Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 15845 | 04/01/2002 | 637595 | Subject regarding think neighbor electrical leaks from the battery pack to the frame with leakage icon illumination. *tt | 12/03/2002 | |
| 15801 | 04/01/2002 | 637523 | Some think neighbor may exhibit a hum noise from the charger. *tt | 12/02/2002 | |
| 15703 | 03/01/2002 | 636341 | Some think neighbor vehicles may exhibit the charge icon illuminated when the vehicle isnot on charge and the charge cord is not connected to the vehicle. *tt | 11/07/2002 | |
| 16127 | 08/01/2002 | 636150 | Some think neighbor may not enable due to a damaged charger fuse cap, malfunctioning charger, or inoperative charger fuse. *tt | 11/06/2002 | |
| 16143 | 08/01/2002 | 636167 | Some think neighbors may exhibit a vehicle no enable condition due to fretting corrosion between the 23 pin harness connector and the motor controller. *tt | 11/06/2002 | |
| 02133 | 07/08/2002 | 635989 | Some think neighbors may exhibit a gauge malfunction, failure to charge, reduced mileage range, or inability to move forward or reverse. *tt | 11/04/2002 | |
| 15619 | 02/01/2002 | 630663 | For some think neighbor, the instrument gauge may not be programmed correctly for the type of batteries installed in the vehicle. *tt | 04/19/2002 | |
| 020102 | 01/01/2002 | 630155 | Some vehicles may exhibit a weak horn chirp confirmation when the key fob is used, or an inoperative horn when the engine is not running. *tt | 04/15/2002 | |
| ELECTRICAL SYSTEM - BATTERY | |||||
| 15847 | 04/01/2002 | 637597 | Some think neighbor may exhibit the loss of the battery water maintenance reminder icon illuminating, however, the icon may then reset itself and turn off. *tt | 12/03/2002 | |
| 15718 | 03/01/2002 | 636360 | Some 2002 think neighbor may exhibit an instrument gauge which fails to update state of charge on battery level indicator. *tt | 11/07/2002 | |
| ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
| 15610 | 05/01/2002 | 637691 | Subject regarding 2002 think neighbor exhibiting a diagnostic trouble code 51. *tt | 12/04/2002 | |
| 15803 | 04/01/2002 | 637526 | Some think neighbor may experience the loss of diagnostic trouble codes when pulling them out of memory from the cluster. *tt | 12/02/2002 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 08/01/2003 | 1 | ||
| I have several issues, both back door windows have fallen off track and won't stay up. this happened in september of 07 and a few months later the second rear window did the same. i have to use clear packaging tape to hold them up. the key to the ignition will not turn unless i use something with a hard end and tap it several times. when the ignition problem first happened in september of 2006 i called ford road side service and they recommended tapping the key several times and said they had a growing complaint of this. my trunk lock latch often gets stuck too. jan of 2003 the radio shorts in and out, i never know if it's going to stay on. lastly the passenger rear door look doesn't latch, i think this happened in late 2003 or early 2004. *tr | |||
| 08/01/2003 | 2000 | 11/01/2002 | |
| There was a strong smell coming out of the air conditioner vents in the warm months. that i describe as a urine odor. the dealership installed a fan in the air conditioner that comes on 15 minutes after the car is turned off to dry out the air unit. | |||