International Prostar 2007
Model Prostar made in 2007 by International got 3 recalls as well as 44 service bulletins. Technical service bulletines regarding electrical system and engine and engine cooling. There were some recalls concerningelectrical system and fuel system, diesel.
Model 2007
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||||||||||||
| 08V258000 | NAVISTAR, INC | from 11/21/2000 to 05/21/2008 | V (Vehicle) | 51588 | 07/10/2008 | MFR | NAVISTAR, INC | 06/05/2008 | 06/09/2008 | |||||||
| Defect Summary | Navistar is recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. the potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination intrusion. if the encapsulation is compromised, water and contaminants may cause an internal electrical short, possibly resulting in a fire. | |||||||||||||||
| Consequence Summary | A fire could cause personal injury or death. | |||||||||||||||
| Corrective Summary | Navistar will notify owners and repair the vehicles free of charge. the recall began on july 10, 2008. owners may contact navistar at 1-280-461-1890. | |||||||||||||||
| Notes | Navistar recall no. 08505.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
| FUEL SYSTEM, DIESEL | ||||||||||||||||
| 07V180000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | V (Vehicle) | 700 | 05/11/2007 | MFR | NAVISTAR, INC | 04/24/2007 | 04/25/2007 | ||||||||
| Defect Summary | On certain trucks equipped with davco fuel pro 382 heated fuel filters, when the key is in the 'on' position, the pre-heater, located in the fuel filter base, is energized. | |||||||||||||||
| Consequence Summary | If this pre-heater is energized while maintenance is being performed on the fuel filter, diesel fuel could ignite within the filter housing. a fire within the fuel filter housing may spread possibly resulting in property damage or personal injury. | |||||||||||||||
| Corrective Summary | Dealers will inspect the fuel filters and fuel heaters and, if necessary, will replace the fuel heater. the recall began on may 11, 2007. owners may contact international at 1-800-448-7825. | |||||||||||||||
| Notes | International recall no. 07506.customers may contact the national highway traffic safety administration | |||||||||||||||
| SUSPENSION - REAR - AXLE - NON-POWERED AXLE ASSEMBLY | ||||||||||||||||
| 07V179000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 11/15/2006 to 02/19/2007 | V (Vehicle) | 1172 | 05/18/2007 | MFR | NAVISTAR, INC | 04/24/2007 | 04/25/2007 | |||||||
| Defect Summary | On certain trucks, one or both rear axle housings may contain thinner material than what is necessary for normal vehicle operation. over time, this thinner material may result in a fatigue failure of the rear axle housing, possibly in the location of the brake flange. | |||||||||||||||
| Consequence Summary | A crack in the brake flange location of the rear axle housing may result in a wheel end lockup or wheel separation possibly resulting in property damage, personal injury, or death. | |||||||||||||||
| Corrective Summary | Dealers will inspect the vehicle's rear axles and, if necessary, replace the axle housings. the recall began on may 18, 2007. owners may contact international at 1-800-448-7815. | |||||||||||||||
| Notes | International recall no. 07505.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| SB-IK-0800293-2 | 08/04/2011 | 10041397 | Ready | 09/28/2011 | |
| SB-IK-0800293-2 | 08/04/2011 | 10041397 | Navistar: troubleshooting for intermittent or no front blower operation. *rm | 09/28/2011 | |
| IK-0800194 | 09/22/2009 | 10032124 | International truck: intermittent or no front blower operation. outlines the process for troubleshooting the front blower on prostar, lonestar, durastar, transtar, and workstar models. no model years listed. *pe | 02/12/2010 | |
| IK0800131 | 03/12/2008 | 10025548 | Lose all of gauges when hooked up with dlb. applies to all vehicles with esc's or bc's. *pe | 08/19/2008 | |
| IK0800130 | 04/03/2008 | 10024783 | International - air pressure gauges & a/c pressure transducer troubleshooting on post-2007 hpv and prostar. *nj | 05/20/2008 | |
| ELECTRICAL SYSTEM - BATTERY - CABLES | |||||
| IK-0800382 | 08/06/2012 | 10045780 | International: battery cables routed too close to spring hanger shackle bolt for left-sided battery box or 8600 boc battery box. model pro-star113 garland built. no model years listed. *pe | 09/17/2012 | |
| IK-0800383 | 08/06/2012 | 10045781 | International: spring hanger shackle bolt may have battery cables routed too close for left sided battery box or 8600 lsm boc battery box for excobedo built prostar 113. no model years listed. *pe | 09/17/2012 | |
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||||
| IK-0800334 | 02/13/2012 | 10043568 | Incorrect 5amp fuse at location f11-d on wabco 6 sensor 6 modulater. *kb | 04/11/2012 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| SB-IK-0800293-2 | 08/04/2011 | 10041397 | Navistar: troubleshooting for intermittent or no front blower operation. *rm | 09/28/2011 | |
| SB-IK-0800293-2 | 08/04/2011 | 10041397 | Ready | 09/28/2011 | |
| ENGINE AND ENGINE COOLING | |||||
| AFC-12902 | 01/01/2012 | 10043556 | Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights. *kb | 04/10/2012 | |
| AFC-11929 | 02/01/2012 | 10043554 | Navistar: hvac front inside module drain repair. *kb | 04/10/2012 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
| IK0900075 | 12/10/2012 | 10049579 | Iknow: stratis fan hub diagnostics. horton 12 thx vmaster ultra (stratis) viscous fan drive troubleshooting guide. *js | 01/16/2013 | |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| AFC-10910 | 10/01/2010 | 10037211 | Navistar: some engines may experience engine over-heating due to the fan clutch not actuating. *rm | 05/11/2011 | |
| AFC-10910 | 11/01/2010 | AFC-G-10910 | 10037211 | Navistar: some engines may experience engine over-heating due to the fan clutch not actuating. *rm updated 5/23/11. *pe | 05/11/2011 |
| AFC-10910 | 10/01/2010 | 10037211 | Ready | 05/11/2011 | |
| IK-1900136 | 09/10/2010 | 10036654 | Navistar int'l: developed in response to reports of intermittent or inoperable front blower motors on prostar and lonestar models built 12/10/07-12/04/09. provides general troubleshoooting procedure for the hvac blower circuit that can be | 04/06/2011 | |
| IK-1200431 | 01/18/2010 | 10033554 | Navistar: cummins air temperature sensor located rear of vehicle, instead of front, on some models. this can be mistaken for a ground connector. do not bolt this sensor to ground. should remain strapped to harness. *pe | 08/23/2010 | |
| AFC-09908 | 10/01/2009 | 10032639 | Navistar: implementation of engine recalibration. this will require the recalibration of the engine ecm. in cold weather conditions, the software upgrade will ensure proper lubrication of the turbocharger by delaying accelerator pedal res | 04/21/2010 | |
| IK-0300023 | 06/01/2009 | 10030566 | International: lower front shock mount bending on prostar s models (113 bbc) w/all engines and prostar models (122 bbc) w/caterpillar c15 engines. prostar models with caterpillar c15 engines will only have the issue on the right side. | 10/21/2009 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| IK-0700047 | 07/06/2012 | 10045160 | International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is loose or backed out, due to possible wear and needs to be replaced, if necessary. *pe | 08/21/2012 | |
| EQUIPMENT - ELECTRICAL | |||||
| IK-0800194 | 09/22/2009 | 10032124 | International truck: intermittent or no front blower operation. outlines the process for troubleshooting the front blower on prostar, lonestar, durastar, transtar, and workstar models. no model years listed. *pe | 02/12/2010 | |
| FUEL SYSTEM, DIESEL | |||||
| IK-1500067 | 08/30/2012 | 10045820 | International: information regarding the fuel system components and repairs to correct interference to avoid fuel line contact wear. model prostar. no model years listed. *pe | 09/17/2012 | |
| FUEL SYSTEM, GASOLINE - STORAGE - AUXILLARY TANK - SELECTOR DEVICES | |||||
| IK-1500035 | 09/22/2011 | 10042644 | Navistar: trucks equipped with electric fuel transfer pump for two tanks, the fuel is balance between both tanks. the engine is supplied fuel directly from the draw tank. hpv, ngv and prostar. *pe | 01/04/2012 | |
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||||
| IK 1500040 | 07/15/2008 | 10025943 | International: three inch fuel tank fill cap gasket cracking. applies to heavy duty models. some of the three inch fuel fill cap gaskets have been cracking. used primarily on heavy duty vehicles like 5000, 8000, 9000 and prostar. *pe | 09/17/2008 | |
| FUEL SYSTEM, OTHER - DELIVERY - FUEL PUMP | |||||
| IK-1500067 | 08/30/2012 | 10045820 | International: information regarding the fuel system components and repairs to correct interference to avoid fuel line contact wear. model prostar. no model years listed. *pe | 09/17/2012 | |
| IK-1500035 | 09/22/2011 | 10042644 | Navistar: trucks equipped with electric fuel transfer pump for two tanks, the fuel is balance between both tanks. the engine is supplied fuel directly from the draw tank. hpv, ngv and prostar. *pe | 01/04/2012 | |
| FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||||
| IK-1500067 | 08/30/2012 | 10045820 | International: information regarding the fuel system components and repairs to correct interference to avoid fuel line contact wear. model prostar. no model years listed. *pe | 09/17/2012 | |
| POWER TRAIN - DRIVELINE - UNIVERSAL JOINT | |||||
| TSI-08-05-02 | 09/01/2008 | 10027544 | Navistar: power steering intermediate shaft u joint end play measurement. *pe | 01/26/2009 | |
| (PWS) | |||||
| IK-0700047 | 07/06/2012 | 10045160 | International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is loose or backed out, due to possible wear and needs to be replaced, if necessary. *pe | 08/21/2012 | |
| SERVICE BRAKES, AIR | |||||
| IK-0400057 | 07/21/2011 | 10040739 | Navistar: the brake lights stay on and are not working. there are problems with voltage. *rm | 09/12/2011 | |
| IK-0400057 | 07/21/2011 | 10040739 | Ready | 09/12/2011 | |
| SERVICE BRAKES, AIR - ANTILOCK | |||||
| IK-0400087 | 10/05/2011 | 10041995 | Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical. *pe | 11/21/2011 | |
| IK-0400087 | 05/01/2012 | IK-0400087 | 10041995 | Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical. *pe updated 4/9/12. *js | 11/21/2011 |
| SERVICE BRAKES, AIR - ANTILOCK - ABS WARNING LIGHT | |||||
| IK-0800158 | 06/03/2009 | 10030567 | International: icon will not function properly. abs lights come on when icon starts or stops. unit shuts down before icon parameter is reached. if you have more than one hour in troubleshooting and do not have a good direction to follow | 10/21/2009 | |
| SERVICE BRAKES, HYDRAULIC - PEDALS AND LINKAGES | |||||
| SB-IK-0400063 | 09/15/2009 | 10030832 | International: brake pedal not returning and sticking slightly in the applied position. brake pedal not returning and binding. brake light staying on. model prostar, no model years listed. *pe update 02/17/10. *pe | 12/08/2009 | |
| STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | |||||
| IK-0500043 | 08/06/2012 | 10045760 | International: information being provided regarding the rusting of power steering hoses that needs to be removed and replaced. model prostar. no model years listed. *pe | 09/17/2012 | |
| TSI-08-05-01 | 07/01/2008 | 10025945 | Navistar: prostar power steering cooler hoses. *pe | 09/17/2008 | |
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||||
| TSI-08-05-02 | 09/01/2008 | 10027544 | Navistar: power steering intermediate shaft u joint end play measurement. *pe | 01/26/2009 | |
| STRUCTURE | |||||
| IK1600170 | 12/14/2012 | 10049639 | Iknow: sleeper side sill/underbody cross-member weld check and repair. the welds described herein are neither durability nor safety critical welds. *js | 01/17/2013 | |
| STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||||
| IK1600170 | 12/14/2012 | 10049639 | Iknow: sleeper side sill/underbody cross-member weld check and repair. the welds described herein are neither durability nor safety critical welds. *js | 01/17/2013 | |
| SUSPENSION - MULTIPLE AXLE - TORQUE ARM | |||||
| AFC-08914 | 02/01/2009 | 10028726 | Navistar: mislocated torque rod bracket on certain prostar and 9000 models. requires an inspection to determine if the torque rod bracket was mislocated on dana 40k and 46k tandem axles. model years unknown. *pe | 05/20/2009 | |
| SUSPENSION - REAR - SPRINGS - AIR SUSPENSION SYSTEM | |||||
| IK-0400087 | 05/01/2012 | IK-0400087 | 10041995 | Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical. *pe updated 4/9/12. *js | 11/21/2011 |
| IK-0400087 | 10/05/2011 | 10041995 | Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical. *pe | 11/21/2011 | |