Gmc K2500 2001
Model K2500 made in 2001 by Gmc got 8 consumer complains, 5 investigations there is 1 recall as well as 11 service bulletins. Consumer complaints with reference, among others things, to engine and engine cooling, equipment and fuel system, gasoline. Technical service bulletines regarding engine and engine cooling, power train and structure. The car had some investigations: service brakes, hydraulic, steering. There was one recall concerning interior lighting .
Model 2001
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| INTERIOR LIGHTING | ||||||||||||||||
| 01V220000 | GENERAL MOTORS CORP. | from 04/01/2001 to 06/15/2001 | V (Vehicle) | 38863 | 07/09/2001 | MFR | GENERAL MOTORS CORP. | 06/26/2001 | 07/03/2001 | 571 | 105 | |||||
| Defect Summary | Vehicle description: certain pickup trucks equipped with 6.6l diesel engines fail to comply with requirements of fmvss no. 105, hydraulic and electric brake systems. these vehicles have a brake system warning light in the instrument cluster that may not illuminate when the brake fluid is low. in addition, when the brake fluid is low, the vehicle may not meet the partial system requirements of fmvss no. 105. | |||||||||||||||
| Consequence Summary | These conditions could result in reduced braking capability, which could lead to a crash. | |||||||||||||||
| Corrective Summary | Dealers will change the location of a wire connection in the underhood bussed electrical center. owner notification began july 9, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. | |||||||||||||||
| Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| PIP-4695 | 09/01/2009 | 10032435 | Gm: loss of power hesitates on acceleration. 4.3, 4.8, 5.3, 5.7 and 6.0 engines coupled with the 4l60e or 4l65e may experience a condition of hesitates, misses or loss of power under acceleration. the vehicle may operate as if it is in r | 03/24/2010 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
| 020601010 | 03/01/2002 | 632326 | Information on serpentine belt identification and diagnosis for certain hd pickup models. *tt | 07/12/2002 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 000730017B | 01/01/2002 | 000730017A | 631802 | Subject regarding service parts resriction program for allison series 1000 automatic transmission. *slc | 06/20/2002 |
| 010417001B | 03/01/2002 | 010417001A | 629551 | Subject regarding launch shudder on acceleration (install new one-piece propeller shaft) *jg | 04/02/2002 |
| 010730021 | 05/01/2001 | 619742 | This technical service bulletin states that technicians may experience difficulty in removing the connectors from the park / neutral position switch, usually when trying to remove the switch during transmission service. *tt | 06/26/2001 | |
| 010730020 | 04/01/2001 | 619715 | Subject ordering reference table for ordering the new valve body, spacer plate and gasket kit. *tt | 06/25/2001 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 010417001 | 02/01/2001 | 619173 | Some extended and crew cab long box pickup models including 1999 and 2001 chevrolet k2500 models with automatic transmission may exhibit a vibration (launch shudder) during acceleration from 0-40 km/h (0-25). | 05/17/2001 | |
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||||
| 010417001A | 06/01/2001 | 010417001 | 623047 | Some customers may comment on a vibration during acceleration from 0 - 40 km/h (0 - 25 mph). *tt | 10/25/2001 |
| STRUCTURE - FRAME AND MEMBERS | |||||
| 0007 | 10/06/2000 | 618681 | Fisher service bulletin regarding 7161 kit fit-up to year 2001 gm trucks. *tt | 04/20/2001 | |
| UNKNOWN OR OTHER | |||||
| 010730002B | 05/01/2001 | 010730002A | 619741 | Malfunction indicator lamp (mil) is on; the transmission is stuck in third gear; and / or the instrument cluster is inoperative. *tt | 06/26/2001 |
| VISIBILITY - WINDSHIELD WIPER/WASHER - MOTOR | |||||
| 070501 | 05/07/2001 | 619775 | Customer may complain that the wiper motor is inoperative or that the wiper motor fuse blows repeatedly. *tt | 06/29/2001 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST - PUMP | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 07/22/2002 | 1 | ||
| When starting up vehicle consumer can here knocking noises coming from motor. also rattling noise coming from under vehicle. dealer notified. *ak the engine knocks when starting cold. rear passenger side door makes noise. the steering column shows rubbing sound. the driver side speaker fell off. right front window makes grinding noise when goes up or down. passenger side power window regulator failed. fuel door bumper failed. left front door lock switch came off. *yh | |||
| EQUIPMENT - ELECTRICAL - RADIO/TAPE DECK/CD ETC. | |||
| 07/22/2002 | 1 | ||
| When starting up vehicle consumer can here knocking noises coming from motor. also rattling noise coming from under vehicle. dealer notified. *ak the engine knocks when starting cold. rear passenger side door makes noise. the steering column shows rubbing sound. the driver side speaker fell off. right front window makes grinding noise when goes up or down. passenger side power window regulator failed. fuel door bumper failed. left front door lock switch came off. *yh | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
| 07/22/2002 | 1 | ||
| When starting up vehicle consumer can here knocking noises coming from motor. also rattling noise coming from under vehicle. dealer notified. *ak the engine knocks when starting cold. rear passenger side door makes noise. the steering column shows rubbing sound. the driver side speaker fell off. right front window makes grinding noise when goes up or down. passenger side power window regulator failed. fuel door bumper failed. left front door lock switch came off. *yh | |||
| STEERING - LINKAGES - KNUCKLE - SPINDLE - ARM | |||
| 4 | |||
| Owner was driving when vehicle slightly went off the road. once vehicle resumed normal operations spindle broke, causing it to lose control and roll over four times. please describe details. *ak | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 07/22/2002 | 1 | ||
| When starting up vehicle consumer can here knocking noises coming from motor. also rattling noise coming from under vehicle. dealer notified. *ak the engine knocks when starting cold. rear passenger side door makes noise. the steering column shows rubbing sound. the driver side speaker fell off. right front window makes grinding noise when goes up or down. passenger side power window regulator failed. fuel door bumper failed. left front door lock switch came off. *yh | |||
| STRUCTURE - BODY - DOOR | |||
| 07/22/2002 | 1 | ||
| When starting up vehicle consumer can here knocking noises coming from motor. also rattling noise coming from under vehicle. dealer notified. *ak the engine knocks when starting cold. rear passenger side door makes noise. the steering column shows rubbing sound. the driver side speaker fell off. right front window makes grinding noise when goes up or down. passenger side power window regulator failed. fuel door bumper failed. left front door lock switch came off. *yh | |||
| SUSPENSION | |||
| 4 | |||
| Owner was driving when vehicle slightly went off the road. once vehicle resumed normal operations spindle broke, causing it to lose control and roll over four times. please describe details. *ak | |||
| VISIBILITY - POWER WINDOW DEVICES AND CONTROLS | |||
| 07/22/2002 | 1 | ||
| When starting up vehicle consumer can here knocking noises coming from motor. also rattling noise coming from under vehicle. dealer notified. *ak the engine knocks when starting cold. rear passenger side door makes noise. the steering column shows rubbing sound. the driver side speaker fell off. right front window makes grinding noise when goes up or down. passenger side power window regulator failed. fuel door bumper failed. left front door lock switch came off. *yh | |||