealer complaining about the issue and failure to remedy the initial cause of the problem. i addressed my frustration that i spent over $450 to fix a problem that may never have had to be fixed. researched other problems with volvo ets and found similar issues and experiences with this module. furthermore, i learn of a warranty extension but never received any documentation of any potential problem with the vehicle. this is a safety hazard. had i been stopped in an intersection/railroad track i would not have been able to accelerate the car to avoid potential injury. very frustrated with volvo in ohio. *nm | |||
07/23/2005 | 70000 | 1 | 01/15/2004 |
Driving along 495 heading west in fast lane at about 65 mph. etc light came on. i started moving over to breakdown lane and stoped. had to put the car in neutral as engine was surging. shut off engine. looked up etc in manual which said shut off engine then restart. after restarting, engine was surging. tachometer going up and down. switched off engine. opened hood to look for loose wire, connector or blown etc fuse. saw no loose wires or connectors. identified fuse. removed fuse, fuse looked fine. replaced same fuse. tried engine, problem disapeared! | |||
12/20/2000 | 1 | 10/01/1999 | |
While pulling in driveway at about 10 mp road was slipperry vehicle bumped into a curb. this broke front axle, there was no body damage to vehicle, oil pan was leaking. volvo co. said consumer lied about accident, and they are not liable.*ak *jb | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
10/06/2005 | 85604 | 8 | 05/25/2001 |
Loss of power while driving/multiple times (sometimes while pulling out into traffic). engine light came on. took to dealer who replaced throttle. *jb | |||
02/14/2005 | 90000 | 6 | 04/23/2000 |
Stalling in 2000 volvo v70. sudden loss of power and power steering assist. failure created dangerous traffic obstruction as disabled vehicle blocked roadway. repairing mechanic diagnosed defect in electronic throttle body and stated this is a well-known product defect in these vehicles. *nm |