Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
030601010 | 03/01/2003 | 10001282 | Engine oil or coolant leak. *tt | 04/25/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
03-06-01-010 | 04/01/2008 | 030601010C | 10004768 | Engine oil or coolant leak. *tt gm reminder. *tt install new lower intake manifold gasket. updated 7/18/08 *pe | 01/06/2004 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
020601014 | 04/01/2002 | 634708 | Subject regarding revised lower intake manifold installation. *tt | 10/07/2002 | |
990604005A | 04/01/2001 | 990604005 | 619360 | Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 05/24/2001 |
990604005 | 02/01/1999 | 776304A | 604343 | Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt | 04/26/1999 |
98576124A | 06/01/1998 | 57-61-24 | 601915 | Comments on a ticking type noise that begins shortly after cold engine start-up and gradually diminishes as the engine warms up. *yc | 08/28/1998 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
01/01/1901 | 1 | ||
1996 pontiac transport van with leaking intake manifold gaskets. consumer states that the internal manifold leaked filling the oil pan up with water which in turn froze the main bearings to the crankshaft, causing the vehicle to lock up at 50 mph. he sent in previous letter about the same problem on another vehicle. *kb the consumer noticed a smell of anti-freeze, but could not locate the problem, because it was internal not external. *jb | |||
10/15/2002 | 88000 | ||
Intake manifold & gasket failure - oil & coolant mixing in engine compartment - imminent engine failure front wiper motor/transmission intermitent failure while driving - difficulty diagnosing problem - major safety issue when the wipers suddenly stop/start working while driving in rain & snow or sloppy highway conditions compressor clutch hub & pulley failure | |||
04/15/2003 | 115000 | ||
Failure of the intake manifold gasket. | |||
06/15/2003 | 0 | ||
After the 2nd valve spring broke, i was told that the valves were seizing up and a new engine would be required. all of this was caused by the bad designed manifold gasket that caused coolant to go into the oil. after spending over $1,000 since 4-29-03, i finally had to trade in for another vehicle. i didn't have between $4,000 and $5,000 for a new engine, which on a '96 model would not have been worth it. i could have gotten a used engine, but all of them have the same manifold gasket and this would have cost aproximately $2,000. i've had nothing but problems with this van. general motors should have taken care of this as a recall, but i guess it was too expensive for them too. | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
08/01/1999 | |||
No summary liksted for abov evehicle. *ak | |||
While driving, noticed engine surging, then heard puff sound, suddenly smoke came out of engine compartment and vehicle caught fire.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
10/15/2002 | 88000 | ||
Intake manifold & gasket failure - oil & coolant mixing in engine compartment - imminent engine failure front wiper motor/transmission intermitent failure while driving - difficulty diagnosing problem - major safety issue when the wipers suddenly stop/start working while driving in rain & snow or sloppy highway conditions compressor clutch hub & pulley failure |