Suzuki Suzuki Motorcycle 2002
Model Suzuki Motorcycle made in 2002 by Suzuki got 26 consumer complains. Consumer complaints with reference, among others things, to engine and engine cooling, exterior lighting and fuel system, gasoline.
Model 2002
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||
09/17/2003 | 2800 | 4 | 03/29/2004 |
Front brake pads wore out at 2800 miles. also, head gaskets leaked oil. *ak problem still exists with the head gasket leaking oil. rear shocks sticking on motorcycle and was repaired under warranty. *la | |||
05/06/2003 | 5700 | 1 | 07/07/2003 |
While driving oil leaked onto the rear tire. *nlm the cause was massive crank case pressure in which the motor built up the crank case and poured oil out of the muffler air box into the motor without warning. *scc | |||
04/01/2001 | 600 | 1 | 03/01/2001 |
(suzuki gs650 2002) this complaint concerns the engines of most 2001/2002 suzuki bandit 1200 motorcycles. hundreds of owners have experienced smoking and high oil consumption since buying this motorcycle. they certainly cannot pass epa emissions standards if they smoke. *ts ***dimsii ivoq entry posted after 12-12-02 cut over to artemis***761433 | |||
1915 | 1 | ||
Suzuki motorcycle had an oil leak. the oil leaked due to a crack in the engine case where the bolt hole was positioned on the bottom of the motor (2002 suzuki marauder). *ak *nlm | |||
08/09/2002 | 1500 | 2 | |
The consumer is experiencing problems with oil leaking from underneath the bike, which is coming from the cylinder, the cylinder base gasket has had two failures-which is a common problem with this make/model. mr *scc *nlm | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
06/11/2004 | 1 | 07/11/2002 | |
1. whenever i ride my suzuki sv650s in heavy rain i have a problem. 2. water gets into the front spark plug and the front cylinder misfires or stops firing completely. 3. i have replaced the plug and wire and have attempted to construct a water shield. all of these efforts have failed. water still gets in whenever it rains. two suzuki dealers have told me that nobody else has ever had this problem and yet an online search reveals that riders all over the world are victim to this design flaw.*ak | |||
03/24/2004 | 4000 | 1 | 05/15/2002 |
At 4000 miles on my 2002 suzuki dr650se motorcycle, the cylinder base gasket is leaking oil over the engine and rear of the bike including the rear tire. this could cause the bike to crash if sufficient oil is deposited on the rear tire. as the bike is out of its one year warrenty, suzuki will not cover the costs to repair. suzuki has also updated this gasket to a new type for 2004 which in my opinion, tells me that suzuki acknowledges the problem. this problem is not isolated to me and can be prooven by numerous post on web sites including thumpertalk.com, yahoo dr650 group and many others. it appears that all dr650se's will eventually experience this failure. *ak | |||
01/29/2003 | 1000 | 5000 | 11/16/2002 |
Failure of suzuki motorcycle to replace defective pistons in 2001-2002 suzuki bandit motorcycles (gsf 1200). they issued a tsb saying they would do so if the motorcycle burned more than 1 quart in 600 (not a misprint) miles. that's almost a gallon between oil changes released into the atmosphere. please see suzuki tsb #129. i believe that at that rate of consumption engine seizure at speed could become an issue resulting in injury and death to the rider. see related information at: http://www.maximum-suzuki.com/ibf/index.php?s=95e46471b8a65930a70342cab9325053&act=sf&f=18 | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
03/18/2004 | 600 | 2 | |
When consumer started the vehicle exhaust system leaked oil. consumer saw smoke coming from under the hood. dealership was notified,but did not resolve the problem. *ak | |||
EXTERIOR LIGHTING - HEADLIGHTS | |||
01/09/2004 | 1 | ||
Dangerously poor lighting on the 2002 suzuki bandit 1200s motorcycle. the headlight assembly collects a fine black dust that, over time, builds up on the lens covers to the point that the low and high beam lights no longer provide safe and adequate light to ride by.*ak | |||
11/26/2003 | 1 | 06/03/2002 | |
Poor front lighting which deteriorates over time and miles on 2002 suzuki gsf1200s (bandit). *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
04/01/2002 | 04/01/2002 | ||
The fuel injection system causes surging, stalling, and unexpected engine performance. unable to operate vehicle in safe manner due to uneven and unexpected engine performance. when traveling down the road at a constant rpm, the bike surges backfires, misses, and can not maintain a constant rpm. i have rode two other identical bikes that do not exhibit any of these problems and are safe to drive. suzuki customer service refuses to admit or address that there are problems with certain suzuki dl1000 motorcycle fuel injection systems. dt | |||
04/01/2002 | |||
Engine stalls without cause. dt | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
09/03/2004 | 6500 | 1 | 08/25/2003 |
I have a 2002 suzuki intruder 1500,motorcycle, i recently smelled gas coming from the bike, i then discovered a crack in the fuel tank itself,i am on a 1500 intruder forum and there are aprox. 20 or so others that have experienced have the same crack in the same place on the tank, this is a major defect that the suzuki corp chooses to ignore. others on our forum have contacted them and with no luck, there are a few that had them replaced that were still under warranty, mine is out of warranty but this does seem like a major safety concern. myself and others on the forum,(we all have the exact same bike) feel like suzuki should put out a recall for this faulty weld on the tank, i still have my tank on the bike and have sanded down the crack and applies jb weld to stop the leak, but im not sure how long that will hold. *jb | |||
POWER TRAIN | |||
08/09/2003 | 3100 | 3 | |
Motorcycle transmission slips out of gear: make: suzuki model: intruder lc1500 year: 2002 the motorcycle will slip out of 4th gear and go to neutral without cause or warning. very dangerous situation, especially when driving on the interstate highways with close traffice behind you. | |||
POWER TRAIN - AXLE HUBS | |||
09/05/2003 | 4400 | 5 | 04/12/2003 |
Plase go to this website address on the suzuki volusia motorcycle owners. ://www.volusiaowners.com/messageboard/discussion.asp?topicid=5&discussionid=25339.the problem is a cracked left side wheel hub on several suzuki volusia motorcycles. look at hub pictures on username 'dsrt' webpage. his website address is http://www.volusiaowners.com/members/page.asp?id=1837. the bottom two pictures listed are 'front hub 1' & 'front hub damage 2'. my hub is cracked as are several other volusia owners. i believe the volusia model starts in 2001 and goes through 2003. mine is a 2002. not all volusia owners subscribe to this website and i'm concerned someone is going to get hurt badly or killed.*ak | |||
POWER TRAIN - CLUTCH ASSEMBLY | |||
05/05/2003 | 7000 | 1 | 07/10/2002 |
Suzuki dl-1000 v-strom problem - clutch basket wears out after only a few thousand miles. replaced under warranty, the same problem is starting to happen again after only 3000 miles. this leads me to believe the clutch basket design is defective and should be fixed in a different manner rather than just replacing with the same parts.*ak | |||
04/05/2003 | 200 | 1 | 04/25/2002 |
Failed clutch basket mechanism causing shuddering and poor performance. *ak | |||
06/06/2003 | 19808 | 1 | |
Vehicle exhibits extreme noise and vibration from clutch area. visual inspection shows clucth basket assembly to be extremely sloppy in fit. other owners (reference: http://autos.groups.yahoo.com/group/vstrom2/database?method=reportrows&tbl=4) report clutch basket replacement under warranty resolves similar complaints. but manufacturer is replacing problem part with identical unit. i believe they need to be 'urged' to redesign part properly, and retrofit all affected vehicles.*ak | |||
POWER TRAIN - MANUAL TRANSMISSION | |||
04/10/2004 | 2800 | 1 | 05/05/2003 |
I have had my suzuki vl1500 lc for one year and have ridden 3,000 miles. at around 2,800 miles while on a ride through the hills, the transmission popped out of gear 3 times in one day. all incidents occured while in 4th gear accellerating under normal load. since then, there have been several more occasions where the transmission will pop out of 4th gear into a nuetral under similar circumstances. *ak | |||
06/28/2003 | 7800 | 1 | 05/31/2002 |
Transmission pops out of 4th gear under a pull. *ak | |||
03/15/2003 | 6000 | 1 | 09/17/2002 |
Hayabusa 2002 with 10 k miles is demonstrating a problem that is only recognized at 2nd gear.i broth the bike 3 times to dealer and after many weeks of diagnose and mechanics they confirm the problem.*ak 2nd gear is popping out at 7k rpm and repair dealer wouldnt repair it if a authorization is not sign by me. called suzuki for warranty and the response was that is the way it works. suzuki have the worst warranty. i will never buy another suzuki again. | |||
06/24/2002 | 120 | 21 | 05/22/2002 |
False neutral when shifting. *ak | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
09/17/2003 | 2800 | 4 | 03/29/2004 |
Front brake pads wore out at 2800 miles. also, head gaskets leaked oil. *ak problem still exists with the head gasket leaking oil. rear shocks sticking on motorcycle and was repaired under warranty. *la | |||
STEERING | |||
06/15/2003 | 8500 | ||
Please! help me with information. this is not a car but i use it for transportation. had a slight wobble in front wheel when new. barely there, could only detect at around 45mph without holding grips. less than one year cupped tread, new tire made worse to point dealer said unsafe. dealer has had for almost 3 months still not fixed, may not even know cause. called ga dept. of cons. affairs, you were one of the ref. they gave me. where can i get info., and help? in shop under warrenty mfg. no help so far. 2002 suzuki 600 motorcycle. thank you | |||
SUSPENSION - REAR | |||
09/17/2003 | 2800 | 4 | 03/29/2004 |
Front brake pads wore out at 2800 miles. also, head gaskets leaked oil. *ak problem still exists with the head gasket leaking oil. rear shocks sticking on motorcycle and was repaired under warranty. *la |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
AL | SCOTTSBORO | RIDLEY'S | ||
CA | LOS ANGELES | 90302 | L. H. CYCLESPORTS | |
CT | NORWALK | 06850 | MOTO FIXX 1800 8 DUCATII | |
FL | DAVIE | 33024 | BROWARD MOTOR SPORTS | 954-436-9905 |
FL | MOUNT DORA | 32757 | SUN STATE FUN SPORTS | 352-735-2900 |
GA | LITHIA SPRINGS | 30122 | METRO CYCLES | 770/941-9050 |
GA | NEWNAN | CYCLE CITY POWER SPORTS | ||
TN | ALCOA | HONDA OF ALCOA | 865-970-2710 | |
TX | AUSTIN | 78626 | WOODS FUN CENTER | 512.459.3311 |
TX | HOUSTON | AJ FOYT KAWASAKI/SUZUKI | ||
VA | NEWPORT NEWS | CASEY CYCLE | 757 595-9721 | |
WV | ROMNEY | ROMNEY CYCLE CENTER |