Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | ||||||||||||||||
07E023000 | CARDONE INDUSTRIES, INC. | E (Equipment) | 13128 | 04/02/2007 | MFR | VOLVO CARS OF N.A. LLC. | 03/29/2007 | 03/29/2007 | ||||||||
Defect Summary | Certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid. | |||||||||||||||
Consequence Summary | Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780. | |||||||||||||||
Notes | This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||||
0007 | 11/01/2003 | 10005319 | Brake vibrations, analysis and corrective action. *tt | 02/20/2004 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
510006 | 04/01/2000 | 615014 | New rear brake pads for vibration when braking condition. *tt | 12/18/2000 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - VACUUM | |||||
5202 | 01/30/2001 | 620147 | This bulletin states that certain models now have different brake pedal feel due to the brake booster characteristics. with newer cars, the brake booster is more sensitive to changes in the vacuum from the engine, which may result in slig | 07/19/2001 | |
SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE LIGHT | |||||
0024 | 02/01/2004 | 10006306 | Recall campaign no.131 brake light relay. *mr | 04/28/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||
12/01/2005 | 1 | 05/27/2000 | |
2001 volvo v70 braking system failed and engine completely shut down without warning. *ts *nm *** no answer required*** | |||
12/03/2005 | 1000 | 10 | |
Volvo, 2001 v70 - vin yv1sw58d111019707 this specific vehicle is unreliable and unsafe. since purchased new, car has had multiple system failures leading to various unsafe driving conditions including brake system failure and engine failure (including loss of braking and steering systems). manufacturer has acknowledged unusual nature of this particular vehicle quality defects - concerned that car must be taken off road to avoid serious crash. please advise. *nm | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
10/10/2005 | 45000 | 1 | 08/09/2005 |
Abs module shows intermittent errors. when abs module has errors the abs system does not work. dealer suggests that it be replaced at my cost of $915.*jb | |||
Anti lock brakes will grab, not stopping smoothly when pedal is deployed. occupants are slung forward. this is common for this particular model, qualitative problem. please describe details. *ak | |||
05/14/2002 | 2 | 09/23/2001 | |
Consumer stated 2 other vehicles almost collided with each other, and a hydraulic sound was coming from brake pedal when brakes were applied, then vehicle vibrated and skidded across the lane of the highway.*ak *mj | |||
09/13/2001 | 50 | 06/01/2001 | |
Brakes travel to within 1 inch of floor and are too near accelerator. possible to simultaneously accelerate and brake at same time with a size 11/2 shoe.*ak | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE | |||
01/27/2007 | 70100 | 1 | 07/15/2001 |
Antilock system and stability tracking system failed abruptly during breaking. no crash occurred, only the system's warning lights came on and stayed on. lucky i was not in a panic break position as then the abs would not have functioned. i have made arrangements to repair the system independent of the volvo dealership since it is much cheaper and a more effective fix is possible than using volvo parts which after web searching is clearly defective. seems every vehicle with this system is failing at about 65 to 80k miles. my 2001 v70 t5 failed at 70k. | |||
SERVICE BRAKES, HYDRAULIC - POWER ASSIST | |||
07/01/2004 | 3 | 08/01/2003 | |
2001 v70 did not shift properly and clunked in and out of gear. consumer was told that the stabilizer motor mount was faulty. *ts the throttle body, cam shaft sensor and vacuum boost sensor needed to be replaced. *jb |