Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ENGINE AND ENGINE COOLING - ENGINE
TSB-04411/01/200910033464Kia: ecm upgrade with tp sensor replacement-mil on with dtc p2135/p0638. information related to ecm software and tp sensor upgrade on some vehicles with 2.7l engines which may experience a malfunction indicator lamp (mil) illuminated with08/18/2010
04105/01/200810025151Some customers of 2006-2007 sedona (vq), 2007 amanti (gh), or 2007 sorento (bl) may experience a concern of a check engine light (mil) being on. 02 sensor (ho2s) codes. *pe07/14/2008
01209/01/200710022961Sedona (vq) intermittent no-crank condition. *nj10/09/2007
02804/01/200710021664Lambda engine noises. *kb06/15/2007

Consumer Complaints


Fail datemilesoccurencesPurchase date
ENGINE AND ENGINE COOLING
12/12/2011
 I have owned my 2006 kia sedona since jan 2008 and have had a persistent problem of oil leaking from the valve covers and the oil pan gasket. this oil leak issue has been
06/01/201161300
 Kia sedona 2006 - engine stalled on highway, no response from the accelerator - the check engine light came on as well as the 'esc off' light. this can happen when driving in city or highway... extremely dangerous! pulled-over, turned off engine then restarted to correct the problem. dealer states tps (throttle position sensor) and/or accelerator position sensor malfuctioning.
04/14/200834099
 Tl-the contact owns a 2006 kia sedona. the contact was driving approximately between 65-70 mph, the engine warning light illuminated followed by a decease of engine power. the vehicle speed rate would not exceed 20 mph. the vehicle was maneuvered to the side of the road, and the engine was turned off. the vehicle restarted after waiting a period of twenty minutes and resumed normally. the vehicle was taken to an authorized dealer where the active pixel sensor (aps) sensor was replaced. the vehicle was taken to an authorized dealer on four separate occasions for the identical failures. the total components replaced on the vehicle consisted of the aps module poor pin connection, throttle body, and gas pedal assembly. the contact no longer owns the vehicle due to the safety hazard. the failure mileage was 34,099. js
07/01/200839000304/01/2007
 Tl*the contact owns a 2006 kia sedona. while driving 75 mph, the esc indicator illuminated and the accelerator failed on the vehicle. the contact attempted to pull over and the vehicle decelerated. he turned off the vehicle and restarted it, but the failure recurred after driving one mile. the dealer stated that they would inspect the vehicle and reset the esc computer under warranty. the vehicle was repaired twice, but the failure persists. the contact believes this is a big safety hazard. the failure mileage was 39,000 and current mileage was 48,000. updated 4/16/09 *cn updated 04/21/09.*jb
08/27/2008247341
 Our sedona van intermittently looses all power. when this happens the rpm's drop to 1000rpm and nothing happens when you push down the accelerator pedal. this happened 3 times today. the first was upon initial start up. the check engine light and esc off light came on. we turned off the car and when we restarted the check engine light stayed on, but the car had power. we drove it the dealership and they said there were 3 codes all indicating low engine voltage. they cleared the codes and said they found nothing wrong and it should not happen again. latter in the day it happened two more times. both time while it was being driven. once one the highway at 65 mph and once in town at about 40mph. each time we coasted to a stop an turned the car off and back on to get it working again. i will be taking it back to the dealer tomorrow. *tr
03/01/2008164831
 Bought 2006 kia sedona new in 2007. no issues until early 2008 with less than 15k miles. engine light on and sometimes blinking. vehicle stalls when in gear and at a stop. vehicle hesitates when driving, often jerking violently. have had in for warranty service at least four times. many sensors replaced. service provider states kia advised vehicle is drivable even when engine light in blinking. no way for me as a consumer to tell if i am doing damage to engine or other component. stalling and jerking is safety issue. since i did not purchase at my nearest dealer, liberty auto plaza (libertyville, il), they have stated they have done what the can and i should take it up with kia. internet research shows this is common unresolved issue and liberty management was aware of issue. manager plainly stated he did not have issue continuing to sell, yet had no responsibility to inform consumers. at this point, i would like kia to provide mechanically sound car under warranty agreement, replace or refund. can not continue to jeopardize family safety or time. *tr
09/25/200719765109/12/2007
 Heavy rattling coming from tensioners/timing chain (per dealer) when starting the vehicle. after you drive around and park for ten minutes then restart it comes back louder .the dealer says it is normal and that all kia vehicles make this sound .they are going to put in a second set of tensioners to try to get rid of this noise .. *tr
03/21/200714289005/13/2006
 Tl* - the contact has a 2006 kia sedona van. the vehicle has had a knocking sound on the driver's side, under the hood. she was told by a tire manufacturer and a mechanic that the cv joints and motor mounts were causing the knocking sound. from 0 - 5 mph, when she turns or brakes, or when the vehicle moves forward or backwards it makes the knocking sound. the weather is not a factor. the knocking was constant and got louder upon driving the vehicle. the current and failure mileage were both 14,289 miles.
12/26/200675112/26/2006
 I bought my 2006 kia sedona brand new. after taking delivery of it, my family and i took the vehicle home. as we stopped in traffic, we immediately noticed a misfire of the engine. we drove it another mile or so, thinking the glitch would remedy itself. upon stopping at another intersection, we observed the same misfire/trembling as before. not knowing what was happening, we drove home. we took it back to the dealer that same night. the dealer was very apologetic, and offered us a used competitor's minivan as transportation until they resolved the problem. i picked up my vehicle two days later. they had a service bulletin indicating of a potential problem with the spark plugs. knowing this information in advance, the dealership could have avoided an embarrassment by replacing the problem spark plugs on all their minivans, instead of waiting to have an upset customer walk up to them and letting them know there was a problem. service bulletins should be addressed as soon as the dealership receives them, not when there is a problem. *jb
ENGINE AND ENGINE COOLING - COOLING SYSTEM
04/09/2008300001
 Tl*the contact owns a 2006 kia sedona. while driving approximately 45 mph, the engine and esc warning lights illuminated on the instrument control panel. the vehicle lost power and would not accelerate. he took the vehicle to the dealer and a technician repaired the wiring in the electrical system. immediately after the repair, the failure recurred. he took the vehicle back to the dealer for inspection, but they are currently unable to locate the cause of the failure. the manufacturer did not provide any assistance. the failure mileage was 30,000 and current mileage was 31,000. the consumer stated dealer replaced computer module which has corrected the problem. updated 06/02/08 *tr
ENGINE AND ENGINE COOLING - ENGINE
07/24/201195000
 Tl - the contact owns a 2006 kia sedona. the contact stated that gas fumes were emitted into the vehicle. the vehicle was taken to the dealer who diagnosed that the ac module was cracked and needed to be replaced. the manufacturer was made aware of the failure who did not offered any assistance. the vehicle was not repaired. the failure and current mileage was 95,000. pm
06/05/200846536
 Tl*the contact owns a 2006 kia sedona. while stopped at a traffic light, the vehicle suddenly shut off and was unable to be restarted. the day before the failure, the contact noticed that the check oil light was illuminated. the vehicle had to be towed to the dealer, where it is currently being diagnosed. the current and failure mileages were 46,536.