Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
040604088 | 03/01/2005 | 040604088A | 10014959 | Replacement of connector when replacing fuel tank module/fuel pump module. *tt | 05/12/2005 |
040603002 | 02/01/2004 | 10012703 | Diagnostic information for intermittent vehicle no crank dead battery. *eh | 03/10/2005 | |
3107 | 01/01/2004 | 10010197 | P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc | 11/04/2004 | |
3121 | 01/01/2004 | 10010056 | Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc | 11/03/2004 | |
01225 | 01/01/2004 | 01225A | 10007717 | Engine coolant leak at intake gasket. * mj | 07/08/2004 |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
3121 | 01/01/2004 | 10010248 | Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc | 11/08/2004 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
4231 | 10021021 | Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb | 02/22/2007 | ||
3691B | 10019426 | Generation iii v8 engine piston repairs. *tt | 03/14/2006 | ||
3267 | 10017155 | Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc | 10/26/2005 | ||
3232 | 3232A | 10014870 | 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt | 05/10/2005 | |
3081 | 10010375 | Service engine soon light and p0300 when towing, cruising uphill or on hard acceleration. *tt | 11/17/2004 | ||
3056 | 10010364 | Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt | 11/17/2004 | ||
3055 | 01/01/2004 | 10009666 | Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt | 10/14/2004 | |
3038 | 01/01/2004 | 10009648 | Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt | 10/14/2004 | |
3015 | 01/01/2004 | 10008781 | 6.0l lq4 vin u engine restriction. *tt | 08/23/2004 | |
01119A | 01/01/2004 | 01119B | 10007576 | Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt | 07/01/2004 |
01484 | 01/01/2004 | 10005499 | Gen iii replacement flywheel bolt holes larger than original part. the bolt holes for the crank shaft in the replacement flywheel are larger than the holes in the original part. sit bulletin 1400596. *tt | 03/01/2004 | |
00969A | 01/01/2004 | 00969B | 10005469 | Engine whistle noise. *tt | 02/27/2004 |
030604060 | 10/01/2003 | 10004733 | Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt | 01/02/2004 | |
030601024 | 08/01/2003 | 10004371 | Rattle noise in engine. *tt | 12/04/2003 | |
030601024A | 03/01/2004 | 030601024B | 10004301 | Rattle noise in engine. *tt | 12/01/2003 |
00634A | 11/18/2003 | 10004162 | Gen iii engine noise after hot soak restart. *tt | 11/20/2003 | |
020604054B | 03/01/2003 | 020604054A | 10001273 | Increased accelerator pedal effort, idle instability. *tt | 04/25/2003 |
020601029 | 09/01/2002 | 10000064 | Needle bearings found in oil pan. *tt | 02/10/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
020604023A | 06/01/2002 | 020604023 | 634788 | Some customers may comment on a mild to severe engine ping (commonly referred to as spark knock) usually worse during acceleration and / or an illuminated malfunction indicator lamp. *tt | 10/09/2002 |
010601029B | 07/01/2002 | 010601029A | 634805 | Some customers may comment on higher than expected engine oil consumption. *tt | 10/09/2002 |
020604023 | 05/01/2002 | 634723 | Some customers may comment on a mild to severe engine ping (spark knock) during acceleration and / or illuminated malfunction indicator lamp with diagnostic trouble code p0332 set. *tt | 10/07/2002 | |
010417004A | 01/01/2005 | 010417004B | 627861 | Clunk, bump or squawk when vehicle comes to a complete stop or acceleration from complete stop. *yh update. *tt | 02/25/2002 |
010604006 | 02/01/2001 | 619179 | Some customers may comment on a lean hesitation, sag or stumble present during light to moderate accelerations. *tt | 05/17/2001 | |
111200 | 12/11/2000 | 617778 | Some customers may complain that their full-size pickup trucks may be hard to start or intermittently does not start. *tt | 04/11/2001 | |
021000 | 10/02/2000 | 617717 | Subject regarding customer complaint of whistle and wind rush or flutter type noise. *tt | 03/24/2001 | |
00601001 | 02/01/2000 | 611288 | Some customers may comment on a whirling sound from the lower rear side of the engine, occuring as the engine warms up, between 1500 and 2000 engine rpm on vehicles within various vin breakpoints. *tt | 06/01/2000 | |
866506 | 11/01/1998 | 602978 | Some vehicles may experience engine idle shake in drive, park, or neutral. *yc | 01/22/1999 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
030605008B | 11/01/2005 | 030605008C | 10005576 | Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt | 03/04/2004 |
020605003C | 02/01/2004 | 020605003B | 10002939 | Exhaust moan/vibration. *tt update. *tt | 10/01/2003 |
020605003A | 03/01/2003 | 020605003 | 10001274 | Exhaust moan/vibration. *tt | 04/25/2003 |
020605003 | 06/01/2002 | 634770 | Exhaust moan or vibration at low vehicle speeds between 900-1200 rpm under load. *tt | 10/09/2002 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
3119 | 01/01/2004 | 10010101 | Engineering investigation - catalytic converter replacement. *sc | 11/04/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
99009 | 04/30/1999 | 606540 | Voluntary emission campaign regarding vehicles built with the wrong exhaust gas recirculation valve. *tt | 08/26/1999 | |
99009 | 04/01/1999 | 606536 | Subject regarding exhaust gas recirculation valve (egr) misbuilds. *tt | 08/26/1999 | |
99109 | 05/04/1999 | 605954 | Recall campaign regarding exhaust gas recirculation valve misbuilds. *tt | 08/02/1999 | |
99009 | 04/01/1999 | 604888 | Voluntary emission campaign involving vehicles with a misbuilt exhaust gas recirculation valve. *tt | 05/18/1999 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
06/09/2001 | 40000 | 06/08/2001 | |
Engine knocks on cold start | |||
10/15/2003 | 44000 | ||
Truck had complete loss of oil pressure. mechanic said engine appeared to have been run without oil. knowing that this did not occur the failure had to be caused by a defect in the engine. i have been unable to get any cooperation. | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
12/20/2001 | 46000 | 6 | 11/14/2001 |
Repeated abs brake failure. this has not been corrected despite numerous attempts to repair problem(s). heater motor malfunction, repeated wiper arm replacement, tailgate handle malfunction. | |||
11/10/2002 | 08/01/2099 | ||
I experienced a sudden onset of a hissing noise coming from under the dashboard. the noise only starts above 1400 rpm and when warm. i have taken it to 2 gmc dealers and 1 independent service shop. all have stated that the noise is water going through the heater core. 1 dealer said that the coolant must have broken down and gelled or scaled into the heater core; therefore, it must be replaced. gmc owners manual states change coolant at 150000 mile or 5 years, if so, why did the coolant break down? this appears to be a major issue and i have read of similar cases. please help. dt | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
02/21/2006 | 65000 | 1 | 01/01/1999 |
Dt*: the contact stated a knocking noise was heard momentarily when starting the vehicle. the vehicle has been taken to the dealership 3 times who determined the pistons were knocking. the problem cannot be repaired. the dealership informed the contact of a tsb #010601028a. updated 3/9/2006 - *nm | |||
03/10/2004 | 49900 | 2 | |
While driving at 30 mph the consumer applied the brakes and the pedal went to the floor, resulting in extended stopping distance. the dealer replaced the rotors and pads twice, however the problem recurred. *ak the vehicle also had tailgate and engine problems. the tires were replaced due to thread cracks. *jb | |||
01/10/2003 | 68000 | 0 | 09/15/2002 |
Fuel pump will over heat and than short out. exhaust always rattles engine knocks cat. converters went out digital display stopped working | |||
05/25/2000 | 90 | 09/01/1999 | |
The engine has two lifters, 5&8 knocking. i've been to the dealer and called the gmc customer service line three times each. they both say there is nothing they can do about it. gm is currently investigating condition.*ak | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
03/06/2000 | 3 | ||
Consumer states there is a loud knocking sound in engine every morning at start up, dealer could not find the cause, the manufacturer offered the consumer a warranty on the engine, consumer still experiencing problem.*yh | |||
03/21/1999 | 1 | 12/03/1998 | |
The engine failed. yh | |||
09/21/1999 | 1 | 02/01/1999 | |
The rear rotors u-joint, carbon build up on throttle, replaced window motor uses 2 qts of oil every 400 to 500 miles , transmission uses 1 qt of oil every 20000 miles , air conditioner fan does not work on high i believe the throttle build up is a safety issue with the gas petal sticking. we have a lemon | |||
06/01/1999 | |||
Engine knocks loudly at start-up and last for aprox. 2 minutes - dealer said this is a normal occurrence. the engine also has spark knock when accelerating and dealer also says this is normal - dealer said this is due to carbon build up on ring lands and could be temporarily repaired but would re-occur within 10,ooo miles. this problem started at 15,000 miles and continues to date. i cannot solve the problem with any type of additive advised by the dealer. dealer said gmc has a defective engine and i have to live with it. they told me even if they replaced the motor i would have the same problem with the knocking and pinging on accelleration. the dealer contacted gmc technical advisor dan pratner case # 3970330 and he advised them this was normal for this engine. i find it hard to believe a person can purchase a vehicle with a defective engine and be told this is normal. the public needs to know before they buy this particular product so they do not end up with a defective product that will cause them additional maintenance costs and a very low resale value not to speak of the embarrassment of having a vehicle that knocks loudly on cold start-up. i do not know what the long term effects of this engine knocking will do. if you do investigate this problem and find this to be caused by another problem that can be repaired, please let me know. thank you for your time. *ak | |||
While driving at 80mph the vehicle will sporadically go out while switching lanes, then kicks back in after a few seconds. dealer can't solve problem. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
09/30/1999 | 10 | 04/01/1999 | |
Has occuring ehaust leak, service wont fix. using brakes while slowing and hitting bump in road, brakes will pulseate very hard and vechile will not stop | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
01/10/2003 | 68000 | 0 | 09/15/2002 |
Fuel pump will over heat and than short out. exhaust always rattles engine knocks cat. converters went out digital display stopped working | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
11/07/2003 | 49000 | 7 | |
Faulty braking system engine noise muffler replace instrument panel fault tire wear transmission automatic shifting rearend noise | |||
01/10/2003 | 68000 | 0 | 09/15/2002 |
Fuel pump will over heat and than short out. exhaust always rattles engine knocks cat. converters went out digital display stopped working |