Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STEERING | |||||
| TSB-019 | 10/01/2008 | 10027724 | Kia: increased steering effort. in areas where heavy road salt use occurs, increased steering effort and noise (from steering intermediate shaft) for some sedona. *pe | 02/02/2009 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STEERING | |||
| 10/01/2010 | |||
| Continual power steering leak for over a year now; finally diagnosed with rack/pinion dysfunction. | |||
| 12/04/2009 | 71000 | ||
| Tl*the contact owns a 2005 kia sedona. while the contact was driving approximately 5 mph out of a parking garage he noticed that the steering wheel became difficult to turn. the vehicle was taken to the dealer who replaced the rack and pinion; however, the failure is still occurring. the current and failure mileages were 71000. | |||
| 03/06/2009 | 82000 | ||
| Tl*the contact owns a 2005 kia sedona. while driving approximately 35 mph or less on normal road conditions, the contact exerted much effort to make a left turn. the vehicle steered in one direction. the failure occurred without warning. the contact had to make several attempts to maneuver the steering wheel before it resumed normal operation. the vehicle was taken to an independent mechanic and they stated that the failure was possibly related to the rack and pinion. the failure occurred on two separate occasions. recently, the steering wheel locked up while the vehicle was in operation. there were no juries. the vehicle was towed to the contact's residence. the authorized dealer was notified of the failures and stated that they were contributed to the intermittent joint shaft, which was a common defect. the vehicle has not been repaired. the failure mileage was 82,000 and current mileage was 83,000. | |||
| 10/13/2005 | 8500 | 1 | |
| A regular maintenance at the dealership caused a defect in my vehicle's brakes, a tire rotation defect and a steering problem(vehicle keeps on pulling to the right and brake pedal too soft and almost touches the floor when used-brake ineffective). the dealer did not show any signs of concern about the safety of the vehicle despite several attempts to address the issue. no choice but to contact company's headquarters. *jb | |||
| STEERING - LINKAGES - KNUCKLE - SPINDLE - ARM | |||
| 03/25/2005 | 105000 | ||
| Tl*the contact owns a 2005 kia sedona. the contact stated that while driving 70 mph he felt a vibration when the brakes were applied. when he pulled over he noticed that the front end suspension had fallen apart. the manufacturer was contacted and advised her to take it to a dealer for a diagnostic test. the dealer stated that it was the contacts driving habit that contributed to the front end suspension failing. the vehicle has been repaired four times and is currently waiting for the fifth part to be installed. the dealer replaced the wheel bearings and the knuckle assembly which has fallen apart five times. the failure mileage was 105,000. the current mileage was 123,442. | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 06/16/2005 | 3 | 02/01/2005 | |
| Driving out of spot at parking lot my wife had the steering to hard to turn and the engine was accelerated. she could not turn and hit a car on the driver side front wheel | |||