Yamaha Yp400 2006

Model Yp400 made in 2006 by Yamaha got 3 consumer complains, 1 investigation there are 2 recalls as well as 1 service bulletin. Consumer complaints with reference, among others things, to engine and engine cooling, fuel system, gasoline. Technical service bulletines regarding engine and engine cooling. The car had one investigation (electrical system). There was one recall concerning fuel system, gasoline .

Model 2006

Recalls

CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
07V219000YAMAHA MOTOR CORPORATION, USAfrom 07/01/2004 to 04/30/2007V (Vehicle)1395806/18/2007MFRYAMAHA MOTOR CORPORATION, USA05/24/200705/24/2007
Defect SummaryOn certain motorcycles, a leak at the fuel pump seal may allow fuel leakage.
Consequence SummaryFuel leakage, in the presence of an ignition source, could result in a fire.
Corrective SummaryDealers will replace the fuel pump seal free of charge. the recall began on june 18, 2007. owners may contact yamaha at 1-800-962-7926.
NotesCustomers may contact the national highway traffic safety administration
08V180000YAMAHA MOTOR CORPORATION, USAfrom 07/01/2004 to 04/30/2007V (Vehicle)960005/09/2008ODIYAMAHA MOTOR CORPORATION, USA04/23/200804/22/2008
Defect SummaryYamaha is recalling 9,600 my 2006-2007 cp250 and my 2005-2007 yp400 motorcycles. the engine could stall and be difficult to restart because the wire terminals in the fuel pump wire coupler have corroded. water can enter from the main wire harness end and run through the harness to the fuel pump coupler.
Consequence SummaryIf the water remains in the coupler for an extended period of time, the terminals can become corroded, which can prevent the fuel pump from operating properly. if this corrosion affects fuel pump operation while the scooter is being ridden, there could be a crash resulting in injury or death.
Corrective SummaryDealers will install a sub-harness which is designed to allow any water between the wire harness and the fuel pump to drain out before it reaches the fuel pump. the dealer will also inspect the connectors. if either the main wire harness connector or the fuel pump connectors is already corroded, the corresponding assembly(ies) will also be replaced. the recall began on may 9, 2008. owners may contact yamaha at 1-800-962-7926.
NotesCustomers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Bulletins

BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ENGINE AND ENGINE COOLING - ENGINE
200701206/21/200710022493Coupler corrosion makes engine difficult to start. *kb08/15/2007

Investigations

NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
ELECTRICAL SYSTEM
PE08018YAMAHA MOTOR CORPORATION, USA03/18/200805/13/2008MOTORSCOOTER STALLING08V180000
 Odi opened this pe based on owner and ewr field reports alleging the subject scooters would stall while underway.after opening this investigation, yamaha decided to conduct a corrective safety recall (08v-180) in lieu of responding an odi information request.with that recall, this pe is closed.

Consumer Complaints

Fail datemilesoccurencesPurchase date
ENGINE AND ENGINE COOLING - ENGINE
06/10/200924511
 Tl*the contact owns a 2006 yamaha yp400v. the contact stated that while driving 10 mph, the scooter stalled without any prior warnings. as a consequence his risk for serious injury and crash were increased. the scooter was taken to a dealership in which a technician concluded that the fuel injector was the cause of the failure. the failures have not been remedied as of current date therefore the safety risk is present. the current and failure mileages were 2451. updated 12/30/09 *bf the dealer cleaned the electric fuel pump connectors. the consumer traded the scooter. updated 12/31/09.*jb
FUEL SYSTEM, GASOLINE
09/07/2007600
 Tl*the contact owns a 2006 yamaha yp400 motorcycle. the vehicle was repaired according to nhtsa campaign id number 08v180000 (fuel system, gasoline:delivery:fuel pump); however, it continues to stall and shut off. the contact feels that the actual harness was not replaced according to the remedy, and was only inspected at the time of the repair. the manufacturer informed him to take the vehicle back to the dealer for further inspection since the vehicle was originally repaired under recall. the contact inquired about replacing the harness and the manufacturer stated that they were unsure if the harness was replaced at the time of the recall repair. the dealer would have to notify the contact once the vehicle was re-inspected. the failure mileage was 600 and current mileage was 25,000. updated 07/24/09. *lj
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
06/10/200924511
 Tl*the contact owns a 2006 yamaha yp400v. the contact stated that while driving 10 mph, the scooter stalled without any prior warnings. as a consequence his risk for serious injury and crash were increased. the scooter was taken to a dealership in which a technician concluded that the fuel injector was the cause of the failure. the failures have not been remedied as of current date therefore the safety risk is present. the current and failure mileages were 2451. updated 12/30/09 *bf the dealer cleaned the electric fuel pump connectors. the consumer traded the scooter. updated 12/31/09.*jb

Car dealers selling

StateCityZipNamePhone
PAEMMAUS18049BLACKMAN'S CYCLE CENTER610-965-9865

Some parts © 2024 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.