Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS | ||||||||||||||||
92V026000 | FORD MOTOR COMPANY | from 08/01/1987 to 08/01/1991 | V (Vehicle) | 467000 | 06/10/1992 | ODI | FORD MOTOR COMPANY | 03/03/1992 | 03/11/1992 | |||||||
Defect Summary | A revised brake lining noise insulator resulted in a decrease in the thermal insulation between the brake lining and the front brake caliper piston. this caused greater heat transfer to the caliper pistons with the potential to overheat the brake fluid and diminish brake effectiveness during severe braking conditions. | |||||||||||||||
Consequence Summary | Increased stopping distances and inablility to holdvehicles on a steep grade results in increased risk of accident in the event ofa sudden stop or when constant braking is needed to maneuver through areas withsteep grades. | |||||||||||||||
Corrective Summary | Add snap-in insulators that attach to each of the front brake caliper pistons. in addition, vehicles with 7.5 l engines will have insulation added to the engine compartment brake lines. | |||||||||||||||
Notes | System: brakes; front brake lining.vehicle description: f250 and f350 trucks with 7.3 l diesel and 7.5 l efiengines ; f250 and f350 4x4 models with 5.8 l efi engines.note: ford recommends vehicle operators do not exceed the gcwr and gvwr of theirvehicles, and proper maintenance of the brakes on these vehicles and any trailerparticularly when operating in mountainous areas with long, steep grades. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
985A29 | 03/18/1998 | 601036 | Some vehicles may exhibit excessive brake pedal travel, irregular front lining wear, and brake pull. *yc | 06/23/1998 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||||
985A38 | 03/18/1998 | 601045 | Front caliper piston boots damaged. *yc | 06/23/1998 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | ||||||
EA91044 | FORD MOTOR COMPANY | 10/30/1991 | 10/30/1992 | LOSS OF BRAKE EFFECTIVENES | 92V026000 | |
There is no summary currently available | ||||||
PE91077 | FORD MOTOR COMPANY | 05/23/1991 | 10/31/1991 | LOSS OF BRAKE EFFECTIVENES | ||
There is no summary currently available |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, AIR - SUPPLY - HOSES, LINES/PIPING, AND FITTINGS | |||
09/01/1996 | 1 | ||
Brake lines rusted. | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
09/15/2001 | |||
When in low gear brake fluid will boil, causing vehicle to lose brakes.*ak | |||
While slowing down the abs would fade away upon traveling 25mph. delaer has been contacted. *ak | |||
01/01/1999 | |||
Abs brake problem; when the abs warning light came on, owner brought truck to the dealer for service. owner purchased a r.a.b.s valve. abs warning light remained on. owner now needs a module replaced that is no longer availabe from the manufacturer. part # e7tf-2c018-ab or ac. *ak | |||
11/11/1996 | |||
Anti-lock brake system problems; when applying the brakes on any type of road surface, under normal braking conditions, the right rear wheel locks up, causing the truck to go into a skid. this problem has been mentioned to the dealer. the system has not been checked. owner still experiencing a problem with system. *ak | |||
1 | 01/01/1992 | ||
Anti-lock brakes experience extended stopping distance and fading, causing lack of stopping control. | |||
05/27/1997 | 2 | ||
Lost front brakes completely, partial rear brakes during heavy duty aplication, brake fluid overheats/blows out, causing holes in calipers, mechanic replaced calipers. *ak | |||
09/01/1990 | 1 | 08/21/1989 | |
Antilock brakes failed. | |||
07/03/1996 | 1 | 07/06/1991 | |
Brakes failed, causing brake pedal to travel to floor. | |||
1 | |||
Abs brakes failed, causing vehicle to lose control/skid, resulting in an accident (other vehicle from 976144). *ak | |||
06/12/1995 | |||
Has rear abs brakes. the truck would not stop when brakes were applied . please describe. *ak | |||
03/15/1995 | 1 | ||
Abs: while driving downhill applying brakes as needed, pedal went to floor; lost braking power; brakes overheated; needed heat shield. tt | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
06/01/1992 | 2 | 07/01/1989 | |
Brakes fail prior to recall, recall work done however remedy failure; overheating of brakes still occurring. recall 92s44 done | |||
10/01/1996 | 1 | 10/01/1988 | |
Brakes too soft, 'rabs' valve replaced. | |||
06/10/1996 | 1 | ||
Brakes overheat. | |||
05/01/1996 | 1 | 02/09/1989 | |
The rear grease seals leaked and spilled grease on the brakes and now they don't stop.*ak which was also causing emergency brake not to hold.*jb | |||
08/29/1995 | |||
Loss of brake effectiveness brake pedal goes to the floor pe91-077. tt | |||
08/10/1995 | |||
Brake system failure, total loss of braking ability. tt | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
07/01/1992 | 1 | 10/01/1988 | |
Front grakes failed and new piston insulators replaced. | |||
04/01/1996 | 3 | ||
Front brakes replaced due to brake failure.*sd | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
05/27/1997 | 2 | ||
Lost front brakes completely, partial rear brakes during heavy duty aplication, brake fluid overheats/blows out, causing holes in calipers, mechanic replaced calipers. *ak | |||
07/30/1993 | 1 | ||
Brake calipers/rotors/ drums repaired. | |||
08/27/1994 | 7 | ||
Left front brake caliper sticking, causing brake failure. *ak | |||
08/27/1994 | 7 | ||
Front calipers stick due to brake fluid overheating, causing loss of brakes. *skd | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
05/01/1991 | 6 | 05/01/1991 | |
Front brakes failed. | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
07/30/1993 | 1 | ||
Brake calipers/rotors/ drums repaired. | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM | |||
07/01/1992 | 1 | 10/01/1988 | |
Rear brakes leaked at rear wheel, brake shoes, axle seals and drums replaced. | |||
07/30/1993 | 1 | ||
Brake calipers/rotors/ drums repaired. | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS | |||
1 | |||
Prior to safety recall (92s44) in which consumer never received, the brakes on vehicle malfunctioned when applied, causing consumer to loose control of vehicle whcih then went over an embankement, the vehicle was decalred totaled and consumer is seeking a $500.00 decductible from manufacturer that he incurred.*jb | |||
1 | 06/07/2000 | ||
Vehicle experiencing brake failure which is a recall related failure (92v-026/92s44), however vehicle denied due to vin#. yh | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
1 | 07/01/1989 | ||
Brake failure prior to recall, the consumer had recall work done to no satisfaction, the problem still exists. (recall #93s69) |