Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | ||||||||||||||||
94V106000 | CHRYSLER CORPORATION | from 02/01/1986 to 08/01/1993 | V (Vehicle) | 230000 | 01/03/1995 | ODI | CHRYSLER GROUP LLC | 06/09/1994 | 06/22/1994 | |||||||
Defect Summary | Vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks. | |||||||||||||||
Consequence Summary | Fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition. | |||||||||||||||
Corrective Summary | Replace the fuel tank sending unit gasket. | |||||||||||||||
Notes | If your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and free of charge or the remedy does not correct the defect or noncompliance, please contact chrysler service center at 1-800-853-1403. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
07E064000 | FEDERAL-MOGUL CORPORATION | E (Equipment) | 34000 | 10/15/2007 | MFR | CHRYSLER GROUP LLC | 08/27/2007 | 08/24/2007 | ||||||||
Defect Summary | Certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. the fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak. | |||||||||||||||
Consequence Summary | A leaking fuel pump could create a vehicle fire hazard. | |||||||||||||||
Corrective Summary | Federal-mogul will notify owners and replace the defective fuel pumps free of charge. the recall began on october 15, 2007. owners can contact federal-mogul at 248-354-7700. | |||||||||||||||
Notes | This recall only pertains to aftermarket carter, napa, accuflow, tru flow, parts master, and parts depot brand fuel pumps and has no relation to any original equipment installed on the listed motor vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | ||||||
RQ97016 | CHRYSLER GROUP LLC | 10/27/1997 | 06/30/1998 | FUEL LEAKAGE | 94V106000 | |
Odi has received 6 reports on fuel leakage and 3 reports on alleged remedy failure reports |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
10/14/1994 | 4 | ||
Gasoline ignited at carburator. *aw | |||
01/13/1995 | 3 | ||
Carburetor rebuilt. | |||
12/05/1994 | 3 | ||
Replaced carburator 3 times. | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
08/01/1998 | |||
Jeep caught fire, assuming from fuel lines directly on top of exhaust manifold designed by chrysler | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
12/25/1997 | 1 | 02/12/1997 | |
Fuel pump leak caused fire. | |||
10/27/1997 | |||
Received recall notice (#94v106000) & contacted the dealer for an appointment. took vehicle to dealer & after arriving, was informed could not repair due to not having the parts readily available. *ak | |||
10/27/1997 | |||
Received recall notice (#94v106000). called dealer & took vehicle in on the appointed date. was informed could not repair vehicle due to not having the parts readily available. *ak | |||
10/30/1995 | 0 | ||
Fuel pump caught fire(recall 94v106000). *sd | |||
03/23/1995 | 1 | ||
Fuel pump failed prior to recall, recall repairs refused due to schedule (94v-106). *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
04/02/1996 | |||
Under the hood fire, due to corrosion of fuel line. *ak | |||
FUEL SYSTEM, GASOLINE - STORAGE | |||
04/10/1995 | 0 | ||
Recall repairs refused because of after-market hitch installed on vehicle. (90v168) *tw | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
12/16/1996 | 1 | ||
Fuel tank is cracked, causing gas to leak. | |||
1 | 11/01/1986 | ||
Gas smell after filling tank. | |||
1 | |||
Gas tank caught on fire. burned hole in gas tank all gas leaked on ground. tt at first the gas was leaking from the top of the tank to a hot exhaust pipe and started fire. *yh | |||
FUEL SYSTEM, OTHER | |||
01/10/1998 | |||
While starting the vehicle up, the gas gauge indicates that there is a full tank of gas in the vehicle. but when driving about a mile, the gas gauge will show that there is only a 1/2 of tank. contacted dealer and can't found the problem. *ak | |||
FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
07/29/1995 | 1 | ||
Possible fuel line leakage resulted in a fire under the hood. |