Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | ||||||||||||||||
90V101000 | FORD MOTOR COMPANY | to 10/01/1989 | V (Vehicle) | 111000 | 07/17/1990 | ODI | FORD MOTOR COMPANY | 06/01/1990 | 06/14/1990 | |||||||
Defect Summary | Under certain conditions, the snap ring that locates the park gear on the output shaft of the transmission may fracture. | |||||||||||||||
Consequence Summary | When the gear is placed in park, the park gear would notengage, allowing the truck to roll freely if the parking brake is not properlyset. this could result in an accident. | |||||||||||||||
Corrective Summary | Install improved snap ring and revised transmission extension housing. | |||||||||||||||
Notes | System: park gear snap ring.vehicle description: 4 x 2 light trucks and vans equipped with one-piecedriveshaft and an e40d transmission. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
0015 | 01/10/2000 | 612203 | Information regarding the new transmission cooler flusher- service tip. *mjs | 06/06/2000 | |
98168 | 04/07/2000 | 609737 | Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd | 04/07/2000 | |
98123 | 01/19/1998 | 605599 | Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt | 07/13/1999 | |
9888 | 04/27/1998 | 601238 | Information on a new transmission fluid usage chart. *yc | 07/10/1998 | |
97511 | 03/03/1997 | 51945 | Fluid- transmission fluid usage charts. *jd | 07/17/1997 | |
95619 | 03/01/1995 | 39913 | New design transmission range sensor. *tw | 11/01/1995 | |
951112 | 06/01/1995 | 45085 | Revised design transmission rear case bushing. *tw | 11/01/1995 | |
BC4178950401 | 04/01/1995 | 3055145 | Unknown | 11/01/1995 | |
951113 | 06/01/1995 | 45086 | Delayed forward engagement and/or heat stained forward clutch plates after installing center support service. *tw | 11/01/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
002310 | 11/13/2000 | 616522 | Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt | 03/05/2001 | |
0038 | 02/07/2000 | 612343 | Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs | 06/07/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||||
962612 | 12/16/1996 | 50997 | Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw | 06/17/1997 | |
96249 | 11/18/1996 | 50908 | Torque converter - leak test procedure - service tip. *tw | 06/17/1997 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
96728 | 03/25/1996 | 613350 | Service tip information regarding the reverse clutch piston and piston seal usage. *tt | 06/22/2000 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | ||||||
PE90056 | FORD MOTOR COMPANY | 03/12/1990 | 06/12/1990 | TRNSMSSION PARK GEAR FAIL | 90V101000 | |
There is no summary currently available |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN | |||
55 | |||
Transmission has failed on three occasions. | |||
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
02/20/2001 | 1 | ||
If not parked on flat ground it will pop out of park. consumer stated that once it popped out of park, and came backwards towards consumer. consuamer would like his vin added to recall 90 v 101 000.*ak | |||
11/11/1995 | 3 | ||
Transmission keeps freezing up, this is the 3rd time while driving. *ak | |||
POWER TRAIN - AXLE ASSEMBLY | |||
While driving rear axle fell off. | |||
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||
03/27/1995 | |||
Clutch and brake pedal became stiff. tt | |||
POWER TRAIN - DRIVELINE - UNIVERSAL JOINT | |||
05/03/1999 | 1 | 04/01/1990 | |
Two rear universal joints were replaced, due to failure. *yc | |||
07/16/1996 | 6 | ||
Leaf springs broke on u - joints. *sd | |||
POWER TRAIN - MANUAL TRANSMISSION | |||
05/02/1991 | 2 | ||
Vehicle intermittently stalls at 40-50 mph, numerous repairs, replacing egr valve, cleaning fuel injectors, replacing ignition module, did not remedy the problem. *ak consumer states that the clutch is noisy. dealer replaced throw-out bearing. consumer states serpentine belt is noisy. dealer replaced belt. *tt | |||
06/01/2000 | 1 | ||
Transmission failed while driving. nlm |