Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
VISIBILITY - WINDSHIELD WIPER/WASHER | ||||||||||||||||
06V144000 | VOLVO CARS OF N.A. LLC. | from 02/17/2004 to 05/13/2005 | V (Vehicle) | 122431 | 09/05/2006 | ODI | VOLVO CARS OF N.A. LLC. | 04/28/2006 | 04/28/2006 | |||||||
Defect Summary | On certain vehicles, if the wiper arm is activated in extreme winter weather conditions and without lifting the wiper arms and cleaning the windshield prior to moving, the wiper arm might slip on its driveshaft, resulting in an inability to move the wipers from the park position. | |||||||||||||||
Consequence Summary | Inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility. | |||||||||||||||
Corrective Summary | Dealers will replace the wiper arms and retaining nuts. the recall began on september 5, 2006. owners may contact volvo cars at 1-800-458-1552. | |||||||||||||||
Notes | Volvo recall no. r156.customers may also contact the national highway traffic safety administrationvolvo recall no. r156.customers may also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||||
8754 | 11/30/2005 | 8754 | 10018740 | Temperature coming out of the climate vents may start to cycle from max hot back to full cold when max hot is required. *ak | 01/12/2006 |
VISIBILITY - WINDSHIELD WIPER/WASHER | |||||
3650 | 05/24/2005 | 10017562 | Customer preparation service (cps), tightening nuts for windshield wiper arms which may slip on its driveshaft, reducing performance. *tt | 11/10/2005 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
VISIBILITY - WINDSHIELD WIPER/WASHER - LINKAGES | ||||||
PE05064 | VOLVO CARS OF N.A. LLC. | 12/02/2005 | 05/10/2006 | WINDSHIELD WIPER ARM PERFORMANCE | 06V144000 | |
The manufacturer notified nhtsa by letter dated april 21, 2006, that a safety recall has been initiated for correction of this problem on certain model year 2003 - 2006 volvo xc90 vehicles. the recall affects approximately 122,400 subject vehicles produced between august 2002 and october 2005.nhtsa has assigned no. 06v-144 to this recall action.the corrective action will consist of replacing the existing windshield wiper arms with a new reinforced design.based on this action, the subject pe has been closed. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
VISIBILITY - WINDSHIELD WIPER/WASHER | |||
03/16/2011 | 55000 | ||
Tl* the contact owns a 2005 volvo xc90. while driving approximately 40 mph in rainy weather, the driver attempted to turn on the windshield wipers but they would not engage. the vehicle was taken to an authorized dealer where the contact was told that the central electronic module would need to be replaced because rain was seeping into the engine compartments. the vehicle was not repaired. the failure and current mileage was 55,000. | |||
11/08/2006 | 50 | 10/22/2005 | |
Windshield wipers leave a streak across windshield, significantly impairing vision and making driving in rain hazardous. both wiper blades and windshield wiper arms were replaced by dealer - problem persists. this has been an ongoing issue since the car was purchased; dealer acknowledge the problem but has not adequately repaired the car. *jb |