Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||||||||||||
06V289000 | GENERAL MOTORS CORP. | from 03/01/2003 to 08/31/2004 | V (Vehicle) | 38439 | 08/31/2006 | MFR | GENERAL MOTORS CORP. | 08/03/2006 | 08/03/2006 | |||||||
Defect Summary | On certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. | |||||||||||||||
Consequence Summary | If the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. | |||||||||||||||
Corrective Summary | Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. | |||||||||||||||
Notes | Gm recall no. 06080.customers may also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
050601034 | 11/01/2005 | 10018733 | Engine oil leak at rear cover assembly area. *tt | 01/12/2006 | |
050849026 | 11/01/2005 | 10018716 | Low oil pressure message display and chimes activated while driving following hybrid (hp2) lm7 engine auto-start (reprogram the pcm). *ts | 01/11/2006 | |
3100C | 10018575 | Ses light due to dtc p0116. *tt | 01/06/2006 | ||
3639 | 10018535 | Oil pressure gauge reading low or near red zone. *tt | 01/05/2006 | ||
0509610018 | 06/01/2005 | 10017533 | Accessory drive belt chirp, squeal, or squeak type noise at cold idle. *tt | 11/09/2005 | |
3317 | 12/01/2008 | 3317F | 10017214 | Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe | 10/28/2005 |
3312 | 10017208 | No start, hard start, loss of power, or white smoke. *tt | 10/27/2005 | ||
050604025 | 03/01/2005 | 10015009 | Revised diagnostic trouble code (dtc) u2104. *tt | 05/13/2005 | |
050604024 | 03/01/2005 | 10015008 | Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt | 05/13/2005 | |
050603001 | 03/01/2005 | 10014989 | Revised engine electrical and automatic transmission - 4l60e/4l65e subsections - new caution statements added. *tt | 05/13/2005 | |
050604023 | 03/01/2005 | 10015007 | Revised diagnostic trouble code (dtc) p2563. *tt | 05/13/2005 | |
3328A | 10014952 | Surge at idle or 1100 to 1400 rpm. *eh | 05/12/2005 | ||
3380 | 10014932 | Oil leak from the pcv vent tube. *tt | 05/12/2005 | ||
3375 | 3375A | 10014923 | Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt | 05/11/2005 | |
3299 | 10013563 | Diesel oil leak from pcv vent tube. *eh | 04/21/2005 | ||
3292 | 10013512 | Diesel engine balance rates all showing zero. *eh | 04/20/2005 | ||
050090001 | 01/01/2005 | 10013446 | Information on the proper air filter for the duramax diesel. *eh | 04/19/2005 | |
11062003 | 11/06/2003 | 10013155 | Airflow sensor problem. *eh | 04/11/2005 | |
020601023C | 11/01/2004 | 020601023D | 10012750 | Oil leak at cooler to engine block mating surface. *eh | 03/14/2005 |
040603002 | 02/01/2004 | 10012703 | Diagnostic information for intermittent vehicle no crank dead battery. *eh | 03/10/2005 | |
040603001 | 02/01/2004 | 10012670 | Incorrect amp code generator. *eh | 03/10/2005 | |
040604007A | 04/01/2004 | 040604007 | 10012594 | Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. this service bulletin replaces 040604007. *eh | 03/08/2005 |
040604032 | 05/01/2004 | 10012601 | Proper method to secure fuel cap during refueling. *eh | 03/08/2005 | |
040601012 | 05/01/2004 | 040601012A | 10012591 | Rattle or crackling noise from engine compartment. *eh updated 03-07-06. *kb | 03/08/2005 |
030604036 | 10/01/2006 | 030604036A | 10012561 | Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb | 03/07/2005 |
3238C | 3238E | 10011735 | Fuel injector driver circuit codes p0201 through p0208. this also includes 2004 2005 lly c2 c3 c4 c5 e4 e5 d4 d5 k2 k3 models. *eh updated *eh | 01/31/2005 | |
3239 | 10011743 | Lb7 engine vibration miss or runs rough no diagnostic trouble code. this also includes lb7 c2 c3 c4 c5 d4 d5 e4 e5 k2 k3. *eh | 01/31/2005 | ||
3227 | 10011674 | Broken #2 and #7 injector connector terminals. this also includes lly 6.6 c2 c3 c4 c5 k2 k3 d4 d5 e4 e5. *eh | 01/28/2005 | ||
3230 | 10011689 | Diesel oil leak at right rear of engine. this includes lly c2 c3 c4 c5 d4 d5 e4 e5 k2 k3 models. *eh | 01/28/2005 | ||
3068B | 3068C | 10011576 | Turbo air charge cooler hoses oil seepage or blows off on acceleration. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh | 01/27/2005 | |
3212A | 3212B | 10011584 | Fuel leaking from body of injector. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh | 01/27/2005 | |
09132004 | 09/13/2004 | 10011255 | Rough idle with white smoke and high balance rates. a 1700 1800 light throttle combustion noise. parking lot surge under ten miles per hour with engine rpm around 800 to 1000 rpm. this also includes 2004 3500 trucks with 6.6 liter diesel en | 01/12/2005 | |
3011B | 3011C | 10010872 | Engine oil leak at main bering side bolt. *eh | 12/15/2004 | |
3187 | 06/01/2009 | PIP-3187A | 10010865 | Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe | 12/15/2004 |
3193 | 3193B | 10010647 | Excessive oil consumption. *eh | 12/03/2004 | |
3204 | 10010663 | Coolant leak at engine mount bolt. *eh | 12/03/2004 | ||
3097 | 01/01/2004 | 10010242 | Oil pan or oil cooler line leak. *sc | 11/05/2004 | |
3138 | 01/01/2004 | 10010106 | Accessory drive belt chirp noise at cold idle. *tc | 11/04/2004 | |
3121 | 01/01/2004 | 10010187 | 6.6 lb7 engine with a no charge condition with diagnostic trouble code p0380 p0621. *sc | 11/04/2004 | |
3107 | 01/01/2004 | 10010197 | P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc | 11/04/2004 | |
3160 | 01/01/2004 | 10010041 | Gas engines exhaust buzz or rattle noise. *tc | 11/03/2004 | |
3121 | 01/01/2004 | 10010056 | Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc | 11/03/2004 | |
3100 | 01/01/2004 | 3100A | 10009998 | Low power service engine soon/malfunction indicator light on diagnostic trouble code p0116 and p0299. *sc | 11/03/2004 |
3147 | 01/01/2004 | 10009957 | Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc | 11/02/2004 | |
3109 | 01/01/2004 | 10009948 | Engineering is investigating the 04 6.6l lb7 injectors for concerns of dtc p1093 and high return line flow rates. *sc | 11/02/2004 | |
02092 | 01/01/2004 | 10007754 | Gurgle noise may be heard from the engine coolant compartment on trucks built with rpo hp2 parallel hybrid system. *tt | 07/09/2004 | |
02055 | 01/01/2004 | 10007743 | Engine oil in the turbo charge air cooler pipes and hoses. *tt | 07/09/2004 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
3121 | 01/01/2004 | 10010248 | Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc | 11/08/2004 | |
3072 | 01/01/2004 | 10009622 | The engine coolant temperature or intake air temperature sensor may read -40 degrees when monitored with tech 2. *tt | 10/13/2004 | |
02013 | 01/01/2004 | 02013A | 10007119 | Coolant leak from head cup plugs on gen iii engines. *mr | 05/26/2004 |
10012003 | 10/01/2003 | 10006572 | Blueheat coolant heater thermo top c. webasto. *mr | 05/06/2004 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
01339 | 11/18/2003 | 10004110 | Hvac blower motor fan stays on in the high blower position. service vme. *tt | 11/18/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIP-4851 | 12/01/2010 | PIP-4851A | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm updated 5/31/11. *pe | 05/24/2011 |
PIP-4851 | 11/01/2010 | 10037492 | Ready | 05/24/2011 | |
PIP-4851 | 11/01/2010 | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm | 05/24/2011 | |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
4231 | 10021021 | Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb | 02/22/2007 | ||
030693001 | 05/01/2006 | 030693001C | 10020839 | Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb | 01/24/2007 |
060604026 | 12/01/2006 | 060604026A | 10020835 | Intermittent ses/mil lamp illuminated, reduced engine power, fuel injector driver circuit. dtc's p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208. cylinder bank shut down dtc's p2146, or p2149. *kb | 01/24/2007 |
050604077 | 12/01/2005 | 10019582 | Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak | 03/30/2006 | |
060601003 | 01/01/2006 | 10019474 | Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt | 03/15/2006 | |
3691B | 10019426 | Generation iii v8 engine piston repairs. *tt | 03/14/2006 | ||
050604063 | 10/01/2005 | 10017760 | Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement. *tt | 11/29/2005 | |
050601014 | 05/01/2005 | 10017409 | Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt | 11/07/2005 | |
05-06-04-047 | 04/01/2008 | 050604047C | 10017389 | Service engine soon (ses) light on with reduction in engine power, diagnostic trouble codes p0202 and p2146 or p0207 and p2149 set. *tt add dtc p1294. install revised 90 degree injector connector with harness support bracket servi | 11/04/2005 |
050604029 | 06/01/2005 | 050604029A | 10017336 | Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300. *tt | 11/03/2005 |
050604008 | 04/01/2005 | 050604008A | 10017337 | Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt | 11/03/2005 |
3343 | 10017229 | Engine oil dipstick unseated or oil leak. *tt | 10/28/2005 | ||
3322 | 10017196 | Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161. *tt | 10/27/2005 | ||
3048A | 10017154 | Supplement to 03-06-01-024b 4.3l lu3 l35 timing chain tensioner. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. *tt | 10/26/2005 | ||
3267 | 10017155 | Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc | 10/26/2005 | ||
3258 | 10017160 | 6.6l lly engine oil leak at rear housing cover bolt. *tt | 10/26/2005 | ||
3394 | 3394D | 10017120 | 6.6 lly injector driver codes. misfire, rough running, and the mil/ses light on. *sc | 10/25/2005 | |
3556 | 10016942 | Hard start or extended crank time on initial cold start when using alcohol blended fuels. *sc | 10/18/2005 | ||
702 | 02/01/2005 | 10016371 | Duramax air filter. gm tech links. *tt | 09/09/2005 | |
3346 | 3346A | 10014804 | There has been a high percentage of no trouble found (ntf) 6.6 lly engine control modules (ecms) being returned to the warranty parts center. the no trouble found (ntf) ecms are being replaced for a specific list of diagnostic trouble code | 05/10/2005 | |
3232 | 3232A | 10014870 | 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt | 05/10/2005 | |
3282 | 3282B | 10013504 | Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt | 04/20/2005 | |
040604070 | 08/01/2005 | 040604070A | 10012715 | Information on the revised fuel filter for the 6.6l duramax diesel. *tt | 03/11/2005 |
040604043 | 06/01/2004 | 10012163 | Unable to reset engine oil life monitor. *tt | 02/16/2005 | |
040601020 | 06/01/2004 | 10012146 | Engine oil leak near oil filter. *tt | 02/15/2005 | |
040604007E | 10/01/2005 | 040604007F | 10012150 | Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt | 02/15/2005 |
040601018 | 06/01/2004 | 10012143 | Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt | 02/15/2005 | |
040602006 | 06/01/2005 | 040602006A | 10011206 | Engine overheating. *tt | 01/10/2005 |
040604001 | 12/01/2006 | 040604001C | 10011126 | Various intermittent driveability conditions - hesitation, lack of power, etc. *tt | 01/03/2005 |
3056 | 10010364 | Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt | 11/17/2004 | ||
3038 | 01/01/2004 | 10009648 | Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt | 10/14/2004 | |
3055 | 01/01/2004 | 10009666 | Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt | 10/14/2004 | |
3022A | 01/01/2004 | 10009617 | 04 full size trucks and utilities with vin g, n, t, v and u engines may have a high altitude, high ambient temperature stall. *tt | 10/13/2004 | |
3087 | 01/01/2004 | 10009513 | Crank no start with no cranking rpm spark or injector pulse. *tt | 10/04/2004 | |
3086 | 01/01/2004 | 10009512 | Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt | 10/04/2004 | |
3004 | 01/01/2004 | 10008891 | 4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj | 08/25/2004 | |
3025 | 01/01/2004 | 10008832 | 04 model year 4.8.5.3.7.6.0 gen iii engine piston pin information. *mj | 08/24/2004 | |
3018 | 01/01/2004 | 10008804 | Engine cylinder head cup plug coolant leak. *mj | 08/23/2004 | |
3011 | 01/01/2004 | 3011A | 10008780 | Repeat engine oil leak at main bearing side bolt. *tt | 08/23/2004 |
1530076 | 01/01/2004 | 10008787 | Vehicles and hummer h2 with a high altitude stall. *mj | 08/23/2004 | |
3015 | 01/01/2004 | 10008781 | 6.0l lq4 vin u engine restriction. *tt | 08/23/2004 | |
040604007 | 10/01/2006 | 040604007G | 10008460 | Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt | 08/02/2004 |
01353 | 01/01/2004 | 01353A | 10007937 | Engine misfire due to injector fretting corrosion. *tt | 07/16/2004 |
00872A | 01/01/2004 | 10007916 | Oil pan or oil cooler line leak on gen iii v-8 engines equipped with an oil cooler. *tt | 07/15/2004 | |
02051 | 01/01/2004 | 10007737 | Intermittent service engine soon (ses) light comes on and code p0700 along with diagnostic trouble code p0742 stored. *tt | 07/09/2004 | |
01586 | 01/01/2004 | 01586A | 10007668 | 8.1l changes in heads, bolts and gasket for for 2004 1/2 engines. various models including the chevrolet and gmc 2500hd/3500 my2001-2004 and 2001, 2002, and 2003 gmt 560. *mj | 07/07/2004 |
00266 | 01/01/2004 | 00266A | 10007596 | Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt | 07/02/2004 |
01119A | 01/01/2004 | 01119B | 10007576 | Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt | 07/01/2004 |
00700A | 01/01/2004 | 00700B | 10007584 | 4.3l l35 engine wide open throttle diagnostic trouble code (dtc) p0335, p0336, p0339. *tt *mj | 07/01/2004 |
01972 | 01/01/2004 | 01972B | 10007581 | Erratic oil pressure gmt 610 or gmt800 with codes p0522 or p0523. *tt 01972a replaced and updated 01/01/04. *sc | 07/01/2004 |
01845 | 01/01/2004 | 01845A | 10007566 | Normal engine operating noise characteristics. *tt | 07/01/2004 |
00609B | 01/01/2004 | 00609C | 10007527 | Low power, will not go over 2300 rpms. 6.6l lb7 engine. *tt | 06/30/2004 |
00764B | 01/01/2004 | 10007271 | 6.6l diesel engine rough idle, clatter, stall and/or diagnostic trouble code (dtc) p1223. *tt | 06/09/2004 | |
01485B | 01/01/2004 | 01485C | 10007272 | Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt | 06/09/2004 |
00678B | 01/01/2004 | 00678C | 10007286 | Engine overheats on vehicles equipped with rpo vyu snowplow prep package. *tt | 06/09/2004 |
01619 | 01/01/2004 | 10007183 | 6.6 lly engine glow plugs are not interchangeable with the current 6.6 lb7 glow plugs.*mr | 06/03/2004 | |
02029 | 01/01/2004 | 10006934 | Inaccurate fuel gauge readings and/or engine stall. *mr | 05/19/2004 | |
01939 | 01/01/2004 | 10006565 | 4.3 4.8 5.3 6.0 lr4 lu3 lm7 l59 lq4 lq9 engines- evap code p0442. *mr | 05/06/2004 | |
01701 | 01/01/2004 | 10006395 | 4.8 5.3 lm4 lm7 lr4 engine - with o2 sensor codes p0135, p0141, p0155, p0161. sit bulletin 1452753. *tt | 04/30/2004 | |
01774 | 01/01/2004 | 10006256 | 6.6l lb7 repeat engine oil leak (left side) #2 main bearing cross bolt. *mr | 04/27/2004 | |
01485 | 01/01/2004 | 10005500 | Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt | 03/01/2004 | |
01499 | 01/01/2004 | 10005481 | 2004 6.6l duramax lb7 engines with extended crank during hot engine restart. diagnostic trouble code (dtc) p0193 may or may not be set. sit bulletin 1402202. *tt | 03/01/2004 | |
01485A | 01/01/2004 | 10005445 | Timing chain tensioner breakpoints for service kit or production fix for vehicle exhibiting rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. sit bulletin 1408407. *tt | 02/27/2004 | |
100903 | 10/09/2003 | 10004986 | Duramax diesel fuel in oil diagnostics revisited. gm voicemail log. this includes c4500 and 5500 trucks. *tt | 01/22/2004 | |
100803 | 10/08/2003 | 10004982 | The engine diagnostic fuel leaks inside of the engine. gm voicemail log. this includes 2000 - 2004 chevroand gmc c4500 and 5500 trucks. *tt | 01/22/2004 | |
020601022C | 01/01/2005 | 020601022D | 10004742 | Information on engine ticking. including 2004 chevrolet kodiak c45/c5500 series and 2004 gmc topkick c4500/c5500 series. *tt update. *tt | 01/05/2004 |
030604060 | 10/01/2003 | 10004733 | Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt | 01/02/2004 | |
030603007 | 08/01/2003 | 10004372 | Availability of starter motor solenoid if damaged during service. 2004 chevrolet kodiak c4500/5500 and gmc topkick c4500/5500 included. *tt | 12/04/2003 | |
030601023 | 08/01/2003 | 10004370 | Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt | 12/04/2003 | |
030603008 | 09/01/2003 | 10004373 | Avoiding oil level sensor harness damage during lower oil pan installation. *tt | 12/04/2003 | |
030604054 | 10/01/2003 | 10004316 | Revised fuel injector balance test with tech 2 (automatic transmission). various models including 2003-2004 chevrolet kodiak and gmc topkick. *tt | 12/02/2003 | |
030604053 | 10/01/2003 | 10004315 | Revised fuel injector balance test with tech 2 (manual transmission). *tt | 12/02/2003 | |
030603001A | 10/01/2003 | 030603001 | 10004304 | Starter cranks after key is released (normal condition). *tt | 12/01/2003 |
030604045 | 10/01/2003 | 10004306 | Revised diagnostic trouble code (dtc) p0093 or dtc p1093 diagnostic tables. *tt | 12/01/2003 | |
030604046 | 10/01/2003 | 10004307 | Revised engine cranks but does not run diagnostic. *tt | 12/01/2003 | |
01275C | 11/18/2003 | 10004189 | Some owners of 03 g-vans or 04 c/k trucks driving at high altitude with warm ambient temperatures may complain of a stall and or lack of power or running rough condition until the vehicle cools down. *tt | 11/21/2003 | |
00634A | 11/18/2003 | 10004162 | Gen iii engine noise after hot soak restart. *tt | 11/20/2003 | |
030604030 | 03/01/2007 | 030604030C | 10002166 | Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 08/14/2003 |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
PIP-3504C | 11/01/2010 | 10037516 | Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm | 05/25/2011 | |
PIP-3504C | 11/01/2010 | 10037516 | Ready | 05/25/2011 | |
PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
07057 | 02/01/2008 | 10024154 | Special coverage adjustment - engine glow plug on certain vehicles with 6.6l diesel v8 (rpo lb7 - vin 1) engine & california emissions (yf5/ne1) or clean fuel emissions (vcl). csc was received. *nj | 03/13/2008 | |
070601009 | 05/01/2007 | 10021839 | Diesel engine cylinder head gasket missing thickness grade markings. *kb | 06/22/2007 | |
3328B | 3328C | 10017202 | Engine rpm surge at 1100 to 1400 rpm. this condition may be noticed more when towing. *tt | 10/27/2005 | |
3314 | 10017211 | Duramax diesel engine hard start, no start, stall of diagnostic trouble code p0093, p1093. *tt | 10/27/2005 | ||
3225A | 10017137 | 01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc | 10/25/2005 | ||
3504 | 3504A | 10016491 | Hard start hot only after the engine has reached operating temperature and then shut off. *tt | 09/14/2005 | |
00968A | 01/01/2004 | 00968B | 10007534 | 6.6l lb7 lly diesel engine with rough, unstable, low idle speed or stall. *tt | 06/30/2004 |
01512 | 01/01/2004 | 10005462 | 6.6 liter duramax diesel engine fuel knock noise. various models including the 2004 gmc c4500 and c5500. sit bulletin 1406247. *tt | 02/27/2004 | |
030693001A | 08/01/2005 | 030693001B | 10004319 | Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt | 12/02/2003 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
3048 | 01/01/2004 | 10009391 | Timing chain tensioner breakpoints for service kit or production kit. supplement to 03-06-01-024b. *tt | 09/27/2004 | |
01242A | 01/01/2004 | 10006284 | 6.6l lb7 lly diesel engine drive belt chirping on shut down. sit bulletin 1460352. *tt | 04/27/2004 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
3401 | 3401A | 10020072 | Turbocharger oil feed line kinked or restricted. *tt | 07/19/2006 | |
3348 | 3348A | 10014816 | Noise, service engine soon (ses) light, or low power. dealer may find turbine (exhaust side) wheel rub damage, a broken turbine shaft, or turbo bearing concern. *tt | 05/10/2005 | |
10292004 | 10/29/2004 | 10013041 | This is in regards to the unnecessary changing of turbochargers due to oil seepage. *tt | 04/06/2005 | |
3068 | 3068D | 10009606 | Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb | 10/08/2004 | |
01496 | 01/01/2004 | 10005493 | 6.6l lb7 duramax diesel turbocharger noises or fuel economy complaint. service vme. sit bulletin 1401355. *tt | 03/01/2004 | |
100803 | 10/08/2003 | 10004983 | Excessive duramax turbocharger whine noise or possibly a performance or a fuel economy complaint. gm voicemail log. this includes 2003-2004 4500 and 5500 trucks. *tt | 01/22/2004 | |
01400 | 11/18/2003 | 10004204 | 6.6l duramax lb7 engines with turbocharger system whine noise. *tt | 11/21/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
01896 | 3066A | 10006476 | 6.6 lly duramax diesel engine turbocharger learn procedure. *mr | 05/04/2004 | |
001496A | 01/01/2004 | 10005513 | This message is in regard to duramax turbocharger noises or possibly a performance or fuel economy complaint. service vme. 6.6 lb7 diesel engine. p0102, p0103, p0236. *tt | 03/01/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
030605008B | 11/01/2005 | 030605008C | 10005576 | Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt | 03/04/2004 |
01531 | 01/01/2004 | 10005447 | Exhaust moan vibration. sit bulletin 1408514. *tt | 02/27/2004 | |
020605003C | 02/01/2004 | 020605003B | 10002939 | Exhaust moan/vibration. *tt update. *tt | 10/01/2003 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
050604021 | 03/01/2005 | 10015005 | Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt | 05/13/2005 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
3119 | 01/01/2004 | 10010101 | Engineering investigation - catalytic converter replacement. *sc | 11/04/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP3343 | 02/01/2008 | PIP3343A | 10024344 | Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj | 04/07/2008 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
3256A | 10017169 | Vehicle may be brought in for service engine soon (ses) or malfunction indicator lamp (mil) light on. *tt | 10/26/2005 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||
09/01/2010 | 48000 | ||
Tl - the contact owns a 2004 gmc sierra. the contact stated that while driving his vehicle check engine light illuminated and the message reduce engine power appeared causing the vehicle to reduce the speed. the contact stated that this failure happened several times without warning and it was a safety hazard if driving on the highway. the vehicle was not taken to the dealer. the manufacturer was contacted who stated that they were not able to help until the vehicle was inspected. the vehicle was not repaired. the failure mileage was 48,000 and the current mileage was 55,000. pm | |||
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
12/30/2005 | 1 | 09/01/2004 | |
2004 sierra caught on fire due to a malfunction in the truck. *ts *jb | |||
06/13/2005 | 26368 | 1 | 02/23/2004 |
The injectors on my 2004 gmc sierra went out at 26,000 miles. the incident caused me to lose my truck for 4 days. the dealership replaced all 8 injectors. | |||
03/28/2004 | 1660 | 4 | 03/26/2004 |
2004 gmc 2500hd duramax - purchased march 2004. severe, abrupt 'clacking/chatter' coupled with brief, complete loss of power and billows of smoke. has occurred 4 times: 3/28 1660 miles @ 67mph, 5/5 2167 miles @ 70 mph, 5/8 2316 miles @ 60-65 mph, 5/8 2325 miles @ 60-65 mph.*ak |