Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING | ||||||||||||||||
| 96V016000 | FORD MOTOR COMPANY | from 06/01/1995 to 09/01/1995 | V (Vehicle) | 76500 | 02/21/1996 | MFR | FORD MOTOR COMPANY | 01/25/1996 | 01/30/1996 | 571 | 105 | |||||
| Defect Summary | The brake system fluid level indicator lamp switch can malfunction. this does not comply with fmvss no. 105, hydraulic brake systems. | |||||||||||||||
| Consequence Summary | Consequence of non-compliance: if the switch malfuntions, the brake system warning lamp will either remain illuminated continuously or fail to light as intended when the fluid level falls to a certain level. in either case, the vehicle operator would not be warned of a low brake fluid level condition. | |||||||||||||||
| Corrective Summary | Dealers will replace the brake system fluid level indicator lamp switches. | |||||||||||||||
| Notes | System: brakes; hydraulic; switch; brake warning; fmvss no. 105.vehicle description: passenger vehicles. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, AIR - DISC - ROTOR | |||||
| 9845 | 03/02/1998 | 601264 | Availability of hub-mount brake rotor machining equipment. *yc | 07/15/1998 | |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
| 985A6 | 03/18/1998 | 601004 | Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc | 12/14/2000 | |
| 95212 | 10/01/1995 | 46478 | The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par | 04/25/1996 | |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||||
| BC0251970201 | 01/02/1997 | 51084 | Abs indicator illumination with dtc c1095. *jd | 06/27/1997 | |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
| 99194 | 09/20/1999 | 6090082 | Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt | 03/06/2000 | |
| 985A11 | 03/18/1998 | 601009 | Service tip information regarding elimination of sanding rotors and drums. *yc | 06/17/1998 | |
| BC1012397020 | 01/02/1997 | 51187 | Residual brake presure on the rear brakes of a 1996-1997 vehicle, make sure to support the rear control arms to remain at the normal ride height position- support during lifting process. *jd | 06/27/1997 | |
| BC0144970201 | 01/02/1997 | 51044 | Residual brake pressure on the rear brakes of a 1996-1997 taurus or sable, make sure to support the rear control arms to remain at the normal ride height position. if the rear contral arm on the drivers side is allowed to hang all the way d | 06/27/1997 | |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||||
| 985A13 | 03/18/1998 | 601012 | The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc | 06/17/1998 | |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||||
| 9814 | 01/19/1998 | 605562 | Subject regarding the availability of hub-mount brake rotor machining equipment. *tt | 07/09/1999 | |
| 985A5 | 03/18/1998 | 601003 | Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc | 06/17/1998 | |
| BC0762961016 | 10/16/1996 | 50398 | Repetitive thumping/knocking noise proportional to wheel speed when braking. *tt | 04/24/1997 | |
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE LIGHT | |||||
| 02176 | 09/02/2002 | 10008580 | Lamp-brake-invadvertent disabling of brake shift interlock. *mj | 08/05/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, AIR - SUPPLY - HOSES, LINES/PIPING, AND FITTINGS | |||
| 05/21/2001 | 6 | 01/01/2097 | |
| The outer door handles become inoperable when the vehicle is left in the rain. condition varies from totally inoperable to difficult to open. the vehicle opens easily from the inside. it has also happened once on the front left door. the dealer never heard of that happening before. if you slam the door real hard it fixes itself. when the condition goes away the doors open like new again until another rain. *ak | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 06/06/2007 | 200000 | 1 | |
| The steel brake lines to the rear breaks rusted and my breaks failed. i have looked at three other cars of the same type and tey have the same problem. this could kill someone. *tr | |||
| 70000 | 1 | ||
| Consumer complained about a brake problem. when driving through the rain warning dash lights come on, and the vehicle stalled. *ak | |||
| 04/15/2003 | 67000 | ||
| I have had this car for one year and one half. i bought it from ray hudson chevrolet in la crosse ,wis. i had the car two weeks and the transmission had to be replaced. two weeks after the front and back brakes had to be replaced. this was at the dealers exspense. i had to have a wheel bearing replaced and now after a year and 1/2 i have to replace the whole motor. | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 03/05/2001 | 1 | ||
| While traveling 50mph driver applied brakes, but pedal went to floor and vehicle did not slow down or stop, eventually coming to rest in a ditch. *ak consumer states 3 people were injured in accident. *slc | |||
| 10/10/2000 | 3 | 04/01/1997 | |
| Brakes failed. hard pressure on brake pedal resulted in no braking from a speed of 25mph. car was stopped when it hit a house. damage appears total. abs brakes have failed in two earlier incidents: one required about $800 of repairs and some property damage. car was purchased from ford motor company after the first owner returned the vehicle for brake problems ford certified that the brakes had been repaired to new condition.*ak | |||
| 12/06/1999 | 2 | ||
| Abs system failed causing light to illiminate 2 repairs due to faulty diagnosis on 1st visit. yh | |||
| 11/27/1997 | |||
| In the rain driving 35 mph the vehicle's defective abs system malfunctioned, causing extended stopping distance which almost caused an accident. *ak | |||
| 11/19/1996 | |||
| Abs brakes; when applied brakes lost effectiveness, pedal went to the floor , vehicle went into open throttle position, 12:00 o'clock position, speed 35mp lost control, resulting in an accident. *ak | |||
| 06/02/1996 | 1 | 05/23/1996 | |
| Vehicle caught on fire while parked in the garage. *ak consumer states abs light was coming the day vehicle was purchasd and dealer admtted that it was on but did not say anything, possible cause was fan from abs light.*jb | |||
| 07/08/1996 | |||
| Driving car to get boyfriend, weather rainy, rd slick/wet, cadillac making left turn, applied brakes (abs), car skidded on rd, lost control of car. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 12/31/1999 | 1 | 12/01/1999 | |
| I have a number of worries with my vehicle. the following are: when playing the radio/tape deck, you hear a loud buzzing noise coming through the speakers even if the radio is turned down; when steering from left to right you'll hear a cranking noise coming from the front end of car; car does not absorb bumps at all, it rocks, makes knocking noise coming from somewhere near wheels; when driving on highway at a speed of about 50-70 mph, car will sway, like a wind is blowing it away; feul sensor will float, you can not count on it to tell you how much gas you have; trunk hood flips up in the air so fast and hard, i have stunted my fingers before on it; the doors on the car have a sharp edge to it, if you don't stand back when opening the door, it can gash your leg; wind shield are a blind spot, to long, wipers are so strong they vibrate the car, unusually strong; back window on left side (passenger) will not roll up, or roll down sometimes; assembly of light moldings/fixtures in back of car are off(not evenly lined up), so is the leveling of trunk lid; car jumps when starting it up, like it's ready to pull off, even when your foot is on the brake; when moving the gears the car makes a knocking noise, and jumps also; brake light comes on and goes off at times; car loses power at times, even after the transmission was replaced in february, 2001; keyless alarm system is sensitive, sometimes a inconvience, if you pick keys up and touch the panic, or trunk release button it can be set off in the house, behind a brick wall.*ak | |||
| 10/31/1999 | 1 | 02/01/1996 | |
| Brake shift interlock permitted shift from park with engine running without foot pressure on brake pedal | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DIFFERENTIAL PROPORTIONAL VALVE | |||
| 02/15/1999 | 2 | 07/01/1998 | |
| When car is put on a standard tire shop lift the rear higth sensing valve goes past its limit which allows constant pressure to be applied to rear brakes, and can lead to brake failure in less than 400 miles. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 05/01/1998 | 4 | 12/01/1997 | |
| Rotors of the car continue to warp and i have spoken to many repair shops and they have told me this is a common problem. with the rotors warping this could make braking safely difficult or impossible.*ak | |||
| 09/01/1998 | 1 | 09/29/1998 | |
| Brake rotors warped causing vibration. | |||
| 09/01/1998 | 09/29/1996 | ||
| Driver noticed pulsation/vibration when applying the brakes at highway speed. dealer informed the owner that the front rotors were so badly warped that had to be replaced. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
| 08/13/2006 | 96000 | 1 | 04/01/1997 |
| Dt*: the contact stated the brake lines from the front to the rear of the vehicle rusted causing brake fluid to pour from the tubes. as a result, the brakes failed without warning. the brake pedal went to the floor while traveling at 25 mph on a dry highway. upon inspection of the vehicle, the contact noticed pit holes in the tubes located in the fuel lines where the rust appeared. the vehicle was towed to a dealership to have the brakes repaired. | |||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - VACUUM - HOSES, LINES/PIPING, AND FITTINGS | |||
| 02/16/1999 | 1 | 12/01/1998 | |
| Brake vaccum line broke, resulting in collision. however, the airbag did not deploy on contact. *yc | |||
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING | |||
| Brake system warning lamp remains illuminated continuously. vehicle not included in recall 96v016000. please give any further details. *ak | |||