Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STEERING - HYDRAULIC POWER ASSIST - PUMP | |||||
| 092603 | 09/26/2003 | 10006830 | Zf vh recall of the zf steering pump, supplied to wd's for replacement of the audi a4 passat p/n 8d0 145 156fx instead of the correct zf p/n 7691 955 276zw. 2004 audi a4 also included. *tt | 05/14/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STEERING | |||
| 09/19/2003 | 1 | 09/18/1995 | |
| Repeated front suspension/steering system component failures. *jb *ph *jb | |||
| 10/01/2001 | 71000 | 1 | |
| While driving power steering rack assembly failed, causing loss of steering and brake control. also sealer broke which resulted in power steering fluid to leak, damaging brake pads and disc. vehicle crashed damaging front end. dealership not willing to do anything. *tt *nlm | |||
| STEERING - GEAR BOX (OTHER THAN RACK AND PINION) | |||
| 10/01/2001 | 1 | ||
| While driving power steering box malfunctioned, causing loss of steering and brake control, also sealer broke which resulted power steering fluid leakage. *ak consumer stated while driving, steeing rack on the driver side blowed out gasket seak, the mineral oil spray out under pressure toward the inside of fdront wheel soaking brake pads and coating disc, vehicle was hard to steer.*slc | |||
| STEERING - HYDRAULIC POWER ASSIST - PUMP | |||
| 10/21/2002 | 66642 | 1 | |
| The tie rods of both front wheels were damaged. the rubber cap was broken on both and the tie rods had a lot of play at the joint underneath. the power steering pump failed causing noise when turning the steering wheel. the right front brake lamp failed. *nlm | |||
| STEERING - LINKAGES | |||
| 06/11/2001 | 3 | 10/01/1998 | |
| Absolutely the worst car i have ever bought i have spent over $6000 in repairs and gone just 40k miles! stay away from this car when i called the 1-800 line they were no help and customer service refused to let me speak with anybody in a higher postion. when i said can i write a letter they said sure but it comes to us and the decision is final about your warrantty defects. no safety defect listed. *ak | |||
| 08/23/2000 | 2 | 05/01/1998 | |
| Many other audi a-4 owners have complained about premature wear of tie rods and control arms in vermont. audi of america and local dealer refused to cover problem although voluntary recall in effect for newer audis. *ak | |||
| STEERING - LINKAGES - TIE ROD ASSEMBLY | |||
| 10/21/2002 | 66642 | 1 | |
| The tie rods of both front wheels were damaged. the rubber cap was broken on both and the tie rods had a lot of play at the joint underneath. the power steering pump failed causing noise when turning the steering wheel. the right front brake lamp failed. *nlm | |||
| 09/01/2096 | |||
| Audi of north america recalled their 1999 model a4s for failure of the tie rods. i own a 1996 a4 with tie rods that failed and audi of north america and the dealership refused to repair the damaged tie rods under the recall notice even though the failure was exactly as outlined in the original recall notice sent to all audi dealers. i read recently in the los angeles times that an owner with a 1998 a4 experienced exactly the same problem. it appears the recall should cover all model years of the a4. i requested and saved the damaged tie rods if you would have interest in seeing them. i believe this problem presents a severe danger to operaters of this vehicle and that this problem should be addressed immediately by audi. dt | |||
| 01/15/2002 | 1 | 07/01/1996 | |
| Control rods loose according to audi dealer. confirmed by independent repair shop. indpt shop also noted that tie rods were also so loose they were hazardous and indicated on receipt to show audi | |||
| 06/27/2000 | 1 | 08/01/1996 | |
| Inner tie rods were loose and worn out which could eventually cause loss of steering. recall for this problem, but this vehicle not included. *ak *ml | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 04/20/2011 | |||
| While driving west on pennsylvania rt. 401 i drove over a small bump in the road, where a drain is buried under the road, and the passenger side front lower a arm snapped in half at a speed of 45 mph causing a catastrophic failure and the car to grind to a halt on the shoulder of the road. | |||
| 01/01/1998 | |||
| Problems is with electrical system/ suspension and air conditioning system. dealership is aware of the problems. *ak | |||