Ford E550 2004
Model E550 made in 2004 by Ford got 1 consumer complain there are 4 recalls as well as 43 service bulletins. Consumer complaints with reference to engine and engine cooling. . Technical service bulletines regarding digital instrument panel, electrical system and engine and engine cooling. There were some recalls concerningelectrical system, engine and engine cooling and exterior lighting.
Model 2004
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
04V444000 | FORD MOTOR COMPANY | from 04/23/2002 to 11/19/2003 | V (Vehicle) | 214849 | 10/15/2004 | MFR | FORD MOTOR COMPANY | 09/13/2004 | 09/15/2004 | |||||||
Defect Summary | On certain vans, a diode in the anti-lock braking system (abs) module may experience an electrical short. | |||||||||||||||
Consequence Summary | The electrical short may cause an abs malfunction that would illuminate the abs warning light, or the module may overheat resulting in a burning odor, smoke, and/or fire. this condition may occur while the vehicle is being driven or unattended. | |||||||||||||||
Corrective Summary | Dealers will install a new fuse in the abs circuit and install a heat shield over the abs module. the recall began on october 15, 2004. owners should contact ford at 1-800-392-3673. also ford is extending the limited warranty (for a one time replacement) of the abs module for a total of 10 years or 150,000 miles from the warranty start date, whichever occurs first. if your vehicle has already accumulated more than 150,000 miles, this coverage will last until september 30, 2005. | |||||||||||||||
Notes | Ford recall no. 04s22/customer satisfaction program 04n03.customers can also contact the national highway traffic safety administration | |||||||||||||||
ENGINE AND ENGINE COOLING | ||||||||||||||||
04V445000 | FORD MOTOR COMPANY | from 04/23/2002 to 04/30/2004 | V (Vehicle) | 253076 | 09/27/2004 | MFR | FORD MOTOR COMPANY | 09/13/2004 | 09/16/2004 | |||||||
Defect Summary | On certain vans, the air filter element material process resulted in an air filter paper element that can smolder or burn. this change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles. | |||||||||||||||
Consequence Summary | These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire. | |||||||||||||||
Corrective Summary | Dealers will inspect and replace the air filter element. the recall began september 27, 2004. owners should contact ford at 1-800-392-3673. also ford is extending the limited warranty (for a one time replacement) of the abs module for a total of 10 years or 150,000 miles from the warranty start date, whichever occurs first. if your vehicle has already accumulated more than 150,000 miles, this coverage will last until september 30, 2005. | |||||||||||||||
Notes | Ford recall no. 04s23/customer satisfaction program 04n03. customers can also contact the national highway traffic safety administration | |||||||||||||||
EXTERIOR LIGHTING - BRAKE LIGHTS | ||||||||||||||||
11V352000 | FORD MOTOR COMPANY | V (Vehicle) | 26715 | MFR | FORD MOTOR COMPANY | 07/13/2011 | 07/13/2011 | 571 | 108 | |||||||
Defect Summary | Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate. | |||||||||||||||
Consequence Summary | Non-functioning lights could increase the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the switches free of charge. the safety recall is expected to begin on or about august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. | |||||||||||||||
Notes | Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
FUEL SYSTEM, GASOLINE | ||||||||||||||||
06E056000 | UFI FILTERS USA | E (Equipment) | 58640 | 08/04/2006 | MFR | FORD MOTOR COMPANY | 06/13/2006 | 06/23/2006 | ||||||||
Defect Summary | Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached. | |||||||||||||||
Consequence Summary | Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur. | |||||||||||||||
Corrective Summary | Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876. | |||||||||||||||
Notes | This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
DIGITAL INSTRUMENT PANEL | |||||
06310 | 01/01/2006 | 0665 | 10019949 | Water-in-fuel (wif) lamp on. *tt | 05/17/2006 |
19099 | 10019795 | P0404 service tip. *tt | 04/28/2006 | ||
ELECTRICAL SYSTEM | |||||
19082 | 10019810 | Lack of power or mil on - turbocharger sticking - revised diagnostics. *tt | 04/28/2006 | ||
0582 | 06/07/2005 | 10017921 | Daytime running lights inoperative and a/c not cooling. *tt | 12/07/2005 | |
18115 | 08/01/2004 | 10013246 | Various driveability concerns such as hard start, no start, hesitation, runs rough, erratic shifts, and the malfunction indicator lamp on with a variety of diagnostic trouble codes. wiring harness chafing. *tt | 04/13/2005 | |
18101 | 08/01/2004 | 10013243 | Insufficient charging system output for modified vehicle use. *tt | 04/13/2005 | |
04174 | 09/06/2004 | 10013116 | Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt | 04/08/2005 | |
04194 | 01/01/2006 | 06310 | 10010715 | Water-in-fuel (wif) lamp. *tt | 12/07/2004 |
17949 | 07/01/2004 | 10009345 | Malfunction indicator lamp on with diagnostic trouble code p2195, p2916, p2197 and/or p2198. *tt | 09/24/2004 | |
ELECTRICAL SYSTEM - BATTERY | |||||
19019 | 01/01/2006 | 10019079 | Low battery voltage - 6.0l diesel with single alternator. *tt | 02/10/2006 | |
ENGINE AND ENGINE COOLING | |||||
06213 | 06223 | 10019380 | White smoke, lacks power, exhaust odor, surges, runs rough, or no start - 6.0l. *tt | 03/13/2006 | |
041601 | 11/14/2005 | 05228 | 10018745 | Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt | 01/12/2006 |
18845 | 09/01/2005 | 10018073 | Flutter noise on deceleration. *tt | 12/14/2005 | |
05185 | 10/07/2005 | 10018056 | Rpm surge at idle - audible egr surge - low power/exhaust smoke/rough idle following cold start - high rpm in battery charge protection mode - diagnostic trouble code p0488 and p1334 - 6.0l engine. *tt | 12/14/2005 | |
051713 | 10/07/2005 | 05249 | 10018062 | Coolant degas bottle overflow. *tt | 12/14/2005 |
18598 | 05/01/2005 | 10017911 | Intermittent crank no start due to an egr throttle plate that is stuck closed. the engine may seem like it has no compression due to a faster than normal cranking speed of greater than 200 rpm. dtc p0488 or p1334 may or may not be present | 12/07/2005 | |
18525 | 04/01/2005 | 10017875 | Buck/jerk, lacks power, black smoke, rolling idle, surge, mil on, and diagnostic trouble codes p2263, p0299, or p0401. *tt | 12/06/2005 | |
18734 | 07/01/2005 | 10017864 | Diagnostic trouble code p0488 set after reflash. *tt | 12/05/2005 | |
05215 | 10/31/2005 | 10017806 | Buck/jerk or surge - 6.0l vehicles built before 8/22/2005. *tt | 11/30/2005 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
052623 | 01/01/2006 | 0638 | 10019385 | Coolant degas bottle overflow - 6.0l. *tt | 03/13/2006 |
05249 | 01/01/2005 | 052623 | 10018939 | Coolant degas bottle overflow. *tt | 01/25/2006 |
ENGINE AND ENGINE COOLING - ENGINE | |||||
TSB-08-20-1 | 03/20/2009 | 10028284 | Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. there are several potential causes for these symptoms. *pe | 03/20/2009 | |
052625 | 01/01/2006 | 0697 | 10020069 | Misfire, lack of power, buck/jerk, excessive smoke or crank/no start. *tt | 07/18/2006 |
18362 | 01/01/2005 | 10013307 | Lack of power or runs rough condition, and/or the malfunction indicator light on with egr related diagnostic trouble codes (p0401, p0402, p0403, p0404, p0405, or p0406). *tt | 04/14/2005 | |
18397 | 02/01/2005 | 10012958 | Lack of power, surge, and/or diagnostic trouble codes p2263 or p0299. *tt | 04/05/2005 | |
031404 | 08/23/2004 | 04161 | 10011162 | Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04. | 01/06/2005 |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
TSB-08-26-3 | 06/01/2009 | 10028826 | Ford: some vehicles with diesel engines may experience no starts, hard starts or rough running when cold and may be accompanied with diagnostic trouble codes (dtcs) p0611, p1378 and/or all 8 injector circuit codes. *pe | 06/01/2009 | |
TSB-08-20-1 | 03/20/2009 | 10028284 | Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. there are several potential causes for these symptoms. *pe | 03/20/2009 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
TSB-08-20-1 | 03/20/2009 | 10028284 | Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. there are several potential causes for these symptoms. *pe | 03/20/2009 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
18694 | 06/01/2005 | 10017873 | Lack of power and/or dtc p2263 or p0299 after turbocharger replacement - service tip. *tt | 12/06/2005 | |
18069 | 08/01/2004 | 10011181 | Low power and/or diagnostic trouble code p0299 or p2263 - turbocharger diagnostic service tip. *tt | 01/07/2005 | |
FUEL SYSTEM, OTHER | |||||
19015 | 01/01/2006 | 10019075 | Fuel conditioner. low power, poor fuel economy, fuel gelling in cold weather, excessive white smoke on cold start, hard start, or coking of components exposed to exhaust. *tt | 02/10/2006 | |
FUEL SYSTEM, OTHER - FUEL INJECTION SYSTEM | |||||
TSB-08-26-3 | 06/01/2009 | 10028826 | Ford: some vehicles with diesel engines may experience no starts, hard starts or rough running when cold and may be accompanied with diagnostic trouble codes (dtcs) p0611, p1378 and/or all 8 injector circuit codes. *pe | 06/01/2009 | |
POWER TRAIN | |||||
042516 | 12/27/2004 | 10014269 | Malfunction indicator lamp (mil) illuminated with diagnostic trouble code (dtc) p0756, p0761 or p0771 after overhaul or installation of 2005 torqshift transmission. *tt | 04/29/2005 | |
04B24 | 08/18/2005 | 10012944 | Low/reverse gear set pinion shaft(s) that may walk out, causing metallic particle contamination. customer satisfaction program 04b24. transmission reverse planet replacement. *tt supplement #1 and #2. *tt supplement #3. *tt | 04/04/2005 | |
18051 | 08/01/2004 | 10011180 | Delayed/harsh forward or reverse engagements. *tt | 01/07/2005 | |
18250 | 10/01/2004 | 10010743 | Intermittent clunk on 3-2 downshift during coastdown/tip-in. oasis. to include 2005 f-150, e-series and expedition. *tt | 12/07/2004 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
18822 | 09/01/2005 | 10018070 | Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park. multiple vehicles. ford oasis. to include 2006 ford f-53. *tt | 12/14/2005 | |
18376 | 01/01/2005 | 10013316 | A cold weather reverse engagement stall. *tt | 04/14/2005 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
POWER TRAIN - AXLE ASSEMBLY | |||||
17905 | 07/01/2004 | 10009332 | Multiple vehicles using fehp rear axle fluid. fluid usage change. *tt | 09/23/2004 | |
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
04N03 | 10/01/2004 | 10010545 | Customer satisfaction program 04n03. additional warranty coverage for anti-lock brake system module. *tt | 12/01/2004 | |
SUSPENSION | |||||
05248 | 01/01/2005 | 10018941 | Vibration/harshness above 45 mph (72 km/h) after tire balance. *tt | 01/25/2006 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
02/01/2006 | 38000 | 3 | 01/06/2005 |
Tl* - the contact stated that between the turbo and the inner cooler, there were two stainless steel lines connected with a flexible joint and the flexible joint was coming loose. the contact stated that when it came off he lost power . the contact stated that vehicle pulled a 5th wheel trailer, and that this has happened twice. the contact stated that neither the weather nor the road conditions were a factor. the contact also stated that he was driving 50 mph. ak the consumer stated the part was replaced under warranty/ updated 06/08/07. *jb |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
WA | VANCOUVER | FORD AGENCY |