Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | ||||||||||||||||
06E091000 | AIRTEX PRODUCTS | E (Equipment) | 24358 | 10/18/2006 | MFR | CHRYSLER GROUP LLC | 11/02/2006 | 11/02/2006 | ||||||||
Defect Summary | Certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module. | |||||||||||||||
Consequence Summary | Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759. | |||||||||||||||
Notes | This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | ||||||||||||||||
00V268000 | DAIMLERCHRYSLER CORPORATION | from 02/15/1995 to 09/05/1999 | V (Vehicle) | 1163000 | 01/25/2002 | ODI | CHRYSLER GROUP LLC | 09/13/2000 | 09/14/2000 | |||||||
Defect Summary | Vehicle description: mini vans built with 3.3l and 3.8l engines have fuel rails with nitrole rubber o-ring seals that can degrade over time. fuel leakage from the underhood fuel injection fuel rail could result, increasing the likelihood of a vehicle fire. | |||||||||||||||
Consequence Summary | Fuel leakage in the presence of an ignition source can result in a fire. | |||||||||||||||
Corrective Summary | Dealers will install a seal on the vehicle fuel rails to prevent external leakage of fuel from the fuel rail crossover tube, should the existing o-rings continue to degrade. owner notification began on january 25, 2002. due to the large quantity of vehicles involved in this campaign, the owner notification will be phased over the next several months. however, if a vehicle is leaking fuel from the o-rings, the vehicle should be taken into a dealer to have this repaired as soon as possible. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | |||||
2601000 | 10/01/2000 | 615694 | Information regarding updates to the fuel system service procedures. *tt | 01/28/2001 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
06/04/2004 | 70000 | 1 | |
While driving 10 mph the fuel clamp disconnected from the vehicle. this problem caused the fuel line to leak and as a result the vehicle stalled. the dealership was notified but did not resolve the problem. *nm | |||
08/12/2003 | 36306 | 1 | 03/30/2000 |
Upon starting vehicle accelerated out of the driveway and proceeded about a quarter of a mile down the street. the fuel hose broke, bringing the vehicle to a complete stop. *ak *mr | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
10/31/2003 | 80000 | 1 | |
Engine miss, diagnosed as excess corrosion of fuel line, therefore clogginng injectors.*ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
10/01/2000 | |||
The gas tank gives of a thumping sound when i accelerate from a stop position do you have any information on this. *ak |