Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | |||||
020604010A | 07/01/2003 | 020604010 | 10002938 | Erratic fuel gauge reading. *tt | 10/01/2003 |
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||||
PIC-5347A | 10/01/2010 | 10037131 | Ready | 05/09/2011 | |
PIC-5347A | 10/01/2010 | 10037131 | Gm: the fuel gauge may show empty when there is still gas in the tank. vehicles may also run out of gas with the fuel gauge at half-full. *rm | 05/09/2011 | |
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
01369 | 11/18/2003 | 10004153 | Creak, popping noise from rear of vehicle near the fuel tank area. *tt | 11/20/2003 | |
990604052 | 10/01/1999 | 6089210 | Subject regarding left fuel tank to underbody contact / rattle noise. *tt | 01/14/2000 | |
FUEL SYSTEM, OTHER | |||||
4159 | 4159A | 10020421 | Revised fuel sender values for the chevrolet corvette and cadillac xlr. *kb | 09/28/2006 | |
00110A | 01/01/2004 | 10005405 | Fuel gauge/pump diagnostic tests. sit bulletin 1411305. *tt | 02/25/2004 | |
010604022 | 03/01/2001 | 619392 | Some owners may comment about inaccurate / erratic fuel level gage reading conditions such as the fuel gage suddenly drops to e (empty) and check gages message illuminates; fuel gage does not go to f (full) after filling fuel tank and / or | 05/29/2001 | |
FUEL SYSTEM, OTHER - DELIVERY - FUEL PUMP | |||||
PIC-5347A | 10/01/2010 | 10037131 | Gm: the fuel gauge may show empty when there is still gas in the tank. vehicles may also run out of gas with the fuel gauge at half-full. *rm | 05/09/2011 | |
PIC-5347A | 10/01/2010 | 10037131 | Ready | 05/09/2011 | |
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
PIC-5347A | 10/01/2010 | 10037131 | Ready | 05/09/2011 | |
PIC-5347A | 10/01/2010 | 10037131 | Gm: the fuel gauge may show empty when there is still gas in the tank. vehicles may also run out of gas with the fuel gauge at half-full. *rm | 05/09/2011 | |
3725 | 3725A | 10017694 | Erratic fuel gauge operation and diagnostic trouble code p1431. models unknown. gmc. *tt | 11/18/2005 | |
3551 | 10017276 | Service vme - fuel gauge erratic or defaults to empty. *tt | 10/31/2005 | ||
01489 | 01/01/2004 | 10005504 | Erratic fuel gauge operation and diagnostic trouble code (dtc) p1431. sit bulletin 1401034. *tt | 03/01/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
06/28/2008 | 62000 | 1 | |
In light of all the gas pedal problems we have seen lately, i would like to share one which i encountered two years ago on my 1999 corvette. being a professional engineer, i was able to pin-point the problem to the brake pedal much better than my dealer. my local chevy dealer wanted me to replace the car's battery, since that was the first code he saw when he scanned the computer. naturally, the car didn't need a battery so i drove away from the dealer. the symptom was at any time the car would pop-on the engine trouble light and immediately slow down. the car could only be driven up to 20 mph. this happened about six times without incident. i could reset my computer, but the issue soon returned. i replaced the electronic gas pedal assembly and the problem was fixed. *tr | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
1 | 06/01/1999 | ||
(1) windshield mounted rear-view mirror shakes/vibrates badly at idle and on highway, especially with convertible top down, making following vehicles appear blurry. dealer replaced mirror once, second dealer retightened to windshield, but problem remains. (2) drive belts make growling sound at idle, a/c on, when shifting between park & reverse, or between reverse & drive. belt & tensioner replaced per existing service advisory, but problem still occurs. (3) rear mounted cd changer does not function if vehicle is started soon after inserting cd cartridge; err displayed on radio. once err is displayed, must remove and reinsert cd cartridge to make work again (restarting vehicle or turning radio off/on doesn't help). voltage at cd changer drops down to about 10v when starting vehicle. dealers clueless. (4) electric fuel pump behind driver seat makes annoying buzzing sound when vehicle stopped, at idle, esp. noticeable with windows up. dealer says noise is normal and existing service advisories only apply to '97 & '98 vehicles. | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
03/29/2003 | 18400 | 1 | 05/20/2002 |
Fuel system, gasoline delivery, computer shuts gas level to empty and the vehicle shuts down while driving. *jb | |||
03/26/2000 | 1 | 12/01/1998 | |
Fuel pump failed without warning. car lost all power instantly. car would start but would not run for more than 30 seconds. throttle had no effect. if the pump ahd failed in traffic, during an evasive maneuver or while attempting to cross a busy road, the car would have been without power and unable to avoid any other oncoming vehicles. other late model corvette owners have reported fuel pump problems on the internet; this is not an isolated incident. this failure has the potential to cause a major accident if not corrected. *ak | |||
5 | |||
Fuel pump failed causing the vehicle to stall. | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
08/28/1999 | |||
The vehicle was started up then turned off. there was a whisteling sound, and white smoke was noticed coming from the right rear wheel, the vehicle was then back up and flames where noticed. the fire department put the fire out, and determined the cause was the fuel filter. chevrolet has been contacted. *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
3 | |||
Possible fuel injection failure caused vehicle to shudder and die. | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
09/25/2000 | 0 | ||
While filling fuel tank fuel was leaking. while driving a security light will pop on sometimes. when pulling out seat belt it will retract and lock without releasing. *ak | |||
FUEL SYSTEM, OTHER | |||
10/12/1999 | 1 | 06/01/1999 | |
(1) intermittent passive keyless entry/alarm system malfunctions in passive mode: doors lock and alarm sets in 5 seconds if key removed from ignition and doors still closed; if unlock button pressed and enter vehicle, doors lock and alarm sets. (2) fuel gauge inaccurate: when tank is completely full, intermittently reads 2/3 full after starting vehicle. after driving for 2 minutes or so, fuel gauge jumps to the full mark. (3) steering column locked while car in gear but not moving (after backing out of garage, while at dealer for other repairs). ref. in ea02-031 *cjs | |||
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
05/28/2004 | 42975 | 2 | 06/22/1999 |
I am in the process of having my forth steering column replaced on my 1999 corvette, manual transmission. but the problem that i am reporting is that there were two times that this car ran out of gas with over 100 miles still showing on the distance to empty display.the last time i was having the steering column replaced i found a service bulletin , tsb # 02-06-04-010a pertaining to erratic fuel level readings and had the dealer correct the problem. both times running out of fuel were at night time and the last time i was stranded on the top of a bridge with my daughter. we were almost hit 4 times by cars driving by because there was no place to safely pull over. i feel this should be a recall item because it leads you to a false sense of security in having fuel and when the car stops running, you loose the ability to steer the car safely.*ak | |||
07/21/2004 | 55000 | 3 | 11/12/1998 |
The fuel gauge on my 1999 chevrolet corvette has never worked properly and now the vehicle stops despite having several gallons of fuel in the tank. i have been stranded several times. most recently in a very dangerous traffic situation. i believe this is now a true safety concern. there also appears to be several service bulletins out on this problems so it does not appear to be isolated.*ak |