Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
0507 | 11/21/2005 | 10018427 | Sporadically after cold start, engine may run slightly rough for a few seconds and the malfunction indicator lamp may illuminate with only misfire diagnostic trouble codes (dtc) (p0300, p0301, p0302, p0303, p0304) stored in dtc memory. *t | 12/22/2005 | |
190504 | 05/16/2005 | 10015583 | The coolant reservoir is diagnosed to be leaking and intended to be replaced. *tt | 07/29/2005 | |
0501 | 04/11/2005 | 10015100 | Fuel injectors unnecessary replacement. *eh | 05/19/2005 | |
0502 | 04/11/2005 | 10015102 | Fuel injectors unnecessary replacement. *eh | 05/19/2005 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
0503 | 04/08/2005 | 10015099 | Coolant leak or on heat in passenger compartment. *eh | 05/19/2005 | |
0411 | 11/21/2005 | 0508 | 10011581 | Update programming engine control module flashing to correct evap purge valve dtc p0441 in the audi 2004 cabriolet . *tc | 01/27/2005 |
0401 | 09/10/2004 | 10009734 | Map controlled engine cooling thermostat, servicing. audi a4 2002-2005 and audi cabriolet 2003-2005. *tt | 10/19/2004 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||||
0406 | 12/13/2004 | 10011880 | Coolant leak at oil cooler hoses. *tt | 02/03/2005 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
TSB-01-12-39 | 01/12/2012 | 10043525 | Audi: engine has reduced engine performance without loss of power or stalling; circuit grounds; fuel quality poor; mil is constantly illuminated or flashing; rough idle; ignition coils incorrectly installed; electrical connections loose or | 04/09/2012 | |
TSB-15-11-18 | 01/25/2011 | 10038249 | Audi: there is a ticking noise from the engine area which may be caused by wear in the camshaft. *rm | 06/14/2011 | |
TSB-15-11-18 | 01/25/2011 | 10038249 | Ready | 06/14/2011 | |
TSB-28-09-05 | 05/12/2009 | 10030629 | Audi: mil on, engine speed sensor spacer not required (dtc p0300, p0335, p0336, p0321, p0322). multiple misfires detected on one or more cylinders; malfunction indicator light (mil) may be on or flashing. *pe | 10/30/2009 | |
28 08 04 | 03/19/2008 | 10024722 | Mil on, engine speed sensor spacer not required (dtc p0300, p0335, p0336, p0321, p0322). *nj | 05/14/2008 | |
17 08 03 | 03/11/2008 | 17 08 04 | 10024407 | Engine oil pressure too low - engine flush. *nj updated 4/30/08. *nj | 04/11/2008 |
20036582 | 02/26/2007 | 10022142 | Loses power or will not move after stop. *kb | 07/06/2007 | |
2012833 | 05/17/2007 | 20128332 | 10021439 | Engine oil pressure too low - engine flush. *kb | 04/26/2007 |
380702 | 01/09/2007 | 10021314 | Shudders when accelerating at 10 to 50% throttle from a stationary position, sometimes with flucuating engine speed. *kb | 04/03/2007 | |
0604 | 04/07/2006 | 10020721 | Oil sludge limited warranty extension. *kb | 01/03/2007 | |
0431 | 08/11/2005 | 0515 | 10016508 | Repairs of oil sludge related problems. *tt | 09/20/2005 |
0402 | 07/26/2005 | 0506 | 10015982 | Engine oil specifications, oil capacity, oil filter. to include audi 24 2006. *tt | 08/18/2005 |
0401 | 11/12/2004 | 10011888 | Engine wire harness, heat insulation installation (ia). 2004 audi cabriolet also included. *tt | 02/03/2005 | |
97 | 10/08/2004 | 10011889 | Front oxygen sensor bank1 and engine wiring engine. also includes audi cabriolet 2004. *tt | 02/03/2005 | |
0420 | 08/01/2004 | 10009900 | Warranty extension covering certain oil sludge related repairs. *tt | 11/02/2004 | |
0403 | 08/05/2004 | 10009881 | Low engine oil pressure light is on. audi cabriolet 2004 included. *tt | 11/01/2004 | |
0420 | 08/26/2004 | 0431 | 10009876 | Oil sludge - warranty extension. service circular - warranty. *tt | 11/01/2004 |
0401 | 08/05/2004 | 0402 | 10009880 | Engine oil specifications, oil capacity, oil filter. *tt this bulletin replaces bulletin 04-01 dated jan. 12, 2004. 2004 cabriolet, audi included. *tt | 11/01/2004 |
0402 | 08/31/2004 | 10009879 | Valve cover, diagnosing oil leakage from gaskets. *tt | 11/01/2004 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
SAC-28F2-REV | 08/01/2010 | 10036497 | Audi: gasoline engine vehicles; inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. added final mailing phase-8/10 vin information. | 03/23/2011 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE | |||
10/04/2012 | 104000 | ||
Tl- the contact owns a 2004 audi a4. the contact stated that a week after having the oil changed, coolant flange replaced and the readiness codes reset the engine seized. the vehicle was towed to the dealer who diagnose that the engine needed to be replaced. the technician explained that the engine failure was not due to the repairs that were previously performed on the vehicle. the failure and current mileage was 104,000. pmb | |||
10/04/2012 | 104000 | ||
Tl- the contact owns a 2004 audi a4. the contact stated that a week after having the oil changed, coolant flange replaced and the readiness codes reset the engine seized. the contact had the vehicle towed to the dealer and was told the engine needed to be replaced. the dealer said the engine needed to be replaced, but that it was not because of the services that were done. the dealer did not say what caused the engine to seize. the failure mileage and current mileages were 104,000.rl | |||
ENGINE AND ENGINE COOLING | |||
07/08/2010 | 99000 | ||
Tl* the contact owns a 2004 audi a4. the contact was driving approximately 35 mph when the vehicle stalled with the illumination of several warning lights. the contact was unable to restart the vehicle and it was towed to an authorized dealer. the dealer advised that the engine failed due to a lack of lubrication and an internal compression failure. the vehicle was then taken to a local mechanic where the engine was rebuilt. after the repairs, the contact continued to experiences the failure with the sporadic illumination of the check engine warning light. the contact stated he performed a diagnostic which located the failure as a multi-cylinder misfire. the manufacturer advised that the vehicle be taken back to the dealer. the vehicle was not further repaired. the contact was concerned with his safety when operating the vehicle. the approximate failure mileage was 99,000 and the current mileage was 100,000. | |||
07/08/2010 | 99000 | ||
Tl-the contact owns a 2004 audi a4. while driving approximately 35 mph the vehicle lost all power and stalled, the contact stated he could not remember what warning lights illuminated on the dashboard. he attempted to restart the vehicle but it would not start. the vehicle was towed to an authorized dealer. the dealer advised him that the engine failed because of a lack of lubrication and a internal compression failure. the vehicle was taken to a local mechanic because of the cost of repairs at the dealer, and the local mechanic rebuilt the engine. after the repairs he was still experiencing the check engine light coming on intermittently. the contact stated he performed a diagnostic and was getting a multi cylinder misfired reading. the contact was concern about his safety. he contact the manufacturer and was advised to take the vehicle back to the dealer. the approximate failure mileage was 99,000 and the current mileage was 100,000. vwb | |||
10/24/2010 | 57000 | ||
My daughter was driving her 2004 audi a4 at about 40 miles per hour when the the car jerked, she then pulled up to the stop light and stoped. the car stalled and would not start. the engine warning light was on. we pushed the car out of the lane of traffic. a few hours later we went back to the car and it started up with no problem, we drove the car with no problems. this is a very dangerous situation and it appears that other owners have had this problem. there was an investigation pe08027 opened on this issue in 2008 and closed in 2008 without a recall. | |||
07/08/2010 | 99000 | ||
2004 audi a4 1.8t engine sludge--complete engine failure. audi absurdly refuses to honor their own extended warranty on the basis the car was run without oil. the engine failed internally because there was and is sludge blocking lubrication ports to the moving parts, i.e., failure. this is my executive synopsis, but i have volumes of supporting evidence, unbelievable as it is to think this could happen in america. | |||
11/22/2004 | 1 | ||
When the consumer came to a stop at an intersection, the vehicle stalled. *jb | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
01/02/2010 | 98000 | 1 | |
I have owned my 2004 audi a4 1.8t quattro for four years. the problem that i am having is a massive issue that hundreds if not thousands of other b6 platform owners also have, the water pump in our vehicles is very prone to failure. the water pump found in our us market vehicles has a plastic impeller that is known to snap, crack, or leak causing the part to fail. i have had two of these pumps fail in the past two years. the first one failed at around 74k in july of 2008 when the part was nearing it's replacement date. the second failure occurred in january 2010 at roughly 98k miles. so i have had two failures in a very short time period. now audi is fully aware of this but has never had a recall or even acknowledges that it is their fault for releasing a poorly designed part. when a pump fails it usually goes very quickly. in my case it leaked and then i lost ac compression. i am lucky that i know cars and knew to immediately park the car and get it into the shop. i know that many other people have had significant engine damage because the failed pump caused overheating. the pump is also part of the whole system that drives the timing belt so a failure could also cause catastrophic engine failure if that belt seizes up. overall it is a huge problem and each time a pump needs to be replaced the entire timing belt service needs to be performed which runs about $1700.00 at a dealership and around $800-$1500 at independent shops. i feel that this is very unfair to us as owners, but that it also puts the public at great risk if a failure occurs at highway speeds or in traffic. lives are already at risk enough on our highways and the last thing that i want to do is cause bodily harm or property damage because a company released a poorly designed part and did nothing to improve it. i request that the nhtsa look into this issue. if you search sites like audiworld.com and audizine.com you will find lots of information and first hand accounts. *tr | |||
08/07/2003 | 8 | 3 | 08/07/2003 |
Vehicle heated up under the steering column, especially when driving 50 mph or greater. consumer took vehicle to the dealer, and they test drove the vehicle for eight days and found the same flaw as the consumer. manufacturer indicated that the vehicle was operating under normal range, and there was nothing they could do. *ak *nm | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
07/08/2010 | 99000 | ||
2004 audi a4 1.8t engine sludge--complete engine failure. audi absurdly refuses to honor their own extended warranty on the basis the car was run without oil. the engine failed internally because there was and is sludge blocking lubrication ports to the moving parts, i.e., failure. this is my executive synopsis, but i have volumes of supporting evidence, unbelievable as it is to think this could happen in america. | |||
01/02/2010 | 98000 | 1 | |
I have owned my 2004 audi a4 1.8t quattro for four years. the problem that i am having is a massive issue that hundreds if not thousands of other b6 platform owners also have, the water pump in our vehicles is very prone to failure. the water pump found in our us market vehicles has a plastic impeller that is known to snap, crack, or leak causing the part to fail. i have had two of these pumps fail in the past two years. the first one failed at around 74k in july of 2008 when the part was nearing it's replacement date. the second failure occurred in january 2010 at roughly 98k miles. so i have had two failures in a very short time period. now audi is fully aware of this but has never had a recall or even acknowledges that it is their fault for releasing a poorly designed part. when a pump fails it usually goes very quickly. in my case it leaked and then i lost ac compression. i am lucky that i know cars and knew to immediately park the car and get it into the shop. i know that many other people have had significant engine damage because the failed pump caused overheating. the pump is also part of the whole system that drives the timing belt so a failure could also cause catastrophic engine failure if that belt seizes up. overall it is a huge problem and each time a pump needs to be replaced the entire timing belt service needs to be performed which runs about $1700.00 at a dealership and around $800-$1500 at independent shops. i feel that this is very unfair to us as owners, but that it also puts the public at great risk if a failure occurs at highway speeds or in traffic. lives are already at risk enough on our highways and the last thing that i want to do is cause bodily harm or property damage because a company released a poorly designed part and did nothing to improve it. i request that the nhtsa look into this issue. if you search sites like audiworld.com and audizine.com you will find lots of information and first hand accounts. *tr | |||
02/26/2010 | 38365 | 1 | |
2004 audi a4 w. approx 38,000 miles. failures involve plug & leaking water pump which ruined timing belt. total charge for repair: approx $1700. *tr | |||
10/21/2009 | 54800 | 1 | |
I have a 2004 audi a4 1.8t. this exact model is what is described in the audi manufacturer's 8 year extended warranty for engines. i am currently being denied warranty coverage for the engine sludge that has built up in the engine. the reason being according to university audi in seattle, is that: my car is too new. but it is a 2004, the cut off year for the extended warranty. *tr | |||
08/07/2009 | 66000 | 1 | |
Ignition coil failed in one cylinder on 2004 audi a4 1.8t quattro. this part on audis repeatedly fails. loss of power, very shaky at idle and acceleration. $400 to repair, but now catalytic converter is ruined due to the cylinder misfiring. *tr | |||
04/22/2008 | 34125 | 1 | |
Engine has an repeated but intermittent loss of power. usually occurs shortly after starting the car and before the temperature gage shows the engine running at normal temp. engine continues to run, but when pressing gas pedal all the way to the floor, there is insufficient power to move the car. also, when in neutral or park, rpm barely goes above 1500 when pedal fully depressed. after waiting a few seconds for sometimes as long as a minute, engine will regain power and will then operate normally. this has happened at least 10 times from oct07 (when purchased car used) through 22 april. manufacturer technician is unable to locate problem. *tr | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
03/15/2004 | 100 | 30 | 03/15/2004 |
Car is 2004 audi a4 with 1.8 engine and cvt transmission. car's engine will upon acceleration from standstill, often hesitate and stumble. at times when making a left hand turn across traffic from standstill, it will at times not only hesitate, but actually stall or have a no power situation for a couple of seconds. this has led to several near accidents. i have reported to our audi dealers service department a number of time. each time, they merely say that they cannot find the problem and return auto to us. a couple of times they have said that they have downloaded software fixes to the automobiles ecm(computer). *tr (excerpt from e-mail 4-1-08) i was then told by one service rep that he had seen this problem on those audi's that are equipped with the so called cvt transmission before but that audi has been unable to address. he said that he applied a software fix to the auto's electronic management computer, but this did not help. *smch | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
05/29/2009 | 49500 | ||
Tl*the contact owns a 2004 audi a4. the contact stated that the timing belt failed and destroyed the engine. the engine will not start and the vehicle cannot be driven. the manufacturer has not been notified. the vin was unknown. the failure mileage was 49,500. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
07/15/2010 | 80000 | ||
One day the low oil light came on, brought it to carousol audi in golden valley mn and they informed me about the oil sludge problem and told me to get my oil recipts ready. i changed my own oil and don't have my oil recipts and am now being denied a warranty coverage. was told that i would have a new engine put in if i had oil recipts but will cost at least 9000 without the warranty | |||
08/07/2009 | 66000 | 1 | |
Ignition coil failed in one cylinder on 2004 audi a4 1.8t quattro. this part on audis repeatedly fails. loss of power, very shaky at idle and acceleration. $400 to repair, but now catalytic converter is ruined due to the cylinder misfiring. *tr |