Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
98776304A | 02/01/1998 | 600282 | Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc | 05/05/1998 | |
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
836316 | 07/01/1998 | 615075 | Some vehicles built prior to vin breakpoint wd100162 may exhibit fuel tank thud / clunk type noise audible when accelerating from a stop or during a braking maneuver when the fuel tank is filled between 5/8 and full. *tt | 12/27/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
01/11/2012 | |||
The fuel guage gives false reading, the needle will position way pass the full. after putting in fuel, it will move to the full mark or show just any amount without the tank being full. it is avery hard act to follow especially in these times when i cannot afford to top off the tank. in other words, this fuel guage is very unruly and has its own way in registering what it feels like showjng me. is there a recall?. how can i correct this embarassing situation?. | |||
08/02/2004 | 3 | ||
Consumer complained about having all kinds of problems with vehicle. firstly, transmission malfunctioned, and it was repaired. secondly, power steering fluid was leaking, and consumer kept replacing it. thirdly, there was a gasoline leak, which was repaired.*ak | |||
06/15/2002 | 113000 | ||
Our cyl head gaskets had to be replaced and our cyl heads had to be machined, we also had to replace our fuel pump at the same time | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
07/29/2001 | 5 | 09/01/1997 | |
No summary listed for abov evehicle. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
06/08/2003 | 37000 | 2 | 10/13/1997 |
Fuel pump stopped running, causing engine to quit. happened three times. found connector contacts at both ends of fuel sender harness severely corroded. contacts in fuel tank end of harness fell out when unplugged. dealer has had other customers with same problem. harness is on backorder.*ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
07/16/1999 | 1 | 03/01/1998 | |
The first problem is a clunking in the gas tank when it is over 1/2 a tank but less than full. when coming to a gentle stop, forward or reverse, the tank makes a physical 'thunk'. i have had the vehicle in to repair the problem 5 times now. the dealership has tried isolation pads, tightening fasteners, installing structural bracing straps, and even replaced the gas tank. all to no avail. this problem has been going on for almost 2 years now. i am at a loss as to what to do now. the second problem was with my serpentine belt. i was on my way home from work and i suddenly lost my power steering going into a 90 degree turn. i navigated through it, and the dealer retrieved my van the next morning. they found that the serpentine belt was shredded with no explanation. they replaced it, and i have not had a problem in that area since. | |||
Plastic gas tanks lets fuel inside splash around in tank. when vehicle comes to a stop it feels like another vehicle rearended it. dealer says that's a design flaw. *ak | |||
03/31/1997 | 1 | 02/24/1997 | |
When vehicle is in reverse and backing up fuel slushing occurs.the dealer has replaced the gas tank in march of 97 and problem reoccurs. manufacturer has been notified *ak. consumer has been trying to get vehicle remedied, however has not been successful. *slc | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
Fire started on driver's side of vehicle in the fuel filler area. *ak | |||
FUEL SYSTEM, OTHER | |||
09/01/2001 | 1 | 06/01/1999 | |
1. front heater and defroster only blows cold air. front windshield fogs up considerably. heater system blows warm air in back vents but cold air only in front vents. 2. gas gauge stops working at about < tank. after reaching that level, the gauge pegs to past the full level and does not work again until the tank is filled again. *ak | |||
03/01/1999 | 1 | 05/01/1997 | |
When headlights are turned on at night tail lights do not function. in daytime when headlights are not in use, tail lights will function. this is due to rain getting in tail lights and causing a wiring shortage.*ak consumer states when lights are on, the light at the top of the hutch work, but the tail lights,brake lights, flashers and reverse lights don't work, the radio flashes and the left and right flash light on the dashboard stay on, consumer took vehicle into repair shop and it was determined that the entire harness system was burned out and needed replacement, consumer also stated fuel guage not reading correctly, also abs light and brake light coming on at times. *jb |