Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | |||||
190101 | 01/19/2001 | 618181 | Information regarding normal diagnostic if the opr valve is causing the leak air to be heard exiting the rubber dump hose, which is located on the left side of the fuel tank. *tt | 04/06/2001 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
FUEL SYSTEM, GASOLINE - DELIVERY | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
Ea02-030 is closed with gmea02-030 is closed with gm |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
09/01/2004 | 29214 | ||
Second submit - 1st submit no response 10427931 6/2003 - fuel pump replaced. 9/2004 cool pressure test found inter gasket leaking - replaced upper & lower internal gaskets; low cool sensor replaced. 12/2004 - missing on incline and with cruise - nothing found. 11/2005 - missing on accel, using lots of gas - wanted to replace plugs, etc. 2/2006 - missing on incline and cruise - nothing found. 6/2008 - numerous issues - bcm replaced. 7/2008 - after bcm replaced, dash lights , cruise indicator, heat and a/c did not function properly - dealer stated there would be cost to fix items even though they worked prior to replacement of bcm. 9/29/2011 - learned about special policy adjustment-catalytic converter #05551(9/14/2005) although i was never advised by dealer and did not receive notification. called dealer to ask if they would check under special policy - dealer said they could not because, although mileage is within special policy guidelines, the time expired 4/2011. i have copies of all service done on this vehicle. can this special policy be honored since i was not notified of the policy by gm or the dealer? the car has always had a problem with missing and using lots of gasoline. thank you for advocating for me. | |||
09/01/2004 | 29214 | ||
6/2003 - fuel pump replaced. 9/2004 cool pressure test found inter gasket leaking - replaced upper & lower internal gaskets; low cool sensor replaced. 12/2004 - missing on incline and with cruise - nothing found. 11/2005 - missing on accel, using lots of gas - wanted to replace plugs, etc. 2/2006 - missing on incline and cruise - nothing found. 6/2008 - numerous issues - bcm replaced. 7/2008 - after bcm replaced, dash lights , cruise indicator, heat and a/c did not function properly - dealer stated there would be cost to fix items even though they worked prior to replacement of bcm. 9/29/2011 - learned about special policy adjustment-catalytic converter #05551(9/14/2005) although i was never advised by dealer and did not receive notification. called dealer to ask if they would check under special policy - dealer said they could not because, although mileage is within special policy guidelines, the time expired 4/2011. i have copies of all service done on this vehicle. can this special policy be honored since i was not notified of the policy by gm or the dealer? the car has always had a problem with missing and using lots of gasoline. thank you for advocating for me. | |||
09/30/2010 | 119452 | ||
Intake manifold explosion resulting in 2nd degree burns. | |||
01/19/2008 | 1 | ||
I was trying to start the car again,and the engine exploded in my face while i was standing over it. *tr | |||
01/19/2008 | 100000 | 1 | |
Car would not start again, raised hood and proceeded to attach jump cables, and at the moment just before attachment, my daughter turns the key and wow, what an explosion! i was injured very bad the whole center of the motor was all over my driveway and i was thrown away from the car. over 25,000 in medical bills and months of disability and still seeking medical attention to this day. *tr | |||
05/12/2005 | 1 | ||
Dt: 2001 chevrolet monte carlo. the contact stated the vehicle would not start. the contact tried to start it three or four times when it exploded. this occurred in the engine compartment. the vehicle had to be towed to the dealership, who stated that the fuel system was putting too much power to the engine, and that caused the explosion. this happened in may 2005. the vehicle was towed to dealership about the beginning of october 2005. the vehicle was sluggish when started. when driving on the freeway the contact would have to pull over because it was not getting enough power to the vehicle. the debris from the explosion hit the top of the hood. the contact does still have parts from the vehicle. chevrolet stated that because the vehicle was not under warranty or recall they could not assist the contact. *ak | |||
FUEL SYSTEM, OTHER | |||
02/12/2009 | 1 | ||
My fuel gauge in my 2001 chevrolet monte carlo does not work correctly. erratic at best. *tr |