Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SUSPENSION - FRONT | |||||
| ONP95B68 | 05/01/1995 | 45048 | Owner notificaion program 95b68 - deliver stop of ford taurus and mercury sable cars built on may 16, 1995 at the atlanta plant. the left front suspension knuckle to lower arm attachment nut maynot be properly torqued. to correct the pr | 11/01/1995 | |
| 9511 | 01/01/1995 | 39127 | Premature wear on the inner edges of rear tires. *tw | 03/16/1995 | |
| SUSPENSION - REAR | |||||
| BC8890950401 | 04/01/1995 | 3031400 | Unknown | 11/01/1995 | |
| 9556 | 03/01/1995 | 39880 | Premature wear on inner edges of rear tires may be caused by rear camber and toe settings that are not within specification. *tw | 11/01/1995 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| SUSPENSION | ||||||
| RQ99017 | FORD MOTOR COMPANY | 08/09/1999 | 02/16/2000 | FRONT SUSPENSION SPRING | 98V094000 | |
| Odi opened pe97-035 and ea97-026 after receiving four complaints of front spring breakage on 1993 ford taurus vehicles.on may 5, 1998, ford motor company filed a defect information report concerning front spring breakage on 1993 ford taurus and mercury sable vehicles built from august 1, 1992 through july 31, 1993 and registered in 21 states with high corrosion; safety recall 98v-094.odi has received three reports of failed new springs or inadequate protective shields, 17 reports of out of scope front spring fractures, including six tire punctures, and ten reports of shields contacting tires and noise problems to the extent that some dealers are removing the shields.all of the odi reports occurred within the geographic scope of safety recall 98v-094.this rq is to determine the extent of remedy failures and out of scope problems in safety recall 98v-094. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SUSPENSION | |||
| 12/16/2002 | 65000 | 0 | 12/15/1998 |
| I have a 1995 mercury sable that has a bad head gasket. i was told by my mechanic that there was a recall by ford, but after calling and leaving messages, i am unable to confirm this. please advise. thank you! i am also listing numerous problems that have occurred with the suspension and brakes in the last year. | |||
| 03/20/2002 | |||
| While trying to make a turn vehicle slows down on its own. also, is hard to start up vehicle.*ak | |||
| 05/06/2001 | 4 | 06/01/1998 | |
| The front driver side strut spring broke while the car was parked. i had the car towed to be fixed. when the mechanic inspected the other spring 2 of them were cracked and in need of replacement. the car isn't driven hard. it is driven 40 miles a day five days a week.*ak | |||
| SUSPENSION - FRONT | |||
| 03/18/2010 | |||
| Was on my way home from work and heard a loud screech, since i was just down the street from my home i pulled in my driveway and the tire blew. upon inspection i noticed the tire was completly slashed from the front right coil spring breaking. new coil spring strut shock and axle | |||
| 06/17/1999 | 1 | 06/01/1995 | |
| The front spring broke while going at a low rate of speed. the car was completly undrivable and if it was going at a higher rate of speed could have had major problems. this happened 113 miles after the car was at the dealers for a recall that replaced the sub frame mounts for the part that supports the engine and transmission. i feel that while making repairs they cracked the spring, or that springs are made of sub standard materal. | |||
| 03/03/1999 | 1 | 06/29/1998 | |
| Missing bolt from the cv shaft and outer tie rod caused the components to collapse and resulted in abs brake failure and several other component failures. mjs | |||
| 12/04/1996 | 1 | 07/16/1996 | |
| Front end misaligned. | |||
| 02/23/1995 | 3 | ||
| Front end noise/vibration. *skd | |||
| SUSPENSION - FRONT - SHOCK ABSORBER | |||
| 1 | 06/09/1998 | ||
| The shocks and struts failed. *slc | |||
| SUSPENSION - FRONT - SPRINGS - COIL SPRINGS | |||
| 02/21/2008 | 1 | ||
| My daughter had just driven all over the state with her student teaching assignment. she was going to teach for the day when she had tire failure. she had just left from her apartment going 10 mph and about one mile from her place. the coil spring broke jabbing into her tire and causing a blow out. we had to have the car towed and the mechanic said these mecuries and ford sables were good for this kind od a problem. then i got on line and it sais that one point back in 95 that these kind of cars had to have guards to protect the coils from the tires. i am concerned. *tr | |||
| 03/31/2005 | 2 | 08/05/1995 | |
| My 1995 merc . sable .2 months ago my right from spring broke and went through my tire i was able to controle it till we stoped but the car was so bad it needed a tow and $375.00 to fix it.i was told it was a defective spring and should have been recalled.and they have fixed a lot of cars like mine with bad springs.then just today the left front spring broke and again into the tire it went.this time it cost $260.00 to fix it.and again i was told it was a defective spring from factory.this was a diferent auto repair in different state.he also said he thought there was a recall on them.i never got a recall notice from ford deal in hicksvill ohio where the car was bought new??is there a probelm with the springs if so who owes me the cost of fixing it . | |||
| 06/06/2004 | 1 | 05/08/1998 | |
| Car was parked in drive when got in to drive would not move. after inspection we found that the coil spring had sheared off and was laying right by vehicle. upon further inspection found both sides to be broken. car has not been driven rough and was still in good condition otherwise. nothing has been done at this time but contacted dealer and would cost major to repair.*ak | |||
| 11/19/2001 | 1 | 03/24/2000 | |
| While the vehicle was parked, the consumer noticed that the front coil springs were broken. the vehicle was towed to the dealer for inspection. the mechanic informed the driver that the front coil springs were broken and needed to be replaced. please provide further details. *jb | |||
| 01/09/2004 | 133195 | 1 | 11/15/1996 |
| When beginning to back car out of garage, driver's side front coil spring failed. left fender sagged noticeably and piece of spring was found on floor of garage under car. after having car towed to repair shop, investigation showed right side front coil spring to also be broken, but still in place. *la | |||
| 07/09/2003 | 28000 | 1 | 08/28/1995 |
| When the consumer started the vehicle and drove slowly about 50 feet, he discovered the two front coils springs were broke and the vehicle had a flat tire. the coil springs broke due to corrosion. *ak *jb | |||
| 03/11/2001 | 85000 | 1 | |
| While driving the front suspension coil spring had broken and punctured the driver side front tire. ts scc | |||
| 05/07/2002 | |||
| Vehicle was going down the hill and black smoke was coming from rear. driver's front tire blewout due to coil spring slipping down over the strut which pushed up against the tire and puncturing it. dealer was notified. please provide more information.*ak | |||
| 03/23/2002 | |||
| Vehicle was in for a oil change. consumer noticed high beams were not shining right distance. also, dealer noticed that both front coil springs were broken. please provide any further information. consumer felt both coil springs should not have broken at the same time. feels its a manufacturer's defect.*ak | |||
| 02/16/2001 | 1 | ||
| Both front springs broke, causing the front end to come down on the frames.*yd*jg | |||
| 06/26/2001 | 1 | ||
| Front coil springs broke off, mechanic stated this should not have happened, there is a recall 98i002, however it only covers 1993 year sables. *slc | |||
| 1 | 06/24/1996 | ||
| While driving, front coil springs broke, causing front end of the vehicle to drop. *ak lower rear subframe mount plate nut has been replaced. fluctuating speedometer was replaced. starter and wire harness have been replaced. muffler and tail pipe have been replaced. 2 front coil springs and strut bearing plates have been replaced. *slc | |||
| 02/04/2001 | 0 | ||
| While driving out of driveway found out that left front tire was flat. took vehicle to shop for tire repair and found out that front coils spring were broken in two parts, had punchured tire.*ak | |||
| 08/07/1998 | |||
| While driving the passenger's front coil spring broke, puncturing the tire and causing a tire blow out and almost an accident. prolbem similar to previous year model recall. *ak | |||
| 06/15/1998 | |||
| Right front coil spring failed while parked at supermarket. | |||
| SUSPENSION - FRONT - STABILIZER BAR | |||
| 12/18/1996 | 1 | 12/20/1994 | |
| Front stabilizer bar failed. | |||
| SUSPENSION - REAR | |||
| 05/01/1996 | |||
| Constant noise in rear wheels. *ak | |||
| SUSPENSION - REAR - SHOCK ABSORBER | |||
| 1 | 06/09/1998 | ||
| The shocks and struts failed. *slc | |||
| SUSPENSION - REAR - SPRINGS | |||
| A washer was missing from the top left rear strut, causing vehicle to shake. *ak | |||
| SUSPENSION - REAR - SPRINGS - COIL SPRINGS | |||
| 01/03/2007 | 1 | 12/24/1997 | |
| When i took my 1995 mercury sable to a mechanic for an oil change, he notified me that both rear springs were broken. he showed it to me and i saw it for myself. furthermore, one spring had worn a visible groove in the right rear tire. it was dangerous to drive my car further and it must be repaired immediately at a cost of $700. the repair is scheduled for next week and includes rear struts, rear springs and the associated mounting brackets. my mechanic says this is a defect in the steel used for the springs and is a common problem on ford products and they fix a lot of them. *jb | |||
| 11/21/2001 | 1 | 03/24/2000 | |
| The consumer took the vehicle to a mechanic for an inspection. the mechanic informed the consumer that the rear coil springs were broken and needed to be replaced. please provide further details. *jb | |||
| 07/01/2004 | 1 | ||
| While driving, a loud clanking noise was heard coming from the rear. the driver was able to pull over. the driver noticed that the passenger side coil spring sheared off. the driver was able to drive the vehicle to the dealer for inspection. the mechanic informed the driver that the passenger side coil spring needed replacement. please fill in additional information. *jb | |||