Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||||||||||||
09V116000 | GENERAL MOTORS CORP. | V (Vehicle) | 1497516 | 04/09/2009 | ODI | GENERAL MOTORS CORP. | 04/08/2009 | 04/08/2009 | ||||||||
Defect Summary | General motors is recalling 1,497,516 my 1997-2003 buick regal, my 1998-2003 chevrolet lumina, monte carlo and impala, my 1998-1999 oldsmobile intrigue, my 1997-2003 pontiac grand prix vehicles equipped with a 3.8l v6 naturally aspirated engine. some of these vehicles have a condition in which drops of engine oil may be deposited on the exhaust manifold through hard braking. | |||||||||||||||
Consequence Summary | If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and may spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire. | |||||||||||||||
Corrective Summary | Dealers will remove the spark plug wire retention channel at the front of engine and install two new spark plug wire retainers free of charge. the recall is expected to begin during may 2009. owners may contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, and pontiac at 1-800-620-7668 or http://www.pontiac.com or http:www.gmownercenter.com. | |||||||||||||||
Notes | Gm recall no. 09047.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
010601007A | 07/01/2001 | 010601007 | 620835 | Experiencing excessive engine coolant consumption, or an engine coolant leak near or under the throttle body area of the upper intake manifold. *tt | 08/31/2001 |
010601007 | 09/01/2007 | 010601007C | 619176 | Engine coolant consumption or coolant leak (inspect for material degradation/replace intake manifolds) *tt updated 11/02/07 *nj | 05/17/2001 |
ENGINE AND ENGINE COOLING - ENGINE | |||||
040601021 | 06/01/2004 | 10012148 | New rear main seal and special tool for installation. *tt | 02/15/2005 | |
010601002A | 12/01/2002 | 010601002 | 10000782 | Revised piston pin removal / installation procedure. *tt | 03/31/2003 |
010601008A | 05/01/2002 | 010601008 | 634813 | Some owners may comment on a repeat engine oil pan leak. *tt | 10/09/2002 |
010601008 | 02/01/2001 | 619177 | Some owners may comment on a repeat engine oil pan leak. *tt | 05/17/2001 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
020601014 | 04/01/2002 | 634708 | Subject regarding revised lower intake manifold installation. *tt | 10/07/2002 | |
010601010A | 06/01/2001 | 0106010101 | 620810 | Subject regarding polymer service pistons. *tt | 08/30/2001 |
990604005A | 04/01/2001 | 990604005 | 619360 | Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 05/24/2001 |
876002A | 07/01/1998 | 876002 | 615073 | Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re | 12/26/2000 |
990604005 | 02/01/1999 | 776304A | 604343 | Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt | 04/26/1999 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
3115 | 01/01/2004 | 10009950 | Engine intake manifold coolant leak. *sc | 11/02/2004 | |
040601017 | 06/01/2004 | 10008471 | New upper intake manifold and gasket kits. *tt | 08/02/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
02/01/2013 | 1 | ||
1998 chevrolet monte carlo. consumer writes in regards to engine compartment fire recall notice and seeks reimbursement. *smd the consumer stated the vehicle caught fire, prior to receiving the recall notice. the vehicle was taken to a junk yard. | |||
05/31/2010 | 98000 | ||
Tl- the contact owns a 1998 chevrolet monte carlo. the contact stated that he received a recall notice for nhtsa campaign id number: 09v116000. he has not taken the vehicle in for the remedy yet but stated the bigger issue other than the spark plug wires is the oil leaking onto the engine which could start a fire, which is not being addressed in the current recall. the owner feels this is a safety issue. the current and failure mileage is approximately 98,000. rd | |||
28000 | 5 | ||
The vehicle has an internal coolant leak within the engine compartment. the leak occurred because the intake manifold gasket was made with a thin material which disintegrated and created an orange slug in the engine, per the dealership. *jb | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
1 | 03/24/1998 | ||
Problems with heavy engine knocking, crankshaft sensor, oil consumption, oil pan gasket...etc. *mr | |||
1 | 07/01/1999 | ||
Vehicle sporadically hesitates on acceleration. does not matter if engine is cold or warm. symptoms also happen at speed and it feels like the engine is not receiving enough gasoline to operate at speed. engine has shut off by itself at idle in gear two times. computer has not set any codes. plugs and wires replaced. no help with the problem. engine will usually turn to normal within 15 to 20 seconds of episode. during episode pressure on gas pedal does not result in acceleration. mechanic reluctant to replace components (i.e tps, egr, etc.) since no codes have appeared and confidence low as to which componet (if any) is causing the problem. problem particularly bothersome when pulling into traffic as vehicle will not always accelerate to speed as anticipated. *jb *****dimsii ivoq entry poster after 12/12/02 cut-over to artemis****764525 | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
10/10/2002 | 3 | 07/09/1998 | |
Consumer states that while driving and no warning when pressing on the gas pedal it will boggle down causing it to be hard for the consumer to control the vehicle. dealer notified. mr consumer stated that pcm, oxygen sensor and wires around the knock sensor replaced as a cause, but the problem still exist. *yh | |||
07/01/2000 | |||
No summary listed for above vehicle. *ak | |||
03/01/2000 | 6 | 12/01/1997 | |
The car would either stall or hesitate if driven, then let cool off for a while and the went to drive again. dealer was informed but not able to fix. *ak | |||
When oil was changed noticed lots of fluids leaking. dealer stated rack and pinion needed to be replaced. please provide further information. *ak | |||
4 | 08/01/1998 | ||
On 4 different occasions vehicle stalled out and died without warning. dealer has inspected vehicle several times, and has not been able to duplicate the problem. *ak | |||
01/01/1998 | |||
While driving at 85mph the engine shut off. the owner notified the dealer, and was informed that there is an engine limit. when the vehicle reaches certain mph, power is cut off from the engine. owner states that the dealer did not tell the owner about this . *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
10/10/2002 | 3 | 07/09/1998 | |
Consumer states that while driving and no warning when pressing on the gas pedal it will boggle down causing it to be hard for the consumer to control the vehicle. dealer notified. mr consumer stated that pcm, oxygen sensor and wires around the knock sensor replaced as a cause, but the problem still exist. *yh | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
05/14/2003 | 46000 | 1 | |
The vehicle leaked coolant due to the faulty manifold gasket. *nlm |