Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 070397 | 05/09/1997 | 07-05-93 | 6088786 | Concerns with engine coolant usage. *nlm | 01/07/2000 |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 070397 | 05/09/1997 | 52963 | Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of ethylene glycol. *yc | 11/13/1997 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 091993 | 11/01/1993 | 39528 | New coated pistons. *tw | 11/01/1995 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
| 110798 | 12/11/1998 | 603108 | Outer exhaust manifold studs may fatigue/break. *ak | 02/02/1999 | |
| 110798 | 07/31/1998 | 602327 | The outer exhaust manifold studs may fatigue and break. *yc | 10/26/1998 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||
| Vehicle has been taken to dealership due problem with gasket. this vehicle is outside of the remedy scope and is not included in nhtsa recall campaign 94v106000 fuel pump. please describe details. mr | |||
| 12/01/2001 | 1 | 09/01/1993 | |
| I was pulling out of a parking lot onto a main road, i was in 1st gear (manual shift) shifting into second gear when all of a sudden a a bearing or pushrod shot thru the oil pan, with no warning. there was nothing seemingly wrong with the vehicle, it is out of warranty by years, but has very low miles. it was maticulously maintained. oil was changed in the vehicle every 3000 miles. the only problem we had with the vehicle since we bought it, was a rear main seal leak. it was fixed under warranty at the dealership twice for that. | |||
| 08/01/2000 | 0 | ||
| Sending unit is not installed correctly/gasket is cracked. consumer is having the same problem as mentioned in recall 94v106000, consumer feels if rear ended jeep may blow up because of fuel leaking all over the place.*ak | |||
| 03/26/1998 | 11/03/1997 | ||
| Threw cylinder rod while normal driving on highway. rod tore through bottom of oil pan, almost caused an accident. | |||
| 12/10/1996 | 03/06/1994 | ||
| Engine block explosion sent pieces flying allover vehicle. *ak | |||
| 09/30/1996 | 1 | 09/30/1996 | |
| Gasket replaced due to gas leak. | |||
| 05/21/1996 | |||
| While driving, three motor mount bolts on right side sheared off, causing engine to drop to side of engine compartment; no warning; could have caused accident. | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 06/01/1996 | 06/01/1994 | ||
| I feel wrangler are advertised as rugged - but they are anything but rugged!! lots of trouble. chrysler did nothing to help except offer costly repairs (new seat for $1,200 that was cheaply made, fix door locks for $200 that kept breaking and windows that would not roll up or down easily) that i felt should not have been at my expense. chrysler's answers when i complained were - i used excessive force all the time. the drivers seat broke - first time i reclinded it. after tearing it apart - it was obviously made very cheaply - one thin metal part going up the back of the seat. how is that going to hold anyone in case of rear impact or reclining the seat without breaking?? same with the plastic parts for the window roller (easily breakable) and who designed the stupid part (bar and pin) for the door locks. oh yeah, and my engined died once - $200 in new wiring and toe bills. they told me i must have been offroad ruffing it - excessive force again. i never took the jeep offroad ever - but of course they would not believe me. also, i have replaced the front windshield 3 times now. my main point is chrysler failed me - sold me a very cheaply made vehicle and did not stand behind their cheap product. i fell i am the best or worse advertiser for this vehicle they have and i make sure to fully explain all the problems i have experienced with my wrangler. | |||
| While driving vehicle in the rain engine blew out, throwing a rod through oil pan. dealer noted cause of problem was rain in engine. | |||
| 12/10/1996 | 1 | 03/06/1994 | |
| The engine block exploded sending pieces flying. | |||
| 01/03/1995 | 1 | ||
| Vehicle fire. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 08/01/2000 | |||
| Catalytic converter rattles loudly. noise is intermittent, independent of speed, engine temp or if transmission engaged. dt | |||
| 06/30/1998 | 04/01/1994 | ||
| No summary listed for this vehicle. *ak | |||
| 02/25/1999 | 3 | 01/01/1994 | |
| Exhaust manifold leaks after bolts break off, cat. converter failure seems to occur at start up of vehicle | |||
| 1 | 01/01/1998 | ||
| No summary from consumer. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 02/10/2003 | 1 | ||
| The catalytic converter needed to be replaced.*jb | |||
| 12/26/2000 | 0 | ||
| When starting car it rattles very badly, and consumer can smell exhaust fumes. took to mechanic, and they said it was catalytic converter.-*ak | |||
| 4 | 12/01/1994 | ||
| I've had to change the catalytic converter 4 times already and going on number 5. i've been told by friends , and i agree this is not normal for this age of vehicle. i just wanted to report it and to see if there was anything that could be done. *ak | |||
| 07/01/1996 | 3 | 05/01/1994 | |
| Exhaust manifold - rear stud on driver's side has broken off leading to an exhaust leak. causes noise and excess o2 in exhaust system signal computer to increase fuel richness which taxes the catalytic converter, causing early failure. catalytic conveter has been replaced three times as result. door locks - the door locks on both the passenger and driver side have broken, making it impossible to unlock door from outside with key. by turning key, the lock begins to disengage, but not enough to unlock door. this creates need to leave windows down continuously in order to gain access to vehicle by opening door from inside through window. major security issue! | |||
| 07/01/1996 | 3 | 05/01/1994 | |
| Exhaust manifold - rear stud on driver's side has broken off leading to an exhaust leak. causes noise and excess o2 in exhaust system signal computer to increase fuel richness which taxes the catalytic converter, causing early failure. catalytic conveter has been replaced three times as result. door locks - the door locks on both the passenger and driver side have broken, making it impossible to unlock door from outside with key. by turning key, the lock begins to disengage, but not enough to unlock door. this creates need to leave windows down continuously in order to gain access to vehicle by opening door from inside through window. major security issue! *ak | |||
| 01/31/1996 | 02/01/1994 | ||
| According to this site, the 1994 jeep wrangler had a recall of the catalytic converter. beginning 31jan96, i took my jeep to shelby motors aprox 7 times because of rattling noise with the same response from them we don't know what it is. now there is no longer a warranty on my vehicle, shelby motors declares the vehicle needs a new catalytic converter absolving themselves of any responsibility. i appealed to their sense of professionalism and loyalty to their customers, but found their interest doesn't lie in the customer's loyalty to them but rather in their money. i have never been notified by chrysler corporation or shelby motors of any recall. any assistance you can provide would be greatly appreciated given i've been struggling with this for 4 years. | |||
| 02/25/1999 | 3 | 01/01/1994 | |
| Exhaust manifold leaks after bolts break off, cat. converter failure seems to occur at start up of vehicle | |||
| 4 | 06/30/1994 | ||
| Catalytic converters have failed several times. | |||
| 02/21/1997 | |||
| Brushed and got caught under the catalytic converter, the catalytic converter caught on fire and burned all wires under the vehicle/the 4 wheel drive systems and the carpet. vehicle was repaired. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 2 | 09/01/1993 | ||
| The exhaust manifold is a welded tubular header. at approximately 50,000 miles the weld at the collector cracks. i don't know if i am at risk of carbon monoxide poisoning because of this failure. this has happened twice now and it is approximately a 600.00 repair. in talking to the repair dept. at a local dealership, this is a fairly common problem. the same problem has occurred twice to my father's 1997 jeep wrangler also.*ak | |||
| 01/02/1999 | |||
| Exhaust manifold cracked, causing fuel to leak out, and creating a potential risk of carbon monoxide poisoning. *ak | |||
| 07/01/1996 | 3 | 05/01/1994 | |
| Exhaust manifold - rear stud on driver's side has broken off leading to an exhaust leak. causes noise and excess o2 in exhaust system signal computer to increase fuel richness which taxes the catalytic converter, causing early failure. catalytic conveter has been replaced three times as result. door locks - the door locks on both the passenger and driver side have broken, making it impossible to unlock door from outside with key. by turning key, the lock begins to disengage, but not enough to unlock door. this creates need to leave windows down continuously in order to gain access to vehicle by opening door from inside through window. major security issue! | |||
| 07/01/1996 | 3 | 05/01/1994 | |
| Exhaust manifold - rear stud on driver's side has broken off leading to an exhaust leak. causes noise and excess o2 in exhaust system signal computer to increase fuel richness which taxes the catalytic converter, causing early failure. catalytic conveter has been replaced three times as result. door locks - the door locks on both the passenger and driver side have broken, making it impossible to unlock door from outside with key. by turning key, the lock begins to disengage, but not enough to unlock door. this creates need to leave windows down continuously in order to gain access to vehicle by opening door from inside through window. major security issue! *ak | |||