Chevrolet Sierra 2002
Model Sierra made in 2002 by Chevrolet got 1 consumer complain there are 23 investigations as well as 21 service bulletins. Consumer complaints with reference to exterior lighting. . Technical service bulletines regarding engine and engine cooling, equipment and exterior lighting. The car had some investigations: latches/locks/linkages, parking brake and service brakes, hydraulic.
Model 2002
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 3232 | 10011692 | Misfire at idle cold and possible p0171 and or p0174. *eh | 01/28/2005 | ||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 3121A | 01/01/2004 | 10009936 | Exhaust vibration resonance or moan 99-05 full size trucks and utility vehicles with gen 3 v-8 engines. *tc | 11/02/2004 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 020604059 | 12/01/2002 | 10000725 | Engine runs rough, service engine soon light on, diagnostic trouble codes p0300 or p0335 set. *tt | 03/27/2003 | |
| EQUIPMENT | |||||
| 190901 | 09/19/2001 | 626230 | Customers may complain on certain models including 2002 gmc/chev truck c3 and 2001 chevrolet truck c3 the secondary information center screen going blank and the on/off button not restoring the display. *slc | 12/13/2001 | |
| EXTERIOR LIGHTING - HEADLIGHTS | |||||
| 3170E | 10019186 | Ipc, interior lights and/or headlamps flicker. *ak fb2 | 02/16/2006 | ||
| INTERIOR LIGHTING | |||||
| 3170E | 10019186 | Ipc, interior lights and/or headlamps flicker. *ak fb2 | 02/16/2006 | ||
| LATCHES/LOCKS/LINKAGES - DOORS - LATCH | |||||
| 010864014 | 10/01/2001 | 628508 | Subject regarding door manual lock lever disengages from door trim panel (repair lock lever) *jg | 03/12/2002 | |
| POWER TRAIN | |||||
| 052103 | 05/21/2003 | 10003656 | Essential tools for servicing the allison transmission. these tools include a four-wheel drive spanner nut wrench, rear bearing puller legs, digital depth micrometer and a rear bearing installer. these tools are required to replace a cr | 10/27/2003 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 200801 | 08/20/2001 | 625114 | Information regarding revised transmission calibration to address driveline growl or prop shaft ring noise. *jg | 11/16/2001 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 3364 | 10014953 | Rear axle retainer button breakage. *eh | 05/12/2005 | ||
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING | |||||
| 100901 | 09/10/2001 | 626161 | Vehicles may experience the brake system warning light not illuminating. *slc | 12/13/2001 | |
| STEERING | |||||
| 030236002 | 08/01/2003 | 10012577 | Revised steering wheel position sensor or steering shaft lower bearing replacement procedure and steering wheel position sensor centering procedure. *eh | 03/07/2005 | |
| 000235003 | 02/01/2007 | 000235003M | 10012089 | Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb | 02/11/2005 |
| STRUCTURE - BODY | |||||
| 180901 | 09/18/2001 | 626202 | Customers may complain that their center console lock is not operational. *slc | 12/13/2001 | |
| STRUCTURE - BODY - DOOR | |||||
| 010864015 | 10/01/2001 | 627471 | Information regarding front and rear side access door noise. *yh | 02/07/2002 | |
| 010864014 | 10/01/2001 | 627425 | Subject on door manual lock lever disengages from door trim panel. *yh | 02/07/2002 | |
| 160801 | 08/16/2001 | 625323 | Subject regarding new door check link. *jg | 11/19/2001 | |
| STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | |||||
| 010864015 | 10/01/2001 | 628505 | Subject regarding front and rear side door access door noise (replace door check link). *jg | 03/12/2002 | |
| SUSPENSION | |||||
| 270901 | 09/27/2001 | 626427 | Some vehicles equipped with 4-wheel drive extended cab and short bed may experience a bump or clunk on stop or acceleration. *slc | 12/14/2001 | |
| SUSPENSION - REAR | |||||
| 3188 | 3188A | 10010615 | Squeak noise from rear leaf springs. *eh | 12/02/2004 | |
| UNKNOWN OR OTHER | |||||
| 130801 | 08/13/2001 | 625271 | Information regarding customer enhancements. *jg | 11/19/2001 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| LATCHES/LOCKS/LINKAGES - TAILGATE - LATCH | ||||||
| EA04005 | GENERAL MOTORS CORP. | 02/19/2004 | 09/28/2004 | TAILGATE CABLE BREAKAGE | 04V129000 | |
| General motors filed a defect notice 04v-129 on march 17, 2004, which outlines a program to replace the tailgate cables installed in affected model year 2000-2004 vehicles.refer to odi's closing report for ea04-005 for additional information.odi is aware of reports of tailgate cable breakage occurring in model year 1999 and earlier vehicles.these vehicles were equipped with similar tailgate cables as addressed by 04v-129, but are not being addressed by campaign o4v-129.odi is initiating a separate investigation to address these vehicles.the complaint-injury-fatality statistics summarized above pertain to model year 2000-2004 vehicles. the complaint-injury statistics for model year 1999 and earlier vehicles are summarized on the opening resume for that investigation. | ||||||
| EA04005 | GENERAL MOTORS CORP. | 02/19/2004 | 09/28/2004 | TAILGATE CABLE BREAKAGE | 04E067000 | |
| General motors filed a defect notice 04v-129 on march 17, 2004, which outlines a program to replace the tailgate cables installed in affected model year 2000-2004 vehicles.refer to odi's closing report for ea04-005 for additional information.odi is aware of reports of tailgate cable breakage occurring in model year 1999 and earlier vehicles.these vehicles were equipped with similar tailgate cables as addressed by 04v-129, but are not being addressed by campaign o4v-129.odi is initiating a separate investigation to address these vehicles.the complaint-injury-fatality statistics summarized above pertain to model year 2000-2004 vehicles. the complaint-injury statistics for model year 1999 and earlier vehicles are summarized on the opening resume for that investigation. | ||||||
| PARKING BRAKE | ||||||
| PE03057 | GENERAL MOTORS CORP. | 12/08/2003 | 04/09/2004 | PARKING BRAKE FAILURE | ||
| Odi opened pe03-057 to assess parking brake ineffectiveness in the subject vehicles.these vehicles are equipped with four wheel disc brakes that incorporate a single-shoe drum-in-hat parking brake independent of the service brakes.complaint and warranty data indicate that the parking brake linings tend to wear out early in the life of the vehicle (at an average of 24 months in service), reducing the parking brake system's torque below that needed to immobilize the vehicle.gm has attributed this accelerated wear to foreign material intrusion and a failure of the brake shoe to properly self-center within its brake drum.effective with the start of my 2003 production, a newer reduced force hold-down clip was introduced to facilitate brake shoe disengagement from the drum surface.this part is also available at the service level for the my 1999-2002 vehicles.gm has indicated that the paking brake is intended to operate in conjunction with the transmission to immobilze parked vehicles, and that in many cases, accelerated parking brake lining wear is caused by rough use, vehicle modifications, and driving with the parking engaged. odi has upgraded the preliminary evaluation to an engineering analysis to gather further information concerning parking brake usage factors and the circumstances surrounding the seventeen reported vehicle crashes. | ||||||
| DP05009 | GENERAL MOTORS CORP. | 12/20/2005 | 05/31/2006 | PARKING BRAKE FAILURE | ||
| Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant. | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| DP05009 | GENERAL MOTORS CORP. | 12/20/2005 | 05/31/2006 | PARKING BRAKE FAILURE | ||
| Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| DP05009 | GENERAL MOTORS CORP. | 12/20/2005 | 05/31/2006 | PARKING BRAKE FAILURE | ||
| Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL - LINKAGE AND CABLE | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| SERVICE BRAKES, HYDRAULIC | ||||||
| EA11001 | GENERAL MOTORS CORP. | 01/05/2011 | Brake line corrosion failure | |||
| The office of defects investigation (odi) received defect petition dp10-003 on march 2, 2010, requesting the investigation of model year (my) 2003 chevrolet silverado 2500hd 4wd pickup trucks for corrosion failures of the vehicle brake lines.dp10-003 was granted and on march 30, 2010, preliminary evaluation pe10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by general motors corporation (gm).on july 2, 2010, odi received gm's response to an information request, which included gm's assessment of the frequency and safety consequences of the alleged defect. gm stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of federal motor vehicle safety standards 105 and 135, light vehicle brake systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (mil) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure. of the890 total complaints for brake pipe corrosion identified, 761 were located in salt belt states (connecticut, delaware, district of columbia, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia and wisconsin).the complaint rate per 100,000 vehicles sold is significantly higher in the salt belt, 43.0, compared with 3.0 for the remaining states.in approximately 25 percent of the complaints, the brake pipe failure has allegedly occurred suddenly, with no warning to the driver (i.e., no brake warning light), and resulted in extended stopping distances.in 26 of these incidents, the increase in stopping distance that resulted was alleged as a factor in a crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.an engineering analysis has been opened for subject vehicles sold or currently registered in salt belt states to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. odi will continue to gather information on subject vehicles outside the salt belt as well. | ||||||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | ||||||
| PE05020 | GENERAL MOTORS CORP. | 04/28/2005 | 09/13/2005 | UNWANTED LOW-SPEED ABS ACTIVATION | 05V379000 | |
| In a letter dated august 29, 2005, gm notified odi that it was recalling certain model year 1999 through 2002 c/k pickup trucks and sport utility vehicles to correct a problem with anti-lock brake system (abs) wheel speed sensor corrosion that may result in unwanted abs activation and extended stopping distances during low-speed braking (recall 05v-379).gm's recall covers approximately 804,000 vehicles currently registered in the following 14 salt-belt states:connecticut, illinois, indiana, massachusetts, maine, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, and west virginia.the recall procedure will involve removing the sensor, cleaning the mounting surface, applying a rust inhibitor (zinc-x) to the surface, and reinstalling the sensor.if necessary, the sensor will be replaced. the population and failure report data given in this resume are for the full region that has been considered by odi as the salt-belt.that includes delaware, iowa, maryland, minnesota, missouri, wisconsin and the district of columbia in addition to the 14 states included in 05v-379.the states covered by gm's recall have the highest incident rates for the subject condition, accounting for 91% of the incidents, but only 24% of subject vehicle sales in the united states.odi's analysis determined that 840 of the complaints, 244 of the crashes, and 16 of the injuries identified in this investigation occurred in those states.the resulting incident and crash rates are 96.2 and 28.0 per 100,000 vehicles respectively (note:rates are based on vehicle sales, not registered vehicles). the corresponding numbers in the excluded portions of the salt-belt are 399,000 vehicles, 81 incidents (20.3 per 100,000 vehicles), 3 crashes, and no injuries.the statistics in the remaining 30 states are 2,406,000 vehicles, 168 incidents (7.0 per 100,000 vehicles), 31 crashes, and one injury.gm and odi are continuing to monitor the problem experience in states that are not included in the recall.gm will provide odi with updated complaint, field report, and warranty data in november 2005.odi and gm will review that data and assess the appropriateness of the current scope of the recall at that time. | ||||||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE | ||||||
| PE05020 | GENERAL MOTORS CORP. | 04/28/2005 | 09/13/2005 | UNWANTED LOW-SPEED ABS ACTIVATION | 05V379000 | |
| In a letter dated august 29, 2005, gm notified odi that it was recalling certain model year 1999 through 2002 c/k pickup trucks and sport utility vehicles to correct a problem with anti-lock brake system (abs) wheel speed sensor corrosion that may result in unwanted abs activation and extended stopping distances during low-speed braking (recall 05v-379).gm's recall covers approximately 804,000 vehicles currently registered in the following 14 salt-belt states:connecticut, illinois, indiana, massachusetts, maine, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, and west virginia.the recall procedure will involve removing the sensor, cleaning the mounting surface, applying a rust inhibitor (zinc-x) to the surface, and reinstalling the sensor.if necessary, the sensor will be replaced. the population and failure report data given in this resume are for the full region that has been considered by odi as the salt-belt.that includes delaware, iowa, maryland, minnesota, missouri, wisconsin and the district of columbia in addition to the 14 states included in 05v-379.the states covered by gm's recall have the highest incident rates for the subject condition, accounting for 91% of the incidents, but only 24% of subject vehicle sales in the united states.odi's analysis determined that 840 of the complaints, 244 of the crashes, and 16 of the injuries identified in this investigation occurred in those states.the resulting incident and crash rates are 96.2 and 28.0 per 100,000 vehicles respectively (note:rates are based on vehicle sales, not registered vehicles). the corresponding numbers in the excluded portions of the salt-belt are 399,000 vehicles, 81 incidents (20.3 per 100,000 vehicles), 3 crashes, and no injuries.the statistics in the remaining 30 states are 2,406,000 vehicles, 168 incidents (7.0 per 100,000 vehicles), 31 crashes, and one injury.gm and odi are continuing to monitor the problem experience in states that are not included in the recall.gm will provide odi with updated complaint, field report, and warranty data in november 2005.odi and gm will review that data and assess the appropriateness of the current scope of the recall at that time. | ||||||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | ||||||
| EA11001 | GENERAL MOTORS CORP. | 01/05/2011 | Brake line corrosion failure | |||
| The office of defects investigation (odi) received defect petition dp10-003 on march 2, 2010, requesting the investigation of model year (my) 2003 chevrolet silverado 2500hd 4wd pickup trucks for corrosion failures of the vehicle brake lines.dp10-003 was granted and on march 30, 2010, preliminary evaluation pe10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by general motors corporation (gm).on july 2, 2010, odi received gm's response to an information request, which included gm's assessment of the frequency and safety consequences of the alleged defect. gm stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of federal motor vehicle safety standards 105 and 135, light vehicle brake systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (mil) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure. of the890 total complaints for brake pipe corrosion identified, 761 were located in salt belt states (connecticut, delaware, district of columbia, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia and wisconsin).the complaint rate per 100,000 vehicles sold is significantly higher in the salt belt, 43.0, compared with 3.0 for the remaining states.in approximately 25 percent of the complaints, the brake pipe failure has allegedly occurred suddenly, with no warning to the driver (i.e., no brake warning light), and resulted in extended stopping distances.in 26 of these incidents, the increase in stopping distance that resulted was alleged as a factor in a crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.an engineering analysis has been opened for subject vehicles sold or currently registered in salt belt states to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. odi will continue to gather information on subject vehicles outside the salt belt as well. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
| STRUCTURE - BODY - TAILGATE | ||||||
| EA04005 | GENERAL MOTORS CORP. | 02/19/2004 | 09/28/2004 | TAILGATE CABLE BREAKAGE | 04E067000 | |
| General motors filed a defect notice 04v-129 on march 17, 2004, which outlines a program to replace the tailgate cables installed in affected model year 2000-2004 vehicles.refer to odi's closing report for ea04-005 for additional information.odi is aware of reports of tailgate cable breakage occurring in model year 1999 and earlier vehicles.these vehicles were equipped with similar tailgate cables as addressed by 04v-129, but are not being addressed by campaign o4v-129.odi is initiating a separate investigation to address these vehicles.the complaint-injury-fatality statistics summarized above pertain to model year 2000-2004 vehicles. the complaint-injury statistics for model year 1999 and earlier vehicles are summarized on the opening resume for that investigation. | ||||||
| EA04005 | GENERAL MOTORS CORP. | 02/19/2004 | 09/28/2004 | TAILGATE CABLE BREAKAGE | 04V129000 | |
| General motors filed a defect notice 04v-129 on march 17, 2004, which outlines a program to replace the tailgate cables installed in affected model year 2000-2004 vehicles.refer to odi's closing report for ea04-005 for additional information.odi is aware of reports of tailgate cable breakage occurring in model year 1999 and earlier vehicles.these vehicles were equipped with similar tailgate cables as addressed by 04v-129, but are not being addressed by campaign o4v-129.odi is initiating a separate investigation to address these vehicles.the complaint-injury-fatality statistics summarized above pertain to model year 2000-2004 vehicles. the complaint-injury statistics for model year 1999 and earlier vehicles are summarized on the opening resume for that investigation. | ||||||
| STRUCTURE - BODY - TAILGATE - HINGE AND ATTACHMENTS | ||||||
| EA04005 | GENERAL MOTORS CORP. | 02/19/2004 | 09/28/2004 | TAILGATE CABLE BREAKAGE | 04V129000 | |
| General motors filed a defect notice 04v-129 on march 17, 2004, which outlines a program to replace the tailgate cables installed in affected model year 2000-2004 vehicles.refer to odi's closing report for ea04-005 for additional information.odi is aware of reports of tailgate cable breakage occurring in model year 1999 and earlier vehicles.these vehicles were equipped with similar tailgate cables as addressed by 04v-129, but are not being addressed by campaign o4v-129.odi is initiating a separate investigation to address these vehicles.the complaint-injury-fatality statistics summarized above pertain to model year 2000-2004 vehicles. the complaint-injury statistics for model year 1999 and earlier vehicles are summarized on the opening resume for that investigation. | ||||||
| EA04005 | GENERAL MOTORS CORP. | 02/19/2004 | 09/28/2004 | TAILGATE CABLE BREAKAGE | 04E067000 | |
| General motors filed a defect notice 04v-129 on march 17, 2004, which outlines a program to replace the tailgate cables installed in affected model year 2000-2004 vehicles.refer to odi's closing report for ea04-005 for additional information.odi is aware of reports of tailgate cable breakage occurring in model year 1999 and earlier vehicles.these vehicles were equipped with similar tailgate cables as addressed by 04v-129, but are not being addressed by campaign o4v-129.odi is initiating a separate investigation to address these vehicles.the complaint-injury-fatality statistics summarized above pertain to model year 2000-2004 vehicles. the complaint-injury statistics for model year 1999 and earlier vehicles are summarized on the opening resume for that investigation. | ||||||
| WHEELS | ||||||
| PE03026 | GENERAL MOTORS CORP. | 06/12/2003 | 11/03/2003 | STEEL WHEEL RIM FRACTURE | ||
| There have been less than 2 complaints per 100,000 subject vehicles related to the alleged defect.the oldest vehicles (my 1999) have only 2 complaints in over 140 thousand vehicles after over 4 years in service.the rate of warranty claims potentially related to the alleged defect is less than 0.1%.there are no known incidents involving rapid loss of tire pressure or loss of vehicle control. a defect trend has not been identified at this time.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will take further action if warranted by the circumstances. | ||||||
| WHEELS - MULTI PIECE | ||||||
| PE03026 | GENERAL MOTORS CORP. | 06/12/2003 | 11/03/2003 | STEEL WHEEL RIM FRACTURE | ||
| There have been less than 2 complaints per 100,000 subject vehicles related to the alleged defect.the oldest vehicles (my 1999) have only 2 complaints in over 140 thousand vehicles after over 4 years in service.the rate of warranty claims potentially related to the alleged defect is less than 0.1%.there are no known incidents involving rapid loss of tire pressure or loss of vehicle control. a defect trend has not been identified at this time.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will take further action if warranted by the circumstances. | ||||||
| WHEELS - RIM | ||||||
| PE03026 | GENERAL MOTORS CORP. | 06/12/2003 | 11/03/2003 | STEEL WHEEL RIM FRACTURE | ||
| There have been less than 2 complaints per 100,000 subject vehicles related to the alleged defect.the oldest vehicles (my 1999) have only 2 complaints in over 140 thousand vehicles after over 4 years in service.the rate of warranty claims potentially related to the alleged defect is less than 0.1%.there are no known incidents involving rapid loss of tire pressure or loss of vehicle control. a defect trend has not been identified at this time.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will take further action if warranted by the circumstances. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| EXTERIOR LIGHTING - HEADLIGHTS | |||
| 03/25/2002 | 1 | 03/25/2002 | |
| Headlights are not bright enough, they barely extend 30 feet from vehicle. dealer stated all 2002 models are designed that way.*ak *jb | |||