Featherlite Trailer 2009
Model Trailer made in 2009 by Featherlite got 5 consumer complains as well as 2 recalls. Consumer complaints with reference to tires. . There were some recalls concerningequipment and power train.
Model 2009
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 10V573000 | FEATHERLITE, INC. | V (Vehicle) | 4 | MFR | FEATHERLITE, INC. | 11/18/2010 | 11/18/2010 | |||||||||
| Defect Summary | Featherlite trailers is recalling certain trailers equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient. | |||||||||||||||
| Consequence Summary | The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire. | |||||||||||||||
| Corrective Summary | Featherlite trailers is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the recall is expected to begin during december 2010. owners may contact norcold at 1-800-767-9101 or featherlite trailers at 1-877-903-1444. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| POWER TRAIN - AXLE ASSEMBLY | ||||||||||||||||
| 11V396000 | FEATHERLITE, INC. | V (Vehicle) | 127 | 03/29/2011 | MFR | FEATHERLITE, INC. | 03/01/2011 | 08/04/2011 | ||||||||
| Defect Summary | Featherlite is recalling certain model year 2007 through 2012 featherlite trailers equipped with arvinmeritor axles that contain the fag brand bearing system. the bearing system has exhibited low durability life in certain vehicle applications. | |||||||||||||||
| Consequence Summary | Prolonged use of the system in these applications can result in the degradation of the bearing grease, thereby potentially resulting in a bearing failure and subsequent wheel end fire. | |||||||||||||||
| Corrective Summary | Featherlite has notified owners and arvinmeritor is performing the repairs free of charge. the safety recall began on march 29, 2011. owners may contact arvinmeritor's ontrac performance plus call center at 1-866-668-7221 or featherlite at 1-563-547-6000. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| TIRES | |||
| 08/12/2012 | 5200 | 1 | |
| On july 8, 2012 traveling south on i-81 my enclosed trailer suffered a blowout of a towmax radial tire, 225/75r/15 load range e. the trailer is a 24' with (2) 5200lb axles and carrying a 3800lb car with an additional 400lbs of luggage and equipment. the towmax tire was inflated to 80psi per the sidewall instructions. it had a tread separation. the tread came off the tire and as it rotated, beat a hole in the floor of the trailer and tore up the fender and some exterior trim. i purchased 4 towmax radials on 08/09/11 for this trailer. the tire was less than a year old with approximately 2000 miles on it. the firestone dealer said there was no mileage warranty nor defect warranty on the tire. i replaced it with another brand. on 8/12/2012, the same trailer suffered a tire blowout of another branded towmax tire. this tire had approximately 3200 miles on it and was also inflated to 80psi per the sidewall instructions. this was on i-75 and the failure was also a tread separation. i have saved this tire for inspection. the damage this time was more extensive than the previous blowout. i have not replaced this tire yet, but will replace with another brand. estimated trailer damage - $2500. to summarize, i have had 2 tire blowouts of the same brand tires that are one year old with 2k and 3k miles on them respectively. the failures are in the same areas of the tires being tread separation. i believe these are defective tires and should be investigated for possible recall or removal from the market. *tr | |||
| 08/12/2012 | 5200 | ||
| On july 8, 2012 traveling south on i-81 my enclosed trailer suffered a blowout of a towmax radial tire, 225/75r/15 load range e. the trailer is a 24' with (2) 5200lb axles and carrying a 3800lb car with an additional 400lbs of luggage and equipment. the towmax tire was inflated to 80psi per the sidewall instructions. it had a tread separation. the tread came off the tire and as it rotated, beat a hole in the floor of the trailer and tore up the fender and some exterior trim. i purchased 4 towmax radials on 08/09/11 for this trailer. the tire was less than a year old with approximately 2000 miles on it. the firestone dealer said there was no mileage warranty nor defect warranty on the tire. i replaced it with another brand. on 8/12/2012, the same trailer suffered a tire blowout of another branded towmax tire. this tire had approximately 3200 miles on it and was also inflated to 80psi per the sidewall instructions. this was on i-75 and the failure was also a tread separation. i have saved this tire for inspection. the damage this time was more extensive than the previous blowout. i have not replaced this tire yet, but will replace with another brand. estimated trailer damage - $2500. to summarize, i have had 2 tire blowouts of the same brand tires that are one year old with 2k and 3k miles on them respectively. the failures are in the same areas of the tires being tread separation. i believe these are defective tires and should be investigated for possible recall or removal from the market. | |||