Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN | |||||
16935 | 07/01/2003 | 10003831 | An uncommanded shift to 4x4 low. *tt | 11/04/2003 | |
0282 | 04/29/2002 | 637922 | Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings while in drive, no 2nd gear, no 3rd gear, no engine braking in manual 1st and slipping shifts and / or delayed engagements. *tt | 12/09/2002 | |
15887 | 05/01/2002 | 637755 | Some vehicles may exhibit a no 1-2 upshift, no 2-3 upshift, a no engine braking condition in manual 1 or diagnostic trouble code p0732 (gear 2 incorrect ratio) or p0733 (gear 3 incorrect ratio). *tt | 12/04/2002 | |
991813 | 09/06/1999 | 6090076 | Experiencing an inoperative or inaccurate odometer / speedometer readings. *tt | 03/06/2000 | |
9943 | 03/08/1999 | 604751 | Information regarding reprogramming powertrain control modules (pcms). *tt | 05/11/1999 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
03261 | 01/05/2003 | 10008279 | New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt | 07/26/2004 | |
01137 | 07/09/2001 | 620988 | Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt | 09/05/2001 | |
13725 | 03/01/2001 | 620267 | Some vehicles with a4wd may exhibit a vibration / moan at highway speeds. *tt | 07/23/2001 | |
99152 | 07/26/1999 | 608431 | Information on the new flush and fill tool available through rotunda. *tt | 01/05/2001 | |
12867 | 06/01/1999 | 6092025 | Some vehicles equipped with 4r44e or 5r55e transmission may exhibit slipping shifts, delayed or no engagements. *tt | 11/17/2000 | |
99-6184 | 05/01/1999 | 607003 | Some vehicles may exhibit slipping shifts, delayed or no enggements. *tt | 11/03/2000 | |
0015 | 01/10/2000 | 612203 | Information regarding the new transmission cooler flusher- service tip. *mjs | 06/06/2000 | |
13482 | 11/01/1999 | 610895 | Some vehicles may exhibit a vibration / groan on acceleration or take-off due to the rear transmission mount being twisted and allowing a ground out condition to occur. *tt | 05/18/2000 | |
7353 | 11/01/1999 | 610785 | Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt | 05/15/2000 | |
7468 | 11/01/1999 | 610834 | Some vehicles may exhibit a vibration / groan on acceleration or take off. | 05/15/2000 | |
13412 | 10/01/1999 | 609668 | Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt | 04/06/2000 | |
991610 | 08/09/1999 | 607667 | Concerns with slipping transmission shifts and / or delayed or no transmission engagements may occur on some vehicles. *tt | 10/04/1999 | |
6458 | 06/01/1999 | 606855 | Some vehicles with 4r44e / 5r55e transmissions may exhibit slipping shifts, delayed or no engagements. *tt | 09/03/1999 | |
5814 | 03/01/1999 | 605225 | Service tips for checking transmission fluid level. *tt | 06/04/1999 | |
9946 | 03/08/1999 | 604762 | Concerns with transmission fluid leaking at radiator. *tt | 06/01/1999 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
04217 | 11/01/2004 | 10013369 | General power train control module (pcm) programming procedures. *tt | 04/15/2005 | |
9987 | 05/27/1999 | 621290 | Some vehicles may exhibit harsh downshift from 3rd to 1st gear while stopping, hesitation after acceleration from stop and / or lack of power after acceleration from stop on vehicles with 4.0l or 5.0l engines. *tt | 09/17/2001 | |
9987 | 05/03/1999 | 606407 | Some vehicles may exhibit harsh downshift from 3rd to 1st gear while stopping; hesitation after acceleration from stop; and / or lack of power after acceleration from stop. *tt | 01/22/2001 | |
13091 | 08/01/1999 | 6091893 | Some vehicles with automatic 4 wheel drive (a4wd) may exhibit multiple generic electronic module (gem) functional concerns (i.e., inoperative one touch down, chime, 4x4 shift motor, etc.). *tt | 11/16/2000 | |
12704 | 05/01/1999 | 6091676 | Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt | 11/09/2000 | |
6844 | 08/01/1999 | 608787 | Some vehicles with automatic 4 wheel drive (a4wd) may exhibit multiple generic electronic module (gem) function concerns such as inoperative on touch down, chime, 4x4 shift motor, etc. *tt | 11/08/2000 | |
7494 | 11/01/1999 | 610853 | All vehicles with electronic shift on the fly transfer cases will display contact plate pids opposite of what the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt | 05/16/2000 | |
99147 | 07/12/1999 | 608423 | Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt | 11/24/1999 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
03148 | 07/21/2003 | 10003748 | New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt | 10/29/2003 | |
002310 | 11/13/2000 | 616522 | Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt | 03/05/2001 | |
9946 | 01/01/1999 | 606733 | Concerns with transmission fluid leaking at the radiator. *tt | 09/01/1999 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||||
14586 | 01/01/2001 | 617969 | Some 4.0l vehicles with a4wd built prior to 9/13/99 may exhibit a vibration / pulsation at 0-45 mph on dry pavement under light to moderate acceleration in 4 auto mode which may characteristic with the control trac 4x4 system. *jb | 04/02/2001 | |
13505 | 11/01/1999 | 614630 | All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt | 11/29/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||||
01181 | 09/17/2001 | 625715 | Brake shift interlock.*jb | 11/30/2001 | |
POWER TRAIN - AXLE ASSEMBLY | |||||
030508 | 04/01/2005 | 05620 | 10017891 | Front axle leaks fluid from vent tube - vehicles equipped with 4x4 or awd. *tt | 12/06/2005 |
0358 | 03/17/2003 | 10001922 | Fluid may leak out of the front axle vent tube. *tt *jb | 07/25/2003 | |
0242 | 03/04/2002 | 636056 | Certain vehicles with 4x4 or all-wheel drive may have a fluid leak from the front axle vent tube. *tt | 11/04/2002 | |
01114 | 06/11/2001 | 622642 | Some 4x4 vehicles may exhibit a high-pitched squeal or whistle type noise from the front axle area of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt | 10/22/2001 | |
01411 | 03/05/2001 | 619427 | High-pitched front axle squeal or whistle type noise from the front of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt | 05/30/2001 | |
14819 | 04/01/2001 | 619314 | Some 4x4 vehicles may exhibit a fluid leak from the front axle vent tube. *tt | 05/23/2001 | |
14847 | 04/01/2001 | 619330 | Concerns with vehicles exhbit fluid leakage from the front axle vent tube. *tt | 05/23/2001 | |
0186 | 04/30/2001 | 619276 | On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt | 05/22/2001 | |
13315 | 10/01/1999 | 6092139 | Some vehicles equipped with 5.0l engines and 3.73:1 ratio / 8.8 inch ring gear rear axles may exhibit a whine noise during various drive modes at speeds between 45 to 65 mph. *tt | 11/27/2000 | |
6032 | 05/01/1999 | 6091736 | Some vehicles may exhibit a high pitched squeal or whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt | 11/14/2000 | |
12521 | 03/01/1999 | 6091767 | Vehicles with limited slip / traction-lok rear axles may exhibit a chatter noise while turning. *tt | 11/14/2000 | |
12843 | 06/01/1999 | 606905 | Some 4x4 vehicles may exhibit a high pitched squeal or whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt | 11/08/2000 | |
0083 | 04/17/2000 | 613577 | Some vehicles equipped with a 5.0l engine may exhibit a rubbing noise during right hand turns from the rear of the vehicle. **mr | 07/21/2000 | |
7241 | 10/01/1999 | 6090821 | Vehicles equipped with 5.0l engines and 3.73:1 ratio / 8.8 inch ring gear rear axles may exhibit a whine noise during various drive modes at speeds between 45 to 65 mph. *tt | 03/30/2000 | |
13176 | 09/01/1999 | 6090530 | Information regarding rear axle whine at highway speeds. *mjs | 03/21/2000 | |
6992 | 09/01/1999 | 6090301 | Some vehicles may exhibit a whine noise from the rear axle during various drive modes at highway speeds. *tt | 03/14/2000 | |
12905 | 06/01/1999 | 606937 | Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt | 09/08/1999 | |
5845 | 03/01/1999 | 605233 | Some vehicles equipped with limited slip / traction-lock rear axles may exhibit a chatter noise while turning. *tt | 06/04/1999 | |
5506 | 03/01/1999 | 605189 | Vehicle may exhibit a high pitched squeal / whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt | 06/03/1999 | |
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||||
13752 | 03/01/2001 | 620270 | Some 4x4 vehicles may exhibit an oil leak from the front axle pinion seal. *tt | 07/23/2001 | |
13404 | 10/01/1999 | 6092199 | Some 4x4 vehicles may exhibit an oil leak from the front axle pinion seal. *tt | 11/27/2000 | |
14056 | 04/01/2000 | 613704 | Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr | 07/27/2000 | |
8512 | 04/01/2000 | 613657 | Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr | 07/26/2000 | |
13504 | 11/01/1999 | 610907 | Concerns with vehicles exhibiting an oil leak from the front axle pinion seal. engineering is currently addressing this issue through the high milage / time-in-service concern resolution process. *tt | 05/18/2000 | |
7316 | 10/01/1999 | 609601 | Some vehicles may exhibit an oil leak from the front axle pinion seal. *tt | 04/04/2000 | |
POWER TRAIN - DRIVELINE | |||||
13004 | 07/01/1999 | 610753 | Some 4.0l vehicles with a4wd may exhibit a vibration / pulsation felt from the driveline in the steering wheel and floorpan on acceleration / light tip-in at 25-35 mph when in 4 auto mode. *tt | 05/12/2000 | |
POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||||
13004 | 07/01/1999 | 610753 | Some 4.0l vehicles with a4wd may exhibit a vibration / pulsation felt from the driveline in the steering wheel and floorpan on acceleration / light tip-in at 25-35 mph when in 4 auto mode. *tt | 05/12/2000 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
02138 | 11/10/2003 | 032210 | 635998 | Low line pressure reading at wide open throttle (wot), slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set on vehicles built before 12/1/2001. *tt | 11/04/2002 |
12512 | 03/01/1999 | 6091754 | Brief information on checking transmission fluid level. *t | 11/14/2000 | |
996887 | 08/01/1999 | 608882 | Some 4.0l vehicles with a4wd may exhibit a vibration / pulsation at 0-45 mph on dry pavement under light to moderate acceleration. *tt | 12/06/1999 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
13112 | 08/01/1999 | 6091923 | Vibration on light to moderate acceleration at 0 - 45 mph on a4wd vehicles. *tt | 11/16/2000 | |
13723 | 01/01/2000 | 612712 | Some all wheel drive vehicles may experience a low speed whining noise from the transfer case. *mjs | 06/12/2000 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
POWER TRAIN | ||||||
SQ99017 | FORD MOTOR COMPANY | 06/09/1999 | 02/22/2000 | VEHICLE HESITATION/STALLING | ||
Ford has issued a technical service bulletin, article no. 99-8-7, pertaining to the powertrain control module (pcm) of the explorers, which may be related to this issue.the service bulletin addressed the issues of explorers and mountaineer's harsh downs |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
09/01/2005 | 1 | 10/01/2004 | |
1999 mercury mountaineer developed problems with the windshield wipers, tires, driver's side mirror, linkage on the transmission, check engine light and the airbag light.*mr | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||
5 | |||
This vehicle has been recalled 5 times since purchase, the most recent is for the pcm (00s45), the consumer believes this vehicle was poorly put together and that the manufacturer should provide an extended warranty for the vehicle. nlm | |||
POWER TRAIN - AXLE ASSEMBLY | |||
09/11/1999 | 3 | 04/01/1999 | |
The rear end makes a noise while driving, also during right turns, tried to get it repaired twice before!*ak | |||
POWER TRAIN - DRIVELINE | |||
Defective front axle seals. dt | |||
POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
04/08/2005 | 67000 | 2 | 02/20/1999 |
1999 mercury mountaineer. leak in rear differential at 40,000 miles. replaced pinion seal. at 67,000 miles, a loud, whine emitted from rear axle when driving (regardless of speed) and the mechanic advises us to replace rear differential bearings or entire rear differential. if we don't, we fear the rear axle will fail, causing a crash.*ak | |||
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
05/08/2005 | 54000 | 1 | 06/23/2000 |
Dt: was driving and the suv threw itself into 4 wheel drive low, causing rapid deceleration of vehicle. it was raining and it happened without warning. ford has special service messages #508000 drive line trasfer case concerns. contact has concerns about not being notified by manufacturer about problem.suv is at dealer now and is still under warranty. contact says is is very dangerous when this happens in traffic and rain.*ak | |||
70000 | 7 | ||
Brakes failed seven times within 70,000 miles. an independent mechanic determined that the gem control module was the problem. when the gem control module malfunctioned, the brakes failed, and the 4-wheel drive didn't operate. also, windshield wipers operated intermittently. *ak |