Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 0901004 | 10/01/2004 | 0901004A | 10006452 | Dirt and debris accumulation at rear main seal. *tt | 05/03/2004 |
| 0900704 | 03/02/2004 | 10006455 | Irregular engine snapping sound. *tt | 05/03/2004 | |
| 1803103 | 09/05/2003 | 1802702 | 10003986 | 4.0l rough engine idle after restart following a hot soak. *tt | 11/10/2003 |
| 0900303 | 08/01/2003 | 10003538 | 4.0l multiple cylinder misfire. *tt | 10/23/2003 | |
| 02023 | 12/06/2002 | 10000832 | 4.0l crankshaft burr. *tt | 04/01/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 08/16/2007 | 24000 | ||
| Tl*the contact owns a 2003 jeep wrangler. while driving 55 mph, the crankshaft position sensor failed and the check engine light continued to illuminate. the contact took the vehicle to the dealer and they confirmed that the sensor malfunctioned. he discovered a recall for the same exact failure with the 2004 jeep wrangler. the manufacturer stated that the failure was not under warranty and would not be covered, although he had a current 7-year powertrain warranty. the current and failure mileages were approximately 24,000. | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| 04/12/2003 | 6200 | 7 | 09/30/2002 |
| According to internal sales brochures and advertisements the 2003 jeep wrangler rubicon is supposed to be the most capable off road jeep ever. my jeep has been nothing but problems, which consists of 2 broken axles, faulty brakes, faulty parking brake, faulty u-joint clips, faulty wheel bearing. after paying the dealer to replace parts that should have been covered under warranty, then realizing that they failed to replace another failed part, called to ask about a workaround until the needed part came in. the advice given was to remove the broken axle shaft and drive without it. this caused brake and wheel bearing failure. an attempt to get the dealer to take responsibility for the repair cost took some time to get resolved. finally, they fixed the problems and voided the manufacture's warranty. reason for voiding the warranty was misuse/abuse because the vehicle had been used off-road and had mud on the under carriage. this is unacceptable because you cannot market a vehicle as off-road and then void the warranty if it is used in this manner. the vehicle was never submerged, or in mud/water deeper then the height of the bottom of the front bumper. furthermore, jeep claims i am a member of a 4wd club that i have no affiliation with and claims a witness saw the vehicle under water. both not true. asking for help from the dot to make jeep stand by it's warranty, or have them not market the vehicle as off-road since if using it off road voids the warranty then this is false advertising. *la | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
| 4182 | 1 | ||
| When traveling at 55 to 60 mph vehicle cut off without warning. vehicle would restart after few minutes. dealer had been contacted. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 11/14/2009 | 77200 | 1 | |
| Traveling at 60-65mph vehicle cut off without warning. no lights on dash came on. pulled out of way of other traffic and came to a complete stop. tried starting and started right up. mileage 77,200. *tr | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 12/11/2003 | 1 | ||
| Paint peeling off of fenders and on the hindges of the hard top and doors. there is a constant ticking, rattle sound coming from the engine. i have driven with the head mechanic,and the dept. manager. they both have heard the sound. the jeep has been in the shop 9 times and the problem still exhists. i have loss confidence in the local dealership's service dept.*ak | |||